林可霉素菌渣与牛粪联合堆肥实验研究

抗生素菌渣因含有抗生素残留而成为一种较难处理的废弃物,不合理的处理方法极易造成环境污染和生态危害,同时也会造成资源浪费.为了探讨林可霉素菌渣堆肥化处理的可行性,设计了林可霉素菌渣与牛粪的联合堆肥实验.4个堆肥处理的林可霉素初始含量分别为1.35 mg/g(干重)、1.89 mg/g(干重)、3.52 mg/g(干重)和...     

添加小麦秸秆对猪粪高温堆肥腐熟进程的影响

选用猪粪与小麦秸秆为堆肥原料进行高温好氧堆肥实验,研究添加小麦秸秆对猪粪高温好氧堆肥过程中堆体温度、pH值、种子发芽指数、碳氮比和养分等理化指标的影响,寻求猪粪高温堆肥时的最佳秸秆配比,旨在为猪粪快速资源化利用提供科学依据。结果表明,猪粪高温堆肥时添加小麦秸秆可以缩短进入高温发酵阶段的时间,减少氮素损失,加快C/N的降低速率,加速有毒有害物质分解。其中猪粪和小麦秸秆6∶4处理各层温度在2~5 d内上升至50℃,并持续37~46 d,在堆肥结束时,有机质和速效氮含量较堆肥初期下降幅度最小,分别为33.90%和23.76%,全氮、全磷、全钾、速效磷和速效钾含量较堆肥初期提高幅度最大,分别为13.34%、20.24%、53.19%、41.53%和16.57%。若以种子发芽指数80%作为堆肥腐熟的评价指标,猪粪和小麦秸秆6∶4配比堆肥的腐熟速度比纯猪粪快18 d,36 d即可腐熟。综合判断,实际应用中,猪粪与小麦秸秆按体积6∶4进行堆肥较为适宜。     

牛粪堆肥腐殖质的动态变化研究

牛粪堆肥实质是有机物质分解的同时形成腐殖质的过程。本研究通过向牛粪中接种发酵微生物进行堆肥,研究分析了总有机碳含量、总腐殖酸、游离腐殖酸和水溶性腐殖酸等的腐殖质物质含量的动态变化。研究结果表明：在牛粪发酵过程中,总有机碳含量呈明显降低趋势,发酵微生物处理下的下降幅度明显大于不接种发酵微生物的处理;总腐殖酸、游离腐殖酸和水溶性腐殖酸含量在发酵前期呈明显的降低趋势,但至发酵腐熟期又逐渐升高。发酵前期,外源微生物的处理,使其下降幅度明显大于不接种外源微生物的处理,但在发酵腐熟期变化不大。     

Microwave Pretreatment for Enhancement of Phosphorus Release from Dairy Manure

Both the advanced oxidation process (AOP) using a combination of hydrogen peroxide addition and microwave heating (H₂O₂/microwave), and the microwave heating process were used for solubilization of phosphorus from liquid dairy manure. About 80% of total phosphate was released into the solution at a microwave heating time of 5 min at 170°C. With an addition of H₂O₂, more than 81% of total phosphate could be released over a reaction period of 49 h at ambient temperature. The AOP process could achieve up to 85% of total phosphate release at 120°C. The results indicated that both the microwave, and the AOP processes could effectively release phosphate from liquid dairy manure. These processes could serve as pretreatments for phosphorus recovery from animal wastes, and could be combined with the struvite crystallization process to provide a new approach in treating animal wastes.     

