Dynamic-risk-informed safety barrier management: An application to cost-effective barrier optimization based on data from multiple sources

An integrated approach for performance assessment and management of safety barriers in a systemic manner is needed concerning the prevention and mitigation of major accidents in chemical process industries. Particularly, the effects of safety barriers on system risk reduction should be assessed in a dynamic manner to support the decision-making on safety barrier establishments and improvements. A simulation approach, named Simulink-based Safety Barrier Modeling (SSBM), is proposed in this paper to conduct dynamic risk assessment of chemical facilities with the consideration of the degradation of safety barriers. The main functional features of the SSBM include i) the basic model structures of SSBM can be determined based on bow-tie diagrams, ii) multiple data (periodic proof test data, continuous condition-monitoring data, and accident precursor data) may be combined to update barrier failure probabilities and initiating event probabilities, iii) SSBM is able to handle uncertainty propagation in probabilistic risk assessment by using Monte Carlo simulations, and iv) cost-effectiveness analysis (CEA) and optimization algorithms are integrated to support the decision-making on safety barrier establishments and improvements. An illustrative case study is demonstrated to show the procedures of applying the SSBM on dynamic risk-informed safety barrier management and validate the feasibility of implementing the SSBM for cost-effective safety barrier optimization.     

气井完整性概念初探及评价指标研究

针对目前国内外尚无明确的气井完整性概念和生产气井完整性评价指标体系的现状,分析了现有的关于气井完整性解释的不足,初步提出了气井完整性的概念,强调了气井完整性是气井处于地层流体发生无控制流动的风险在可接受范围之内的状态。并根据此概念,从完整性管理、屏障设备、监测状态三个方面,建立了气井完整性评价指标体系,分析了各个评价指标与气井完整性的关系。屏障设备完整性是气井完整性的核心,完整性管理是提高气井完整性的关键,监测状态是气井完整性最直接的判断依据。     

阻挡放电联合金属氧化物催化降解H2S的研究

采用介质阻挡放电联合金属氧化物催化降解气态H2S,考察了单组分及复合金属氧化物催化剂、催化剂与低温等离子体结合方式对H2S及副产物O3去除性能的影响,分析了等离子体联合Mn复合金属氧化物催化降解H2S机理。结果表明,金属负载量相同条件下,电压低于22kV时,Mn复合金属氧化物对H2S的催化活性高于单组分Mn金属氧化物,催化活性及对O3的分解能力从大到小依次为:Ag+Mn、Cu+Mn、Fe+Mn、Mn。当电压为18 kV时,Ag+Mn、Cu+Mn、Fe+Mn复合催化剂分别比单组分Mn催化剂对H2S的去除效率提高了近10%、6%、4%。等离子体后催化区域中Mn催化剂催化氧化H2S的效率明显低于等离子体催化区域。Mn催化剂在等离子体后催化区域中能有效催化分解O3。随着电压的升高,Mn金属氧化物在等离子体后催化区域对H2S催化作用逐渐增强。在电压22 kV时,等离子体联合后催化比单独等离子体作用时,H2S去除效率提高了近11%。     

商业区与轻轨站厅开口处防火分隔失效时人员安全疏散评估

针对相连接部位开口处的防火分隔失效时人员能否安全疏散进行评估,研讨人员安全疏散评估过程中所采用的定性分析和定量分析方法。以某商场与轻轨站相连接开口处为例,考察当防火分隔耐火性能失效后,商场内人员和轻轨站的人员能否从火灾中得以安全疏散;通过火灾模拟的方法,采用BuildEvac和FDS软件分别对火灾时人员疏散状况和火灾烟气的蔓延情况进行人员疏散模拟和火灾烟气运动模拟。根据模拟计算结果,对商场内人员和轻轨站人员的安全性进行详细分析和讨论,从而得出实例评估结论:当排烟系统正常工作时,即使防火分隔(防火卷帘)失效,火场环境对商业区和轻轨站的人员生命安全在整个疏散过程中均不会构成威胁,所有人员都能安全疏散到安全地点。     

隔声屏障对街道峡谷污染物扩散的影响

对带有隔声屏障的街道峡谷内流场和污染物浓度场进行了数值模拟,探讨了风速、隔声屏障高度及与建筑物间的距离对流场及污染物扩散的影响。模拟结果显示:街谷内由1个稳定的主涡及街角两侧隔声屏障所在区域的3个附属涡组成。隔声屏障改变了街谷底部的流型,提高了街谷内的x、y方向速度峰值,但在隔声屏障附近区域x方向速度场明显减弱,这也是污染物聚集原因之一。与无隔声屏障相比,隔声屏障的存在物理性阻隔了污染物扩散路径,提高了街道峡谷内污染物浓度峰值,其中行人高度处背风面污染物浓度升高27.51%~28.72%,迎风面污染物浓度升高11.64%~19.99%。街谷内污染物浓度的分布和峰值由风场、隔声屏障高度及与建筑物之间的距离共同决定。     

