Antimony smelting process generating solid wastes and dust：Characterization and leaching behaviors

A large amount of solid waste has been produced by the antimony smelting process in the＂World Capital of Antimony＂, Xikuangshan area in China. This study comprehensively investigated the physical and chemical characteristics of the various solid wastes, as well as the leaching behavior of the solid wastes, which included water-quenched slag,arsenic-alkali residue, desulfurized slag and blast furnace dust. These four types of waste were enriched in a variety of heavy metals and metalloids and more specifically with As and Sb levels up to 8.6 × 104 and 3.16 × 105mg/kg, respectively, in arsenic-alkali residue. For desulfurized slag and water-quenched slag, the leaching concentration of Sb significantly exceeded the acceptable limits during the leaching tests using the toxicity characteristic leaching procedure and the synthetic precipitation leaching procedure. In addition, As leaching in arsenic-alkali residue was extraordinarily hazardous, being three orders of magnitude higher than the regulatory level of As. According to the results of the extraction tests, all the tested wastes were classified as hazardous waste.     

Origin of major ions in monthly rainfall events at the Bamenda Highlands, North West Cameroon

Rainwater characteristics can reveal emissions from various anthropogenic and natural sources into the atmosphere. The physico-chemical characteristics of 44 monthly rainfall events （collected between January and December 2012） from 4 weather stations （Bamenda, Ndop plain, Ndawara and Kumbo） in the Bamenda Highlands （BH） were investigated. The purpose was to determine the sources of chemical species, their seasonal inputs and suitability of the rainwater for drinking. The mean pH of 5 indicated the slightly acidic nature of the rainwater. Average total dissolved solids （TDS） were low （6.7 mg/L）, characteristic of unpolluted atmospheric moisture/air. Major ion concentrations （mg/L） were low and in the order K＋ 〉 Ca2＋ 〉 Mg2~ 〉 Na＋ for cations and NO3 〉〉 HCO3 〉 SO] 〉 CI- 〉 PO3- 〉 F- for anions. The average rainwater in the area was mixed Ca-Mg-SO4-CI water type. The CI-/Na＋ ratio （1.04） was comparable to that of seawater （1.16）, an indication that N a＋ and CI originated mainly from marine （Atlantic Ocean） aerosols. High enrichments of Ca2＋, Mg2＋ and SO2- to Na＋ ratios relative to seawater ratios （constituting 44% of the total ions） demonstrated their terrigenous origin, mainly from Saharan and Sahelian arid dusts. The K＋/Na＋ ratio （2.24）, which was similar to tropical vegetation ash （2.38）, and NO3 was essentially from biomass burning. Light （〈 100 mm） pre-monsoon and post-monsoon convective rains were enriched in major ions than the heavy （〉 100 mm） monsoon rains, indicating a high contribution of major ions during the low convective showers. Despite the acidic nature, the TDS and major ion concentrations classified the rainwater as potable based on the WHO guidelines.     

凹凸棒石纤维复合气凝胶吸附水体中TPH吸附特性

以水体中总石油烃(total petroleum hydrocarbons,TPH)为目标污染物,采用凹凸棒石复合二氧化硅气凝胶进行净化石油类污染水体研究,主要考察复合气凝胶使用量及环境要素对去除水体中TPH的影响。研究结果表明:凹凸棒石纤维复合气凝胶与污染水体的质量比为1:60,对TPH的去除率随温度的升高而降低,受pH变化影响较小;当NaCl浓度在0~100 g/L,MgCl2浓度在0~2.5 g/L时,复合气凝胶对水体中TPH的去除率几乎不受盐度的影响;Fe3+、Mn2+、NH4+、NO3-均能促进复合气凝胶对TPH的去除,但受其浓度变化影响较小,同时,凹凸棒石纤维复合气凝胶对上述离子也有微弱的去除作用。研究成果为凹凸棒石复合气凝胶在实际石油类污染水体中的应用提供了科学可靠的数据支撑。     

钴胁迫下红苋菜中钴积累分布及其生理特性的研究

采用模拟钴污染土壤的方法,研究不同程度的钴(0、20、40、60 mg/kg)胁迫对成熟期红苋菜生长及其体内钴积累分布和生理特性的影响。结果表明:(1)同一钴胁迫下,红苋菜株高差异性大,株高差值(最高与最矮的差值)范围为14~27 cm,远大于对照组的4 cm;(2)在不同程度的钴胁迫下,植株各部位钴含量分布规律不一致,且根部钴含量最高。当胁迫浓度为60 mg/kg,植株长势最差组的根、茎、叶部钴含量最高,分别为对照组的41、44和14倍,此时地上部和单株的钴积累量均最大,分别为1 103和1 275μg,且两者的积累量与MDA含量成极显著正相关;(3)钴胁迫使得叶片叶绿素含量、CAT和POD酶活性均出现不同程度的降低,SOD酶活性仅在低浓度的钴胁迫下上升,而MDA含量则上升;(4)钴胁迫下植株对钴的转运系数为0.20~0.64,地上富集系数为1.96~10.06,同一胁迫下,长势最差组的转运系数和地上富集系数最大。     

