泔脚与秸杆混合发酵法生产蛋白饲料的新工艺流程

利用多菌种混合发酵同时处理泔脚和秸杆2种废弃物,提出了一种生产高蛋白饲料的新工艺流程,并且对该流程初步进行了经济估算。结果表明,在泔脚和稻草秸杆粉按3:1、温度150℃、高压锅中高温湿热酸处理的条件下,经过初步双菌混合发酵试验所得的饲料产品质量为粗蛋白≥25％,粗纤维≤18％,水分≤ 10％,说明新工艺能很好地同时处理泔脚和秸杆2种废弃物,并且大大地提高了秸秆饲料的蛋白含量。处理新工艺流程简单、技术可行,是一种很好的饲料制备方法。     

微生物发酵米糠对Pb~(2+)的吸附研究

利用微生物对米糖进行发酵处理,制备出微生物发酵米糠重金属吸附剂,对微生物发酵米糠吸附Pb2+进行了研究,结果表明,微生物发酵米糠对Pb2+吸附效果好,吸附率可达96.5%。该吸附剂的最佳用量为20g/L。最优吸附条件为:pH4.5,温度30℃,Pb2+浓度不超过50mg/L,最佳吸附时间30min。     

Investigation of biocatalytic potential of garbage enzyme and its influence on stabilization of industrial waste activated sludge

The decomposable waste thrown into the environment can be used to produce value added bio-product which in turn reduces the production of greenhouse gas. Garbage enzyme is one such value added product produced by fermentation of organic solid waste. In the present study enzyme activity and disinfectant potential of garbage enzyme was evaluated and its influence on reduction of total solids, suspended solids and pathogens in dairy waste activated sludge were studied. The result showed the garbage enzyme possesses protease, amylase and lipase activity and reduced 37.2% of total solids, 38.6% of suspended solids and 99% of pathogens in dairy waste activated sludge. This significant result may be helpful for researchers to compare the effectiveness of earth-friendly garbage enzyme treatment of industrial sludge with various physical and chemical pre-treatment methods to improve the biogas production from the sludge digestion unit.     

Performance and fouling mechanism of direct contact membrane distillation (DCMD) treating fermentation wastewater with high organic concentrations

In this study,direct contact membrane distillation(DCMD)was used for treating fermentation wastewater with high organic concentrations.DCMD performance characteristics including permeate flux,permeate water quality as well as membrane fouling were investigated systematically.Experimental results showed that,after 12 hr DCMD,the feed wastewater was concentrated by about a factor of 3.7 on a volumetric basis,with the permeate flux decreasing from the initial 8.7 L/m~2/hr to the final 4.3 L/m~2/hr due to membrane fouling;the protein concentration in the feed wastewater was increased by about 3.5 times and achieved a value of 6178 mg/L,which is suitable for reutilization.Although COD and TOC in permeate water increased continuously due to the transfer of volatile components from wastewater,organic rejection of over 95%was achieved in wastewater.GC–MS results suggested that the fermentation wastewater contained 128kinds of organics,in which 14 organics dominated.After 12 hr DCMD,not only volatile organics including trimethyl pyrazine,2-acetyl pyrrole,phenethyl alcohol and phenylacetic acid,but also non-volatile dibutyl phthalate was detected in permeate water due to membrane wetting.FT-IR and SEM–EDS results indicated that the deposits formed on the membrane inner surface mainly consisted of Ca,Mg,and amine,carboxylic acid and aromatic groups.The fouled membrane could be recovered,as most of the deposits could be removed using a HCl/Na OH chemical cleaning method.     

糖厂废醪农用可行性分析

糖厂废醪废水治理一直是国内制糖业不惜花费较大人力、物力要解决的问题。由于以前技术所限,未得到很好治理或综合利用。本文根据废弃废醪池中废醪液和废醪淤泥有机质和N、P等元素含量较高特点,建议采取有效方式用于农田施肥,既可治理污染,又可对改良农田起到积极的促进作用。     

复合菌种协同发酵混合酒糟最佳C/N的测定

通过测定混合酒糟发酵液初始碳源氮源的含量及复合菌种协同发酵后发发酵液中碳源氮源残留含量，计算复合菌种对碳源氮源的利用率或转化率，研究了最佳C／N的新测定法，同时对细胞干重法作了改进，发酵试验条件为：100mL混合酒糟培养液中接种量10％，温度30．0℃，转速170r/min，摇床培养48h，通过正交试验得绝干菌体质量高达14.693g/L，碳利用率是高灰98．13％，氮转化率最高达78．14％，最佳C／N比为5．1。     

废物乙醇化处理进展

废物乙醇发酵是废物资源化的途径之一,包括废物的预处理,乙醇发酵菌株的选育,乙醇发酵新技术,新工艺的采用等重要内容。同酵母发酵乙醇相比,利用细菌发酵产乙醇具有产率和转化率高,平均发酵速度快等优点,是研究的热点之一,特别是热纤核菌和热糖核菌能直接发酵纤维类废物为乙醇,它们的发现使纤维类废弃物的资源化向前迈进了一大步。同时,人们利用基因工程的手段,改变原菌株的遗传物质,构建“超级菌”,来满足乙醇发酵的要求,同一般发酵技术相比,细胞固定化拄术具有使发酵过程连续运行又具有细胞浓度大,产乙醇效率高等优点。有效的乙醇分离技术包括分离膜、萃取、真空等,它们能降低发酵液中乙醇的浓度,保证酵母的发酵活性,从而提高乙醇的产量。因此,废物乙醇化技术是一个具有巨大潜力的处理废物的新领域。     

离子色谱法测定污泥与餐厨垃圾联合厌氧发酵液中有机酸

采用离子色谱法同时测定污泥与餐厨垃圾联合厌氧发酵液中乳酸、乙酸、丙酸、正丁酸、异丁酸、正戊酸、异戊酸等7种有机酸,通过试验优化洗脱程序,使得7种有机酸在2．00mg／L～60．0mg／L范围内线性良好。试验表明,方法检出限为0．250mg／L～0．580mg／L,标准样品的加标回收率为93．O％～108％,8次测定结果的RSD为3．7％一7．1％,实际样品测定的加标回收率为90．6％～109％。     

制药行业高浓度有机废水的综合治理及资源利用研究

制药行业中的皂素生产废水,是酸性高浓度有机废水,富含淀粉水解产生的大量糖类,采用酸解和酒精生产工艺相结合的方法,从皂素废水中提取酒精,使废水中的有用资源得到再利用,不仅有良好的环境效益,亦产生明显的经济效益      

酒糟制取高蛋白菌体饲料优质菌种对碳源氮源利用率的研究

研究了8503和8505二白种在以白酒糟、薯干酒精糟及两糟混合的培养液中培养，对该酒糟培养液中还原糖的利用率和氮的转化率的分析检测方法．通过对绝于菌体质量的时变曲线与菌种对碳源利用率和氮源转化率的时变曲线的对比研究，可以看到该菌种在酒糟培养液中对碳源和氮源的利用率与转化率的规律性，经48h或72h发酵后碳源利用率可达90％左右，本实验最高达92．92％，氮源转化率一般可达50％～70％，本实验最高达68.41％，每100ml培养液中绝干菌体质量最高达0.78399。