城市垃圾焚烧渗沥液中Ca2＋对厌氧EGSB处理效果的影响

研究了城市生活垃圾焚烧厂渗沥液中Ca2＋对厌氧颗粒污泥膨胀床反应器（EGSB）处理效果的影响,并采用静态实验方法考察了Ca2＋对厌氧颗粒污泥产甲烷活性的影响。实验结果表明,进水COD为17000mg／L的条件下,当Ca2＋浓度低于6000mg／L时,EGSB对COD去除率达93％以上;当Ca2＋浓度高于6000mg／L时,COD去除率随运行时间明显下降,并在污泥中形成大量沉淀。静态实验结果表明,废水中低浓度Ca2＋促进了厌氧颗粒污泥的产甲烷活性,但高浓度Ca2＋明显抑制了其产甲烷活性,这是导致高Ca2＋浓度条件下EGSB对COD去除率降低的主要原因。研究表明,颗粒污泥产甲烷活性恢复程度随Ca2＋浓度增加而减弱。     

危险废物焚烧处置项目竣工环境保护验收监测要点

对危险废物焚烧处置项目竣工环境保护验收监测中尚需明确的要点进行了剖析,并从入炉危废种类及比例、焚烧量的控制、助燃剂加入量、空气过剩系统的把握,以及安全管理检查要点等方面,提出相应的解决办法。     

垃圾焚烧飞灰对染料（亚甲基蓝）的吸附性能

以垃圾焚烧飞灰为吸附剂对亚甲基蓝进行了吸附脱色实验。主要探讨了飞灰粒径、用量、温度、pH值和初始浓度等因素对亚甲基蓝吸附的影响,同时分析了吸附上清液中重金属Pb和Cr的浸出毒性。研究结果表明,在25—45℃、pH值2～12、飞灰用量1～5g范围内,经过180min吸附,亚甲基蓝的脱色率都达75％以上,最高可达99．46％。实验还得出,除重金属Pb外,吸附上清液中重金属的浸出量远远低于《危险废物鉴别标准浸出毒性鉴别》的限定值。因此,若能降低重金属Pb的浸出,飞灰将具有应用于处理染料废水的巨大潜力。     

垃圾焚烧飞灰中不同粒径的毒性特性

对广州市某垃圾焚烧发电厂的焚烧飞灰进行粒径分级毒性分析研究。主要研究了粒径在35～1 000μm范围内的飞灰的腐蚀性和短期浸出毒性,包括Cr、Cd、Mg、Pb、Mn、Fe、Cu、Zn、Ni、Co等重金属,SO24-,Cl-,NO3--N和NO2--N,同时也研究了飞灰的物质组成和矿物特性。研究结果表明,所有粒径飞灰的浸出液pH值在12.3～12.5之间,属于有腐蚀性的危险废物,重金属Mg、Pb、Zn的浸出浓度最高,分别为168.78、53.94和86.40 mg/L。飞灰浸出液和含量最高分别达到8.87g/L和1.38 g/L,同时浸出液中测出一定量的硝态氮和亚硝态氮,证明飞灰吸附了垃圾焚烧过程中产生的氮氧化物气体。另外,研究得出飞灰的基本组成元素为Ca、Si、Cl、K、Na、S、Al、Mg和Fe,而重金属则以Zn、Pb、Mn、Cu、Cr等为主。矿物相主要为含硅和钙的化合物及NaCl和KCl等氯化物。     

医疗废物回转窑焚烧线中二恶英的生成

通过采集医疗废物回转窑焚烧生产线不同部位的烟气的二恶英样品,研究了医废焚烧过程二恶英在焚烧线200～600℃区间不同烟道断面烟气中分布变化情况。研究结果表明,医疗废物焚烧后烟气中二恶英的发生浓度要高于一般的生活垃圾焚烧烟气的浓度,大致在5～23.3 ng TEQ/m3的范围,锅炉出口到脱酸塔入口段的管道和设备为烟气中二恶英重新合成的高发区域,医废焚烧烟气中二恶英(TEQ)主要是以气态污染物的形态存在。     

