水泥灰三相泡沫的形成机理与稳定性试验研究

针对高硫矿石容易发生氧化自燃的危险,通常的灌浆、注砂、注惰气和喷洒阻化剂等技术还存在一些不足,提出一种以水泥灰为基料的三相泡沫来预防硫化矿石自燃的新技术。该技术是将水泥灰和水按一定的比例混合,同时加入一定比例的发泡剂和稳泡剂后,经物理机械方式发泡形成,集固、液、气三相材料的防灭火性能与一体。理论分析了水泥灰三相泡沫的形成与衰变机理,并通过正交试验,对三相泡沫的发泡倍数与半衰期进行研究,最后采用单因素实验,定量分析灰水质量比,发泡剂和稳泡剂浓度对三相泡沫稳定性能的影响,得到最佳泡沫配方。结果表明:当灰水质量比为1:5,发泡剂浓度为5g/L,稳泡剂浓度为8g/L时,制得的三相泡沫发泡倍数达到6倍,半衰期达到6h以上。     

震后民用建筑重建质量监管机制研究

针对震后民用建筑重建质量监管缺失问题,从政府、社会、责任主体三维视角出发,构建了一套促进重建工程质量持续改进的监管机制,并分析该机制具有时空性、多维性、循环性三大特征。另外,为便于社会力量对震后民用建筑重建工程质量进行监督,构建了一套针对非专业人员的工程质量评价指标体系,并利用模糊综合评价法,通过实例验证了该指标体系的有效性。最后,提出了优化该质量监管机制的建议。     

电磁屏蔽针织服装屏蔽作用的影响因素及机理

本文简述了电磁辐射的危害,论述了电磁屏蔽服装的一般原理。结合前人的研究,针对针织服装特点详细分析了织物厚度、线圈长度、针织组织、服装结构设计等对屏蔽作用的影响规律及机理。最后,提出织物组织结构参数与屏蔽纤维含量、屏蔽纤维之间孔隙的关系,屏蔽纤维含量与屏蔽纤维之间孔隙的合理配置是针织物电磁屏蔽效能研究的关键。同时,进行电磁屏蔽针织服装研究时可以结合人体模型并增加服装结构研究的切入点。     

基于疲劳累积破坏机制的储罐结构动力可靠度分析

针对随机风载荷作用下储罐结构动力可靠性问题,以300 m3的中小型立式低温储罐为研究对象,利用AR模型进行数值模拟得到风载荷的脉动风速时程与脉动功率谱密度函数。采用ANSYS建立储罐三维有限元模型,并对储罐进行动力学分析,计算出储罐结构的随机响应,进而求出随机风载荷作用下储罐结构动力可靠性所需全部数字特征,最后利用疲劳累积损伤机制计算得到储罐的动力可靠度。结果表明:假设结构强度不随时间退化,前5 a动力可靠度基本保持不变,随着使用年限的延长,动力可靠度下降速度明显增大。研究方法可为储罐的动力可靠性及寿命预测提供一定的理论依据。     

爆炸冲击波作用下圆形通风设施的动态破坏特性

为了研究瓦斯爆炸对通风设施造成的严重破坏及其导致的通风系统紊乱与灾情迅速扩展问题,基于LS-DYNA有限元软件,模拟研究巷道中瓦斯爆炸冲击波作用下圆形通风设施的动态破坏特性,分析应力、应变、速度、位移的动态特征及其破坏过程,并对圆形通风设施动态破坏机理进行初步探索。研究结果表明:爆炸冲击波作用下,圆形通风设施正、反面出现压应力与拉应力分布圆环,且压应力与拉应力峰值处于在外部受约束边界径向圆环附近区域与圆心位置,应变、速度和位移最大值均分布在次区域;爆炸冲击波作用下,通风设施表面形成多圈的正向和反向的应变相互交替,呈现W型的褶皱变形;爆炸冲击波作用下,环向裂纹集中在受约束的边界区域附近,发生脆性破坏,其他区域会出现较多的径向裂纹,可发生韧性破坏,整个断裂过程是脆性与韧性断裂的混合型断裂。     

动态惩罚机制下企业安全生产行为演化分析

为揭示动态惩罚机制下企业安全生产行为规律,以企业成本和收益为基础,通过区域内所有企业的博弈,运用演化博弈理论研究不同策略下企业对安全生产投入达标行为演化趋势.研究结果表明:当政府监管能力有约束时,无论企业是否明确预设控制目标,均可能出现投机心理,而政府加大惩罚力度可有效改善整体安全生产水平;同时,企业明确控制目标时,通...     

