次临界操作下的膜污染机理研究

临界通量在膜污染控制的水动力学条件优化中是一个非常有意义的概念。本研究用一种新型的中空纤维膜组件过滤活性污泥混合液 ,采用通量阶式递增法对临界通量进行测定 ,实验表明 ,气水二相流是一个提高临界通量非常有效的方法 ,而且临界通量随着曝气强度的增大而增大 ,根据测定结果 ,可以得出膜生物反应器 (MBR)的 3个水动力学操作区 :超临界区、临界区和次临界区。次临界操作可以防止颗粒物质在膜面上沉积引起的可逆污染 ,在次临界操作下 ,膜污染分为两个阶段 ,第一阶段为不可逆污染发展阶段 ,跨膜压力 (TMP)发展缓慢 ;第一阶段膜的不可逆污染导致膜丝点通量不断的重分配 ,一旦出现膜丝上某一点的通量大于临界通量时 ,颗粒物质就以此点为突破口 ,不断沉积到膜丝表面 ,发生可逆污染 ,膜污染进入第二阶段 ,TMP急剧增加。     

膜蒸馏用于气田采出水的深度处理

采用自制聚丙烯中空纤维疏水膜,开展了内压式真空膜蒸馏处理某气田采出水的实验研究,考察了膜通量、脱盐率、产水电导率及产水水质等随运行时间的变化,针对实验后期出现的膜污染情况对膜蒸馏浓水除硬后进行二段膜蒸馏,再对出水进一步做催化臭氧氧化处理。实验结果表明：105 h后,废水中各离子浓度随着废水的浓缩而急剧升高,同时废水的高硬度造成膜堵塞,产生膜污染;除硬后去除了膜结垢污染,改善了膜疏水性能,膜通量恢复到初始膜通量的73%;膜蒸馏出水经催化臭氧氧化处理后,出水COD、TOC和ρ（NH₄⁺-N）分别为49 mg/L、6.5 mg/L和11.0 mg/L,满足回用要求。     

Co-application of energy uncoupling and ultrafiltration in sludge treatment: Evaluations of sludge reduction,supernatant recovery and membrane fouling control

• Effects of metabolic uncouplers addition on sludge reduction were carried out. • TCS addition effectively inhibited ATP synthesis and reduced sludge yield. • The effluent quality such as TOC and ammonia deteriorated but not significantly. • Suitable dosage retarded biofouling during sludge water recovery by UF membrane. Energy uncoupling is often used for sludge reduction because it is easy to operate and does not require a significant amount of extra equipments (i.e. no additional tank required). However, over time the supernatant extracted using this method can deteriorate, ultimately requiring further treatment. The purpose of this study was to determine the effect of using a low-pressure ultrafiltration membrane process for sludge water recovery after the sludge had undergone an energy uncoupling treatment (using 3,3′,4′,5-tetrachlorosalicylanilide (TCS)). Energy uncoupling was found to break apart sludge floc by reducing extracellular polymeric substances (EPS) and adenosine triphosphate (ATP) content. Analysis of supernatant indicated that when energy uncoupling and membrane filtration were co-applied and the TCS dosage was below 30 mg/L, there was no significant deterioration in organic component removal. However, ammonia and phosphate concentrations were found to increase as the concentration of TCS added increased. Additionally, due to low sludge concentrations and EPS contents, addition of 30–60 mg/L TCS during sludge reduction increased the permeate flux (two times higher than the control) and decreased the hydraulic reversible and cake layer resistances. In contrast, high dosage of TCS aggravated membrane fouling by forming compact fouling layers. In general, this study found that the co-application of energy uncoupling and membrane filtration processes represents an effective alternative method for simultaneous sludge reduction and sludge supernatant recovery.     