Treatment of dairy manure using the microwave enhanced advanced oxidation process under a continuous mode operation

The microwave enhanced advanced oxidation process (MW/H₂O₂-AOP) was used to treat dairy manure for solubilization of nutrients and organic matters. This study investigated the effectiveness of the MW/H₂O₂-AOP under a continuous mode of operation, and compared the results to those of batch operations. The main factors affecting solubilization by the MW/H₂O₂-AOP were heating temperature and hydrogen peroxide dosage. Soluble chemical oxygen demand (SCOD) and volatile fatty acids (VFA) increased with an increase of microwave (MW) heating temperature; very high concentrations were obtained at 90°C. Insignificant amounts of ammonia and reducing sugars were released in all runs. An acidic pH condition was required for phosphorus solubilisation from dairy manure. The best yield was obtained at 90°C with an acid dosage of 1.0 %; about 92 % of total phosphorus and 90 % of total chemical oxygen demand were in the soluble forms. The MW/H₂O₂-AOP operated in a continuous operation mode showed pronounced synergistic effects between hydrogen peroxide and microwave irradiation when compared to a batch system under similar operating conditions, resulting in much better yields.     

Measuring and modeling nitrous oxide and methane emissions from beef cattle feedlot manure management: First assessments under Brazilian condition

Intensive beef production has increased during recent decades in Brazil and may substantially increase both methane (CH₄) and nitrous oxide (N₂O) emissions from manure management. However, the quantification of these gases and methods for extrapolating them are scarce in Brazil. A case study examines CH₄ and N₂O emissions from one typical beef cattle feedlot manure management continuum in Brazil and the applicability of Manure-DNDC model in predicting these emissions for better understand fluxes and mitigation options. Measurements track CH₄ and N₂O emissions from manure excreted in one housing floor holding 21 animals for 78 days, stockpiled for 73 days and field spread (360 kg N ha^?1). We found total emissions (CH₄ + N₂O) of 0.19 ± 0.10 kg CO₂eq per kg of animal live weight gain; mostly coming from field application (73%), followed housing (25%) and storage (2%). The Manure-DNDC simulations were generally within the statistical deviation ranges of the field data, differing in ?28% in total emission. Large uncertainties in measurements showed the model was more accurate estimating the magnitude of gases emissions than replicate results at daily basis. Modeled results suggested increasing the frequency of manure removal from housing, splitting the field application and adopting no-tillage system is the most efficient management for reducing emissions from manure (up to about 75%). Since this work consists in the first assessment under Brazilian conditions, more and continuous field measurements are required for decreasing uncertainties and improving model validations. However, this paper reports promising results and scientific perceptions for the design of further integrated work on farm-scale measurements and Manure-DNDC model development for Brazilian conditions.     

Bioenergy production from diluted poultry manure and microbial consortium inside Anaerobic Sludge Bed Reactor at sub-mesophilic conditions

In this study, anaerobic treatability of diluted chicken manure (with an influent feed ratio of 1 kg of fresh chicken manure to 6 L of tap water) was investigated in a lab-scale anaerobic sludge bed (ASB) reactor inoculated with granular seed sludge. The ASB reactor was operated at ambient temperature (17–25°C) in order to avoid the need of external heating up to higher operating temperatures (e.g., up to 35°C for mesophilic digestion). Since heat requirement for raising the temperature of incoming feed for digestion is eliminated, energy recovery from anaerobic treatment of chicken manure could be realized with less operating costs. Average biogas production rates were calculated ca. 210 and 242 L per kg of organic matter removed from the ASB reactor at average hydraulic retention times (HRTs) of 13 and 8.6 days, respectively. Moreover, average chemical oxygen demand (COD) removal of ca. 89% was observed with suspended solids removal more than 97% from the effluent of the ASB reactor. Influent ammonia, on the other hand, did not indicate any free ammonia inhibition due to dilution of the raw manure while pH and alkalinity results showed stability during the study. Microbial quantification results indicated that as the number of bacterial community decreased, the amount of Archaea increased through the effective digestion volume of the ASB reactor. Moreover, the number of methanogens displayed an uptrend like archaeal community and a strong correlation (?0.645) was found between methanogenic community and volatile fatty acid (VFA) concentration especially acetate.     