方解石活性覆盖系统抑制底泥磷释放的影响因素研究

通过摇床振荡试验和底泥磷释放控制模拟试验,考察了覆盖系统厚度、上覆水Ca2 浓度、温度、方解石粒径以及人工曝气等对方解石活性覆盖系统抑制底泥磷释放效率的影响.结果表明,方解石覆盖系统可以抑制厌氧状态下底泥磷的释放,且抑制效果受覆盖系统厚度、上覆水Ca2 浓度、温度、方解石粒径及人工曝气等的影响.方解石覆盖系统对底泥磷释放的抑制效率随厚度的增加而明显提高,方解石投加量由12.7 kg/m2增加到38.2 kg/m2,模拟期间覆盖系统对底泥磷释放的抑制率则由56%增加到99%;上覆水的Ca2 会增强方解石覆盖系统对底泥磷释放抑制的效率,上覆水Ca2 浓度由1 mmol/L增加到5mmol/L,模拟期间上覆水的磷浓度下降36%左右;对于方解石投加量较少的情况下,高温条件与低温条件相比,底泥向上覆水释放更多的磷,而通过增加覆盖系统的厚度可以消除高温所带来的不利影响;方解石覆盖系统对底泥磷释放的抑制效率随粒径的减小而明显增强;对方解石覆盖系统表面进行人工曝气,不仅可以降低底泥氨氮的释放速率,而且还可以降低底泥磷的释放速率.     

Arsenic and chromate removal from water by iron chips-Effects of anions

The purpose of this study is to estimate the removal efficiency of As and Cr (VI) by one kind of industrial waste — iron chips, as well as to estimate the effects of typical inorganic anions (sulfate, phosphate, and nitrate), and typical organic anions (citrate, oxalate, and humate) on As or Cr (VI) removal. The results showed that 98% of As (V) and 92% of As (III) could be removed from aqueous phase by the iron chips within 60 min. Compared with As species, Cr (VI) was removed much more rapidly and efficiently with 97% of Cr (VI) being removed within 25 min. The removal efficiency for arsenic was in the order: As (III) (sulfate), As (III) (nitrate) or As (III), As (III) (humate), As (III) (oxalate), As (III) (citrate), As (III) (phosphate), and for chromate was in the order: Cr (VI) (sulfate), Cr (VI) (phosphate) or Cr (VI) (nitrate) or Cr (VI) (oxalate), Cr (VI), Cr (VI) (citrate), Cr (VI) (humate). In all the treatments, pH level increased with time except for As (III), the removal of which was either without anions or in the presence of humate or nitrate.     

有毒气体泄漏绕障碍物扩散的安全性分析

介绍了用FLUENT软件数值模拟有毒气体泄漏绕障碍物扩散的方法,并根据伤害区域的划分对障碍物附近的安全性进行分析。基于FLUENT模拟三维瞬态流动的原理,选用标准双方程湍流模型,对有毒气体扩散的不同时段障碍物附近质量分数及安全性分别进行考察,从而归纳出有毒气体绕障碍物扩散及伤害区域分布的一般规律。     

介质阻挡放电中添加乙炔对NO脱除的影响

利用介质阻挡放电(DBD)进行模拟烟气脱除NO实验,通过改变乙炔体积分数和烟气水蒸汽含量研究添加乙炔对NO脱除效率的影响.结果表明:烟气中添加乙炔强化了NO氧化作用,随着乙炔体积分数的提高,NO脱除率逐渐增加.在NO/N2/O2/C2H2/H2O体系中,水的电负性和离解反应消耗大量高能电子,降低了活性自由基的生成,NO脱除速率随之减慢;能量密度低于400 J·L-1时,相对湿度(RH)为0的情况下脱出效果最好.但随着能量密度的增加,H2O不会影响最终的NO脱除率;H2O的添加可以产生更多的·OH自由基,促进NO2向HNO3转化,使出口NO2浓度大幅度降低.     

EK∕PRB修复砷污染土壤影响因素及机理

为明确EK/PRB（电动联合渗透反应格栅）修复As污染土壤过程中各因素的影响机理、提高As的去除效率,以As污染高岭土为研究对象,考察PRB加入、PRB位置、pH调控及腐殖酸强化影响下,EK/PRB系统中电流密度、土壤pH分布和土壤中As残余量、电渗透系数及电渗流的变化规律;探讨EK/PRB修复后土壤中As形态的迁移转化规律.结果表明:①单独EK修复对土壤中As的去除效率较低,加入PRB后去除率为由42%增至57%,并且EK/PRB修复可以将土壤中的As由不容易去除的可还原态转变成较容易去除的酸溶态.②采用盐酸调节阴极pH,可以将土壤中As的去除率由57%增至63%,但同时能耗也明显升高,由5.22 kW·h/g升至39.38 kW·h/g.③添加腐殖酸会促进土壤中As的迁移、提高As的去除效率,但也会增加土壤中难处理的可氧化态和残渣态As的占比.研究显示,EK/PRB除As过程中以PRB的去除作用为主,阴极pH调控及腐殖酸强化均可以提高土壤中As的去除率.