膜法处理含油废水研究进展

介绍了含油废水的来源、危害及其一般的处理方法,概述了国内外处理含油废水的膜分离技术——微滤、超滤、反渗透及膜法联合处理工艺的研究现状。对膜污染与预防问题进行了探讨,指出了膜法联合处理工艺是今后处理含油废水的研究方向,而研制抗污染、净化效果好、成本低廉的新型功能有机高分子过滤吸附材料也是含油废水处理领域的一项重要工作。     

纳滤膜脱除矿山酸性废水中重金属离子试验研究

采用纳滤膜法脱除矿山酸性废水中的重金属离子进行了试验研究,讨论了压力、pH、浓差极化、共存离子和膜污染对膜性能的影响。结果表明,在最佳条件下,DK2540纳滤膜对矿山酸性废水中的重金属离子截留率都超过了97%,出水浓度除Cu2+为1.5mg/L外,Ni2+、Zn2+、Pb2+均<0.5mg/L,透过液中的重金属离子基本达标排放,浓缩液可进一步回收利用。     

采油污水对离子交换膜的污染研究

为了缓解油田污水对离子交换膜的污染程度,使电渗析技术更好地用于油田污水处理,从而实现含聚合物采油污水的良性循环,针对含聚采油污水对离子交换膜的污染情况进行了考察.实验考察了相同工况下,淡室溶液电导率下降到0.9mS·cm-1所经历的时间、平均电流和膜面电阻等参数的变化,确定了离子交换膜的污染状况,分别考察了含聚合物采油污水中的固体悬浮物、聚合物和原油对离子交换膜性能的影响.实验结果表明,部分固体悬浮物集聚在阴离子交换膜和阳离子交换膜表面甚至内部从而造成膜污染,但相对于阴膜,悬浮物对阳膜性能的影响更严重;聚合物可聚集在阴膜表面,对于阴膜的透过性有一定的影响;原油在阴膜表面甚至内部形成致密的油膜,对其造成严重污染,但对阳膜的影响较小.利用酸碱液以及非离子表面活性剂(AEO-9)作为清洗剂,并添加少量的助洗剂(如三聚磷酸钠),阴膜过滤能力可以得到有效恢复.     

Effects of different Ca2+ behavior patterns in the electric field on membrane fouling formation and removal of trace organic compounds

The effects of Ca²⁺on membrane fouling and trace organic compounds(TrOCs) removal in an electric field-assisted microfiltration system were investigated in the presence of Na+alone for comparison. In the electric field, negatively charged bovine serum albumin(BSA)migrated towards the anode far away from the membrane surface, resulting in a 42.9% transmembrane pressure(TMP) reduction in the presence of Na+at 1.5 V. In contrast, because of the stronger charge shielding of Ca²⁺     

MBR复合工艺膜污染及其清洗特征

采用“A＋（A／O）n＋MBR”复合工艺,在次临界通量条件下,考察了膜污染发展及清洗特性。试验发现,膜污染随运行时间的变化呈现出阶段性上升的特征,即经过初期缓慢发展和中期较快发展后,出现了膜污染的急剧增加。电镜及能谱分析表明,膜面污染物主要包括沉积于膜面的大量污泥絮体、附着于膜面的致密凝胶层和一些由Ca^2＋、Mg^2＋等离子形成的堵塞和吸附于膜孔的无机垢粒。膜清洗及阻力表明,自来水冲洗可使泥饼层大部分脱落,泥饼层对膜污染阻力贡献最大,达到60.71％;NaClO清洗对凝胶层的去除效果显著,有机污染对膜污染阻力为31.44％;HCl清洗去除的无机垢粒对膜污染贡献率仅为7.85％。     

好氧膜-生物反应器中微滤膜选择的实验研究

用扫描电镜表面观察和全自动压汞仪测定了2种亲水化改性PVDF微滤膜的平均孔径、孔隙率等基本性能参数。对2种膜的纯水通量,及其平板膜组件在好氧膜生物反应器内污染过程进行分析。结果显示,2种膜污染过程均呈现先缓慢后快速的"二阶段"趋势,第二阶段是膜污染的主导阶段。尽管平均孔径小、孔隙率高的膜本身阻力大、纯水通量低,但其污染速率较低,物理及化学清洗恢复率较高。膜孔径及孔隙率指标是影响其在MBR中运行的污染速率的主要因素,平均孔径小、孔隙率高的膜抗污染能力强。     

盐度对膜生物反应器处理含盐废水影响的研究进展

总结了国内外采用膜生物反应器( MBR)处理含盐废水的研究进展,分析了盐度对有机物去除的影响、对脱氮效果的影响、对总磷去除的影响以及对微生物活性和膜污染的影响.指出当前MBR处理高盐度废水的研究热点主要是如何降低对各类功能微生物活性的抑制作用,以及降低溶解性微生物产物、胞外聚合物的释放量,从而减轻膜污染,但目前大多数的研究仍处在实验配水阶段.最后还对今后的研究方向进行了展望.