Assessment of a composting process for the treatment of beef cattle manure

The intensive breeding of beef cattle in Juncosa de les Garrigues (Catalonia, Spain) leads to the production of a large volume of manure that needs appropriate management. Land application in the area at agronomic rates is not enough to ensure good management practices, making necessary extended on-farm storage and the export of part of the production to long distances. In this context, the implementation of a collective treatment based on composting could help in enhancing the handling of manure. We assessed a full-scale composting process based on turned windrows (W), and involving treatment of beef cattle manure (CM) alone (two typologies were considered according to carbon-to-nitrogen ratios of ~25 (CM1, W1) and ~14 (CM2, W2)), or mixed with bulking agent (CM2/BA, W3) and dewatered digested sewage sludge (CM2/BA/DDSS, W4). Composting significantly improved the transportability of nutrients (final volumes were 40–54% of the initial volume). Temperature >55°C was reached in all the treatments but following different time patterns. Under the applied conditions of turning and rewetting, 14 weeks of processing did not ensure the production of stable, and mature, compost. Thus, only compost from W1 attained the maximum degree of stability as well as concentration of ammonium–N < 0.01% (with ammonium–N/nitrate–N ratio of 0.2) and low phytotoxicity. However, high pH, salinity, and heavy metal contents (Cu and Zn) may limit its final use. Addition of BA was advised to be kept to minimum, whereas use of DDSS as a co-substrate was not recommended in agreement to the higher loss of N and levels of heavy metals in the final compost.     

Effect of application of phosphate and organic manure-based fertilizers on arsenic transformation in soil columns

The mobility of arsenic in Cambisol under the influence of added barnyard manure and application of a phosphate solution to the soil was described on the basis of column experiments. A soil sample containing 126 mg/kg total As and 3.72 mg/kg specifically-sorbed As was extracted using demineralized water (DIW) or a 28 μmol/l phosphate solution in a column containing untreated soil and in a column with added barnyard fertilizer. The pH, Eh, alkalinity, main components, including DOC, and selected trace elements (Al, Mn, Pb, Cu, Zn, Cd, Cr, Co, Ni, Ba and As) were determined in the extracts. Hydrodynamic tests of the flow and transport of the substances in the columns were carried out. The addition of barnyard manure was manifested in elevated concentrations of the main inorganic components, DOC and Al and a decrease in the Eh value and Mn concentration. Application of a phosphate solution was manifested in a decrease in the NO₃ and SO₄ concentrations, probably as a result of the effect of increased biological fixation. The As concentration in extracts varied from 8.8 to 15.5 μg/l and was not dependent on the composition of the extracting solution or the addition of barnyard fertilizer.     

牛粪与小麦秸秆混合高温堆肥的腐熟进程研究

通过研究牛粪与小麦秸秆混合高温堆肥的腐熟进程,寻求最佳的堆肥体积比,旨在为农业废弃物快速资源化利用提供科学依据。将牛粪与小麦秸秆分别按体积比10∶0、8∶2、6∶4、4∶6、2∶8混合,高温堆肥64d,研究各种处理下堆肥进程。结果表明,与纯牛粪高温堆肥相比,添加小麦秸秆可以加快堆肥升温速度,抑制高温堆肥前期pH的升高和氨气挥发,减少氮素损失,加速堆肥内有毒有害物质分解,加快C/N降低速率。其中牛粪和小麦秸秆以6∶4的体积比混合高温堆肥时效果最好,堆肥结束时有机质和速效氮下降幅度最小,分别为31.84%和18.18%,全氮、全磷、全钾、速效磷和速效钾的提高幅度最大,分别为15.86%、13.64%、9.42%、22.73%和29.30%。若以种子发芽指数80%作为堆肥腐熟的评价指标,牛粪和小麦秸秆按6∶4体积比混合高温堆肥43d即可腐熟,比纯牛粪腐熟提前了12d。综合判断,实际应用中牛粪与小麦秸秆按6∶4体积比进行高温堆肥较为适宜。