A Bayesian network-based approach for the assessment and management of ageing in major hazard establishments

Currently, there is an increasing attention towards ageing of industrial equipment, as the phenomenon has been recognised as a cause of severe accidents, recorded in the last years in many process establishments. Recent studies described ageing through a number of key-factors affecting the phenomenon by accelerating or slowing it down. The Italian Competent Authority for the prevention of chemical accidents (Seveso III Directive) adopted a short-cut method, accounting for the assessment of these factors, to evaluate the adequateness of ageing management during inspections at Seveso sites. In this paper, a Bayesian Network was developed, by using the data gathered during the first application of the short-cut method, with the aim to verify the robustness of the approach for ageing assessment and the validity of the a priori assumptions used in assessing the key-factors. The structure of the Bayesian network was established by using experts’ knowledge, whereas the Counting Learning algorithm was adopted to execute the parameter learning by means of the software Netica. The results showed that this network could effectively explore the complex logical and uncertain relationships amongst factors affecting equipment ageing. Results of the present study were exploited to improve the short-cut method.     

Effects of nitrogen and carbon dioxide on hydrogen explosion behaviors near suppression limit

By varying inert gas content, equivalence ratio and initial pressure, this study is aimed at investigating flame propagation behaviors and explosion pressure characteristics near suppression limit. For carbon dioxide, the weakest flame floating phenomenon is observed at Φ = 1.5 and the buoyant instability is enhanced when the equivalent ratio deviates to the rich and lean sides. For nitrogen, the buoyant instability decreases with increasing equivalent ratio. Both maximum explosion pressure and maximum pressure rise rate increase firstly and then decrease with the increase of equivalence ratio, and they decrease significantly with increasing content of carbon dioxide and nitrogen. For carbon dioxide, the critical suppression ratio of Φ = 0.6, 0.8, 1.0, 1.5 and 2.0 is 7.50, 7.18, 5.74, 3.83, and 2.87. For nitrogen, the critical suppression ratio of Φ = 0.6, 0.8, 1.0, 1.5 and 2.0 is 15.83, 11.87, 9.50, 6.33 and 4.75. Compared to nitrogen, the carbon dioxide is more effective on suppressing hydrogen explosion pressure. The adiabatic flame temperature, thermal diffusivity and mole fraction of active radicals continue to decrease with increasing content of carbon dioxide and nitrogen, which contributes to the decrease of laminar burning velocity.     

Research based on double coverage rate and reliability of gas detector layout optimization

The gas detector layout should be highly attuned to combustible gas leakage and attain a good reliability in avoiding detector malfunction, which is an important guarantee for the normal production of the chemical industry and other related enterprises. Herein, a gas detector layout optimization method based on double coverage and reliability is proposed. The key gas leakage monitoring area is determined through layout scene field investigation. To improve the detection probability and detection system reliability, the dual coverage target and voting mechanism are set, and the gas detector layout is determined with the ray-casting algorithm according to the coverage target. Combined with FLACS software to simulate a variety of typical leakage conditions under different layout scenarios, the relationship between the leaked gas concentration detected by gas detectors in each layout scheme and time is obtained, and the gas leakage detection probability in each layout scheme, number of detectors that can trigger the alarm, shortest time to trigger the alarm and reliability are comprehensively evaluated. The decision-maker selects the final gas detector layout plan according to the evaluation results and actual site needs. The study shows that the detection probability of each layout scheme set according to the double coverage is high, and multiple detectors can trigger the alarm (up to 100%), which ensures that the alarm can be triggered within 10 s under all applicable conditions. According to the evaluation results, the decision-maker can obtain a layout scheme that not only agrees with the actual site conditions but also attains a high detection probability, short detection time and strong reliability.     

基于模糊评价的VDT系统搜索策略绩效形成机理研究

为优化视觉显示终端（VDT）结构性搜索界面的布局,提高作业绩效和安全,设计了VDT系统搜索实验,构建了搜索目标位置在4个主观偏好指标下的Pythagorean模糊集决策矩阵,运用交互式多准则决策（TODIM）法计算各目标位置偏好的总体优势度并排序;同时对VDT系统搜索实验中各目标位置的绩效进行方差分析并排序,分析系统搜索策略下作业者对目标位置的主观偏好与绩效之间的关系。研究结果表明:基于系统搜索策略的VDT作业绩效在不同目标位置差异显著;导致绩效差异的根本原因是作业者对搜索目标位置的主观偏好度,而不是搜索目标的位置属性;除中心区域外,偏好度高的区域搜索绩效要优于偏好度低的区域。