A pilot-scale study of cryolite precipitation from high fluoride-containing wastewater in a reaction-separation integrated reactor

Fluoride removal by traditional precipitation generates huge amounts of a water-rich sludge with low quality, which has no commercial or industrial value. The present study evaluated the feasibility of recovering fluoride as low water content cryolite from industrial fluoride-containing wastewater. A novel pilot-scale reaction-separation integrated reactor was designed. The results showed that the seed retention time in the reactor was prolonged to strengthen the induced crystallization process. The particle size of cryolite increased with increasing seed retention time, which decreased the water content. The recovery rate of cryolite was above 75% under an influent fluoride concentration of 3500 mg/L, a reaction temperature of 50℃, and an influent flow of 40 L/hr. The cryolite products that precipitated from the reactor were small in volume, large in particle size, low in water content, high in crystal purity, and recyclable.     

硫酸钙垢层清洗方法研究

从化学热力学角度和沉淀转化角度,理论上分析了碳酸钠、氢氧化钠分别与硫酸钙发生化学反应的可能性和反应进行的限度。并结合动力学规律,提出影响化学反应的条件,通过实验进行检验。最后提出,在实际工作中,达到良好清洗目的可采取的措施。     

Critical velocity in phosphorus exchange processes across the sediment-water interface

Sediments are ultimate sinks of nutrients in lakes that record the pollution history evolutionary processes, and anthropogenic activities of a lake. However, sediments are considered as inner sources of environmental factor changes such as the variation in hydrodynamic conditions because of the nutrients they release. How does this process happen？ This study investigates a typical nutrient phosphorus （P） exchange among sediment, suspended particle matter （SPM）, and water. Compared with numerical and experimental studies, this study confirms that the critical velocity that occurs at a lower flow rate state exists in the range of 7 to 15 crn/sec. Critical velocity below the critical flow rate promotes the migration of particulate phosphorus （PP） to the SPM. On the other hand, critical velocity above the critical flow rate promotes the release of PP in water.     

重金属絮凝剂PEX对水中铅的去除性能研究

在合成高分子重金属絮凝剂聚乙烯亚胺基黄原酸钠(PEX)的基础上,研究了该絮凝剂处理含铅离子废水的效能,并对一些影响因素进行了考查。研究结果表明:高分子重金属絮凝剂PEX对铅离子的捕集效率较高,去除率可达90%以上;pH值对PEX去除铅离子有一定的影响,pH=5.0时去除效果最好;Mg2+﹑Ca2+、EDTA、柠檬酸、焦磷酸钠以及致浊物质的存在均能促进铅离子的去除;絮体残渣稳定性好,金属离子易回收,回收率可达到70.0%。     

维生素C生产废水处理工艺优化研究

采用生化-物化-再生化的废水处理优化工艺,研究了利用生产产生的废碳、废酸水为原料对IC厌氧生化出水进行铁炭微电解与Fenton法组合深度处理,净化絮凝沉淀除去反应产生物,提高出水的可生化性,COD去除率提高56%;进行好氧污泥耐盐驯化,COD去除率进一步提高15%。通过单因素实验对比,选定铁炭比为1:1,停留时间为30 min,双氧水投加量为0.2 mL/L,壳聚糖为助凝剂,最终使废水中COD由12 000 mg/L降到50 mg/L以下,COD去除率达到99.5%以上。经过生产试运行,出水COD稳定达到规定的排放标准COD≤50 mg/L,该优化工艺于2011年12月8日通过省级成果鉴定。     

混凝-氧化法处理印染废水的实验研究

实验使用混凝-氧化法对印染废水进行处理,采用混凝-氧化法不仅能有效地去除废水中的固体悬浮物和颜色,而且也能去除大部分的CODCr,去除率在60%～70%左右。本研究采用混凝沉淀与氧化的组合工艺对其进行处理实验,着重研究了有关工艺条件与CODCr去除率的关系。用混凝-氧化法处理印染废水,确定最佳混凝和氧化条件。实验中考察了pH值、混凝剂加入量、沉降时间、氧化剂加入量和氧化时间等对CODCr去除率的影响。     

新型机械澄清池设备的设计及在尾矿水处理中的应用

国内现有的机械加速澄清池因池体及设备结构的原因,存在刮泥耙直径小、驱动扭矩低,高负荷时排泥差等问题,不能满足用户对设备大池径（大于Ф29m）、大处理量、高效澄清、多用途的要求。介绍了新型澄清池设备的工艺、结构设计及特点。新型机械澄清池设备通过对池体结构的改进设计,及对刮泥机、提升搅拌机、排泥防堵搅拌机三者同心套装结构,扭矩可达百万牛顿米的带齿回转支承及多组电机同步驱动的刮泥耙驱动机构,池周边增设斜板及集水装置等方面的设计,实现了池径大于qb29in机械澄清池的设计制造,填补了国内该项目的空白,经矿山尾矿水处理实际应用证明效果理想。     

建设可持续基础设施,支持城市未来发展

目前全球超过50%的人口居住在城市.20世纪,城市区域不断扩大,其扩展速度更甚于人口增长速度.城市对资源的需求量以及对自然环境的影响不断上升,城市社会也不断演变,多元化的文化、高密度的人口、日益增长的服务需求,使得人类城市系统越加复杂.城市系统与基础设施体系互相影响,在基础设施的设计、建设和管理过程中必须考虑社会和环境的因素,同时也要为未来城市发展留出余地.     

Competition of bloom-forming marine phytoplankton at low nutrient concentrations

Competition of three bloom-forming marine phytoplankton (diatom Skeletonema costatum, and dinoflagellates Prorocentrum minimum and Alexandrium tamarense) was studied through a series of multispecies cultures with di erent nitrate (NaNO3) and phosphate (NaH2PO4) levels and excess silicate to interpret red tide algae succession. S. costatum outgrew the other two dinoflagellates in nitrate and phosphate replete cultures with 10 mol/L Na2SiO3. Under nitrate limited (8.82 mol/L NaNO3) conditions, the growth of S. costatum was also dominant when phosphate concentrations were from 3.6 to 108 mol/L. Cell density of the two dinoflagellates only increased slightly, to less than 400 and 600 cells/mL, respectively. Cell density of S. costatum decreased with time before day 12, and then increased to 4000 cells/mL (1.5 mg/L dry biomass) at NaNO3 concentrations between 88.2 and 882 mol/L with limited phosphate (0.36 mol/L NaH2PO4) levels. In addition, P. minimum grew well with a maximal cell density of 1690–2100 cells/mL (0.5–0.6 mg/L dry biomass). Although S. costatum initially grew fast, its cell density decreased quickly with time later in the growth phase and the two dinoflagellates were dominant under the nitrate-limited and high nitrate conditions with limited phosphate. These results indicated that the diatom was a poor competitor compared to the two dinoflagellates under limited phosphate; however, it grew well under limited nitrate when growth of the dinoflagellates was near detection limits.     

有关斜管沉淀池的上升流速讨论

文章从理论上了分析斜管沉淀池上升流速对沉淀池处理效果的影响,及原水特性与斜管沉淀池上升流速取值的关系。讨论分析斜管沉淀池设计时,应根据原水特性不同选择不同的斜管沉淀池上升流速。