翼形上进风长袋脉冲袋式除尘器气流特性研究

袋式除尘器对超细颗粒物的净化效果较好,增加袋长是提高过滤面积的有效方法,但随滤袋加长,气流均匀性变差,滤袋容易破损,局部积灰严重,滤袋不能得到充分的利用。文章对翼形上进风长袋脉冲袋式除尘器建立几何模型并进行网格划分,基于计算流体动力学(CFD)理论,选取过滤速度为0.5~1.3 m/min和压力出口为-350~-2 000 Pa为边界条件,采用压力-速度耦合的SIMPLE算法,模拟包含Φ130 mm和Φ150 mm,长10 m滤袋的翼形上进风长袋脉冲袋式除尘器的气流分布,考察气流在滤袋空间分布的均匀性。结果表明:翼形上进风方式使得长袋脉冲袋式除尘器内气流分布较均匀;通过Φ150滤袋的气流速度大于Φ130;靠近壁面的滤袋的气流速度大于相应中心滤袋的。该研究可为上进风袋式除尘器的优化设计提供指导和依据。     

喹啉为单一燃料在填料型MFC的产电特性研究

多环芳烃是我国近岸海域水体和沉积物中需要优先控制的首位有机污染物,喹啉是典型的含氮杂环芳烃,具有较大的毒性、致畸性和潜在的致癌作用。该研究利用填料型MFC对单一喹啉为燃料的产电性能进行了研究。经过6个月利用喹啉和葡萄糖作混合燃料的驯化,MFC中的阳极群落发生了改变,可以利用单一喹啉进行产电,以200 mg/L喹啉为燃料时的最大体积功率密度为2.7 W/m3。在没有外加葡萄糖可能带来的协同共代谢作用下,利用单一喹啉做燃料时,对喹啉在MFC中的降解途径进行了研究。实验结果表明,以喹啉为燃料时,MFC可以在不利用有机物本身作为电子受体的作用下,通过外电路的电子传递完成电子从阳极到阴极的传递而达到相同的目的。     

专利资讯

专利名称：从废锂电池中回收硫酸锂和氢氧化钴的方法 到目前全国手机用户已经超过2亿,其中使用锂电池的手机约占三分之二,如果按每个锂电池重为50g,按每部手机每年更换一次电池,每年就会产生666．7t／a电池垃圾,再加上其他电器的使用,全国所产生的废锂电池垃圾超过1000t／a,这些电池垃圾中含有碱、钴酸锂等物质。     

汽车的未来新能源——氢

正丰田汽车最近宣布将推出首款商用氢燃料电池汽车,新车将于明年上市销售。不仅仅是丰田,现在主流的汽车厂商几乎都有一个氢燃料汽车计划:2015年开始,现代计划在美国出租1 000辆氢燃料汽车;雷诺和日产宣布,与戴姆勒、福特共同分担研发成本的氢燃料汽车最快将在2017年推出;通用与本田2013年宣布将组建一家合资公司,在2020年量产氢燃料汽车。     

国家安全生产监督管理总局化学品登记中心化学品危险性鉴别分类实验室

<正>化学品危险性鉴别分类实验室是国家安全生产监督管理总局化学品登记中心的专业实验室,负责全国化学品危险性评估工作,对未分类的化学品统一进行危险性分类,承担化学品及相关产品的检测检验工作,受理有争议的化学品危险性实验鉴别结果的复验,并做出复验结论。     

再生水中5种抗生素抗性菌的紫外线灭活及复活特性研究

抗生素抗性菌作为再生水中的新兴污染物而受到广泛关注.为探明紫外线对抗生素抗性菌的灭活和消毒后抗性菌的复活潜能,研究了以城市污水为水源的再生水(简称"再生水")中青霉素抗性菌、氨苄青霉素抗性菌、头孢氨苄抗性菌、氯霉素抗性菌和利福平抗性菌的紫外线灭活特性,并考察了再生水中的抗生素抗性菌在黑暗条件下的复活潜能.结果表明,20mJ·cm-2紫外线消毒剂量下,实际再生水中青霉素抗性菌、氨苄青霉素抗性菌、头孢氨苄抗性菌和氯霉素抗性菌的灭活率均高于4-log,与总异养菌群灭活率相当,而利福平抗性菌的灭活率(3.7-log)略低于总异养菌群.紫外线消毒后,再生水静置22 h后,抗生素抗性菌普遍出现复活现象,当紫外线消毒剂量为常规剂量20 mJ·cm-2时,消毒后再生水中的抗生素抗性菌菌落形成能力高达3-log.因此,常规的紫外线消毒剂量不能有效控制再生水储存或运输过程中抗生素抗性菌的复活.