旋流分离器油水分离效率的模拟研究

采用计算流体力学的方法,探讨了操作条件和物料特性对旋流分离器分离油水效率的影响。旋流器为单锥双入口,其主直径为50 mm,锥角为5.5°。模拟过程中,采用商业用软件‘Fluent 6.3’中的雷诺应力模型和欧拉多相流模型来模拟不同条件下油水旋流分离器的分离性能。模拟结果表明,对于本研究的油水旋流分离器,最佳的分流比是10%,最佳的油滴浓度是0.5%(V/V)。在最佳的分流比和油滴浓度下,当进口流速为10.46 m/s时,油水旋流分离器可将15μm的油滴去除80%以上,油滴的分离界限粒径d50(50%的分离效率)为9.2μm。在模拟的基础上,用统计软件STATISTICA6.0对分离效率与操作条件和物料特性之间的关系进行拟合。通过拟合式预测的分离效率与实测值相吻合,误差小于15%。     

Investigation of the hydrodynamic behavior of diatom aggregates using particle image velocimetry

The hydrodynamic behavior of diatom aggregates has a significant influence on the interactions and flocculation kinetics of algae. However, characterization of the hydrodynamics of diatoms and diatom aggregates in water is rather difficult. In this laboratory study, an advanced visualization technique in particle image velocimetry (PIV) was employed to investigate the hydrodynamic properties of settling diatom aggregates. The experiments were conducted in a settling column filled with a suspension of fluorescent polymeric beads as seed tracers. A laser light sheet was generated by the PIV setup to illuminate a thin vertical planar region in the settling column, while the motions of particles were recorded by a high speed charge-coupled device (CCD) camera. This technique was able to capture the trajectories of the tracers when a diatom aggregate settled through the tracer suspension. The PIV results indicated directly the curvilinear feature of the streamlines around diatom aggregates. The rectilinear collision model largely overestimated the collision areas of the settling particles. Algae aggregates appeared to be highly porous and fractal, which allowed streamlines to penetrate into the aggregate interior. The diatom aggregates have a fluid collection efficiency of 10%-40%. The permeable feature of aggregates can significantly enhance the collisions and flocculation between the aggregates and other small particles including algal cells in water.     

苏里格气田气井现状及钻井泥浆的成分、危害

随着苏里格气田天然气探明储量的增加,气田的开发力度逐渐加大,气田开发带给当地的生态环境问题也在凸显。本文介绍了苏里格气田的现状及钻井泥浆的成分及危害,为减少环境危害提供理论依据。     

影响工业废水中BOD_5测定因素的分析与研究

采用稀释与接种法测定工业废水中的BOD5,并结合CODcr的测定结果,分析影响BOD5测定的因素如稀释倍数、接种液配比等条件进行试验后,得出了最佳试验条件,从而达到提高测定BOD5准确度的目的。     

钻井液化学剂可生物降解性评定方法

介绍研究钻井液化学剂生物降解性的必要性及开发可生物降解钻井液的进展。阐述了常用的评定有机物生物降解性的试验方法。推荐采用BOD_5／COD_Cr比值来评定我国石油行业钻井液化学剂及油田化学剂的可生物降解性，规范石油行业生物降解研究工作，保证评定结果的可靠性和可比性。     

深水悬臂桥墩动力特性及地震响应分析

利用ADINA中的势流体单元对一已建成的深水高墩建模,桥梁上部结构对桥墩的影响以墩顶集中质量的形式体现,分别对不同水深条件下桥墩-水体系的动力特性和地震动响应进行了系统的求解;为了检验Morison方程在深水桥墩动力分析中的有效性,将基于忽略速度力项的Morison方程的计算结果与基于势流体的结果进行了比较.研究结果表...     

印刷线路板的超临界流体分离实验

目前印刷线路板(Printed Circuit Board, PCB)的资源化循环利用方法存在材料回收率低和环境污染的不足,采用一种新的超临界流体技术对PCB中的金属及其它成分进行分离处理,在采用丙酮、CO2及Lewis-酸的混合介质及优化的温度和压力反应条件下,获得了90%的金属回收率,高于目前的机械破碎分选实验结果.该方法为线路板的资源化循环再利用提供了一个新的有效选择.     

国产防锈水及其组成成分对鼠伤寒沙门氏菌诱发突变作用的研究

国产防锈水对鼠伤寒沙门氏菌直接试验和加肝微粒体酶试验均能引起TA100菌株突变,并且有剂量-效应关系。对于各主要成分的分别检查表明,工业品亚硝酸钠可能含有的杂质或在贮藏过程中形成的物质对沙门氏菌有直接致突变作用。进一步研究发现,分析纯亚硝酸钠本身Ames直接试验阴性,但使用分析纯的亚硝酸钠与聚乙二醇、三乙醇胺配成的防锈水Ames直接、间接试验均为阳性,这提示亚硝酸钠与三乙醇胺等在一起产生了新的直接或间接的致突变物质,防锈水配方中亚硝酸钠、三乙醇胺的存在可能在体内、体外合成N-亚硝基化合物。     

Application of Neomysis awatschensis as a standard marine toxicity test organism in China

The small mysid crustacean Neomysis awatschensis was collected in the west coast of Jiaozhou Bay, Qingdao, China in 1992 and acclimated and cultured in laboratory conditions since then. Standard acute toxicity tests using 4--6 d juvenile mysids of this species were conducted and the results were compared with Mysidopsis bahia, a standard toxicity test organism used in the US in terms of their sensitivities to reference toxins, as well as their taxonomy, morphology and geographic distributions. Because of its wide distribution along the Chinese coast, similar sensitivity to pollutants as M. bahia, short life history, small size and the ease of handling, this study intended to use N-awatschensis as one of the standard marine organisms for toxicity testing in China. The species were applied to acute toxicity evaluations of drilling fluid and its additives, organotin TPT and toxic algae, and to chronic (life cycle) toxicity assays of organotin TPT and a toxic dinofalgellate Alexandrium tamarense, respectively. Using N. awatschensis as a standard toxicity testing organism in marine pollution assment in China is suegested.     

First-trimester amniotic fluid and extraembryonic coelomic fluid acetylcholinesterase electrophoresis

Acetylcholinesterase (AChE) gel electrophoresis was performed on samples of amniotic fluid and extraembryonic coelomic fluid obtained by high resolution transvaginal ultrasound-guided amniocentesis from 38 women between 8 and 12 weeks of pregnancy. AChE was positive in 33 per cent (12/36) of the amniotic fluid samples; the percentage of positive results decreased as gestation advanced. AChE was positive in 32 per cent (9/28) of the extraembryonic coelomic fluid samples. In 81 per cent (21/26) of matched samples, the AChE results were identical in the two fluids. Amniotic fluid and extraembryonic coelomic fluid AChE electrophoresis cannot be used to diagnose neural tube defects prior to 12 weeks of gestation.