600 t/d新型污泥喷雾干化-焚烧 示范工程污染物去除效果

新型污泥喷雾干化-回转窑焚烧工艺是将脱水污泥通过雾化喷嘴形成滴雾后与高温烟气并流接触达到干化后再进行焚烧的集成技术.干化过程中湿污泥中有机物的挥发及该新型工艺的运行工况和污染物减排效果成为污泥处理处置领域关注的焦点.在对污泥喷雾干化焚烧工艺原理分析基础之上,对我国600 t/d新型污泥喷雾干化焚烧示范项目进行封闭式现场取样监测,通过成分分析、毒性监测等重点对污染物去除效果进行了研究,结果表明,该工艺通过自动控制可将出口烟气温度和干化污泥温度保持较稳定的状态,分别为(96±10)℃和(72±8)℃;喷雾干化塔内不存在粉尘爆炸危险,TVOC＜0.025 mg/m3;直接干化热利用率＞80％,优于间接干化;烟气排放口各指标均满足《生活垃圾焚烧污染控制标准》(GB18485-2001)的要求.     

Experimental evaluation of PCDD/Fs and PCBs release and mass balance of a WTE plant

The behaviour of waste incineration plants with respect to organic toxic trace contaminants such as PCDDs, PCDFs and, to a minor extent, PCBs, is still a matter of concern for the public opinion and the decision makers. It is therefore very important, first, to evaluate the release of these organic toxic trace contaminants in the environment during waste incineration, not only through the stack gas emission but also with the solid and liquid residues, and then to compare the total release with the input through the treated waste in order to assess the plant behaviour as a “sink” rather than a “source” of organic toxic trace contaminants. The experimental investigation carried out on an Italian full scale incineration plant has shown a total 17 PCDD/Fs and 12 dioxin-like PCBs release of 5.5-27 μg WHO-TEQ per tonne of treated waste and an input flux of 1.6-44 μg WHO-TEQ per tonne of waste, with the difference between the input and the output fluxes rather small and the plant behaviour toward organic trace toxic contaminants in average neutral. Results are compared with similar evaluations conducted in the last decade on a number of waste-to-energy (WTE) plants operating in Italy.     

我国生活垃圾焚烧工程分析

分析了我国生活垃圾的基本特征、垃圾焚烧厂的效益和垃圾焚烧厂的现状,展望了我国垃圾焚烧工程的发展趋势。     

Thermal removal of PCDD/Fs from medical waste incineration fly ash--effect of temperature and nitrogen flow rate

The fly ash used in this study was collected from a bag filter in a medical waste rotary kiln incineration system, using lime and activated carbon injection followed by their collection as mixed fly ash. Experiments were conducted on fly ash in a quartz tube, heated in a laboratory-scale horizontal tube furnace, in order to study the effect of temperature and nitrogen flow rate on the removal of PCDD/Fs. Results indicated that in this study PCDD/Fs in the fly ash mostly were removed and desorbed very little into the flue gas under thermal treatment especially when the heating temperature was higher than 350 °C, and dechlorination and destruction reactions took important part in the removal of PCDD/Fs. However, in terms of flow rate, when flow rate was higher than 4 cm s⁻¹, destruction efficiency of PCDD/Fs decreased dramatically and the main contributors were P₅CDF, H₆CDF and H₇CDF desorbed to flue gas, the PCDD/Fs in the fly ash decreased with enhanced flow rate.     

从荷兰、德国的实践看污泥的能源回收利用——浅议污水厂的污泥处理

进入21世纪后,随着城市发展和环境污染的加剧,我国城镇污水处理厂的建设开始加速发展。至2010年,城市污水处理率约为70%,随着大量污水处理厂投入运行,污泥处置问题已经迫在眉睫。本文介绍了荷兰污泥处理的发展历程和方法,以SNB污泥处理中心、慕尼黑Gut Groβlappen污泥处理厂为实例介绍了集中式污泥处理及能源利用。我们认为,荷兰、德国污泥处理的经验和方法对我国的污泥处理具有借鉴价值。