丁腈橡胶密封圈高温老化行为——自由状态和承压状态

目的研究丁腈橡胶密封圈自由状态和承压状态下的高温老化行为。方法以拉伸强度和拉断伸长率为参数,对各温度下的老化行为进行表征和分析。结果 70℃条件下机械应力大大加快了橡胶密封件拉伸强度的下降速率,以致试验64 d时拉伸强度甚至比110℃时还低,拉断伸长率的下降速率也明显加快了;90℃加速条件下机械应力对拉伸强度的下降有一定的促进作用,但对拉断伸长率的变化基本无影响;110℃加速条件下机械应力对拉伸强度和拉断伸长率均没有明显的影响。结论机械应力在较低温度下可以显著促进丁腈橡胶密封圈热氧老化,高温条件下促进作用不明显。     

氯化磁性凹土树脂的制备与表征研究

利用表面负载的方法将有机化磁性凹土与苯乙烯、二乙烯苯等制备磁性凹土树脂;对磁性凹土树脂进行氯甲基化改性,制备出氯化磁性凹土树脂.表征了样品的形貌、结构以及表面积,研究了树脂对天然有机物(腐殖酸)的吸附性能.结果表明:氯化后的磁性凹土树脂的比表面积是原有的1.9倍,对附腐殖酸的饱和吸附能力也从原有的41.84 mg/g提高到了51.02 mg/g,这表明改性后的树脂增强了其对腐殖酸的去除能力.     

次氯酸钠氧化消除水中BPA的影响因素和动力学

采用常用消毒剂次氯酸钠对内分泌干扰物双酚A（BPA）的氧化消除及动力学规律进行研究,考察了加氯量、BPA初始浓度、pH值、Br^-浓度和温度各因素对降解效果的影响.结果表明,次氯酸钠对BPA的氧化降解过程符合拟一级反应动力学;pH值对该降解反应影响较大,当pH为8～9时,BPA与 HOCl的反应速率达到最大为0 .544 3　min^-1;溶液中存在Br^-会加快BPA的降解,并且其整体反应不符合拟一级动力学规律,随着Br^-浓度的增加,BPA降解得越快;温度对该降解反应的影响较大并且符合Van't Hoff规则,提高反应温度,有利于氯对BPA的降解.     

橡胶工业化学品安全防护

随着对环境、安全和健康意识的加强,人们对于工作场所的安全卫生问题已引起极大的关注.众所周知,橡胶工业对工人的健康存在较大的危害,这主要是在橡胶工业中所采用的大量化学品导致的.本文将就橡胶工业化学品的危害和安全防护的问题进行简要介绍和探讨.     

氯碱企业生产过程中的重大危害分析及对策

分析了氯碱企业生产过程中的重大危害为中毒和火灾爆炸,提出了相应的对策.     

Formation pathways of brominated products from benzophenone-4 chlorination in the presence of bromide ions

The brominated products, formed in chlorination treatment of benzophenone-4 in the presence of bromide ions, were identified, and the formation pathways were proposed.Under disinfection conditions, benzophenone-4 would undertake electrophilic substitution generating mono- or di-halogenated products, which would be oxidized to esters and further hydrolyzed to phenol derivatives. The generated catechol intermediate would be transformed into furan-like heterocyclic product. The product species were p H-dependent,while benzophenone-4 elimination was chlorine dose-dependent. When the chlorination treatment was performed on ambient water spiked with benzophenone-4 and bromide ions, most of brominated byproducts could be detected, and the acute toxicity significantly increased as well.     

Efficient dechlorination of chlorinated solvent pollutants under UV irradiation by using the synthesized TiO2 nano-sheets in aqueous phase

Titanium dioxide(TiO2), which is the widely used photo-catalyst, has been synthesized by simple hydrothermal solution containing tetrabutyl titanate and hydrofluoric acid. The synthesized product has been applied to photo-degradation in aqueous phase of chlorinated solvents, namely tetrachloroethene(PCE), trichloroethene(TCE) and 1,1,1-trichloroethane(TCA). The photo-degradation results revealed that the degradation of these harmful chemicals was better in UV/synthesized TiO2 system compared to UV/commercial P25 system and UV only system. The photo-catalytic efficiency of the synthesized TiO2 was 1.4, 1.8 and 3.0 folds higher compared to the commercial P25 for TCA, TCE and PCE degradation, respectively. Moreover, using nitrobenzene(NB) as a probe of hydroxyl radical(.OH), the degradation rate was better over UV/synthesized TiO2, suggesting the high concentration of.OH generated in UV/synthesized TiO2system. In addition,.OH concentration was confirmed by the strong peak displayed in EPR analysis over UV/synthesized TiO2system. The characterization result using XRD and TEM showed that the synthesized TiO2 was in anatase form and consisted of well-defined sheet-shaped structures having a rectangular outline with a thickness of 4 nm, side length of 50 nm and width of 33 nm and a surface 90.3 m2/g. XPS analysis revealed that ≡Ti-F bond was formed on the surface of the synthesized TiO2. The above results on both photocatalytic activity and the surface analysis demonstrated the good applicability of the synthesized TiO2 nano-sheets for the remediation of chlorinated solvent contaminated groundwater.     

水库水氯化消毒副产物毒性研究

为了证实水库出水的氯化消毒副产物CHClBr2和CHBr3具有一定的遗传毒性,将水库出水进行浓缩富集研究其对小鼠脾脏淋巴细胞DNA的影响。同时分别与水库枯水期和丰水期出水的小鼠彗星实验结果进行了对比,发现氯化消毒副产物CHClBr2和CHBr3的DNA损伤效应同时高于两个水期的出厂水。     

设置限位器双向隔震铁路桥梁车桥耦合动力响应研究

对铅芯橡胶双向隔震铁路桥梁在列车荷载作用下的力学性能进行了研究,针对双向隔震铁路桥梁中存在的问题,提出了设置限位器的解决方案,并对设置限位器的双向隔震铁路桥梁进行了车桥耦合动力响应分析.研究结果表明,采用常规隔震设计方法的铅芯橡胶支座在横桥向的初始刚度和屈服强度均不能满足规范要求,设置限位器后,双向隔震铁路桥梁的力学性...     

顺序氯化对微生物、副产物和生物稳定性的综合控制

在中试规模试验中,研究了“短时游离氯后转氯胺的顺序氯化消毒工艺”对微生物、消毒副产物和生物稳定性指标的控制效果.该顺序氯化消毒工艺综合利用了游离氯消毒灭活微生物迅速彻底,氯胺消毒副产物生产量低的特点,通过氯化消毒技术的组合,安全经济地实现了消毒卫生学和消毒副产物指标的双重控制.该消毒工艺对细菌总数、异养菌平板计数、总大肠菌群指标的控制效果略好于传统游离氯消毒,对脊髓灰质炎病毒和大肠杆菌f2噬菌体的灭活效果与游离氯相同.相同原水条件下,顺序氯化消毒工艺比游离氯消毒工艺产生的三卤甲烷浓度减少35.8%～77.0%;卤乙酸减少36.6%～54.8%.消毒进水水质越差,顺序氯化消毒工艺在消毒副产物控制方面就越有优势.该工艺对生物稳定性指标的控制效果明显高于游离氯消毒.