一种用于空气压缩机的空气消声过滤器

介绍了组合式空气消声过器的用途结构、工作原理和合乎经是空气压缩机前的专用理想设备,推广使用后可获得良好的综合效益。     

炉渣用于深层过滤的试验研究

将炉渣用作深层过滤的床层过滤,在油田水处理中具有良好的应用前景。通过对炉渣滤料的物性测定,对流体力学性能、过滤性能及反洗性能的研究,获得了有关炉渣滤料的粒径分布、床层孔隙率、密度、吸水率等物性参数,以及清洁滤料床层阻力与速度的关系曲线和流化曲线,过滤条件下床层阻力随时间的变化关系和悬浮物脱除率随时间的变化曲线,炉渣床层的反洗曲线。结果表明：炉渣表面粗糙,有棱角,吸附表面积大,孔隙率大,过滤效果好;炉渣滤料密度小,反洗效果较好,反洗用水量只是过滤水量的５％左右;同时,炉渣作为滤料用于深层过滤,不仅来源广泛,而且属废物利用。     

氨荒酸膦酸树脂滤器的制备及其在AAS分析中的应用

本文介绍了氨荒酸膦酸树脂过滤器的制备方法，以及应用该过滤器分离与富集地面水、海水中Ｃｕ、Ｐｂ、Ｚｎ、Ｃｄ多元素的适用条件。实际样品中的Ｃｕ、Ｐｂ、Ｚｎ、Ｃｄ等重金属离子经过过滤器过滤，被吸附在树脂滤层中，用少量酸洗脱，以ＡＡＳ测试，结果稳定、准确度高。此过滤器在痕量分析中具有很高的应用价值。     

SiO2纳米粉掺杂对薄膜光催化剂结构和活性的影响

针对固定膜光催化剂吸附能力差的缺陷,在催化剂的涂覆溶胶中掺杂具有较大比表面积的SiO2纳米粉制备了一种新的TiO2薄膜.通过X射线衍射(XRD)、扫描电镜(TEM)和红外光谱(FTIR)等手段对催化剂进行表征发现,催化剂的晶相以锐钛矿为主,并含有少量的金红石,平均晶粒尺寸为27nm左右.其中掺杂的SiO2以十几到几十纳米的无定型团簇形式分散于薄膜中,除了能增大薄膜的表面积外,对TiO2的晶体结构和表面基团等性质几乎没有影响.光催化降解试验表明,SiO2掺杂后薄膜的活性大大改善,并受掺杂SiO2的原始粒径和掺杂量影响很大.此外,该催化剂还具有很好的稳定性,在连续30多天的使用中,对活性艳红X-3B的去除率一直维持在80%左右,活性未见降低.     

薄膜覆盖减少化肥养分流失研究

我国化肥的利用率低,使用量又不断增长,增加了农业面源污染问题的严重性.本研究针对化肥流失主要通过水带走的特性,进行大田试验种植玉米,利用薄膜覆盖所施用的化肥,实现"肥与水隔离",以减少化肥流失.试验一方面观察了不同施肥处理二季甜玉米的生长和产量,另一方面测定了作物对肥料的利用率以及地表径流养分含量.结果表明,在本土壤条件下甜玉米只需施用常规施肥量的70%即可达到高产.甜玉米收获后土壤中碱解氮、有效磷、有效钾的含量比不经薄膜覆盖的显著提高,其顺序为100%施肥量+覆膜70%施肥量+覆膜100%施肥量、70%施肥量不施肥.氮、磷、钾肥料的表观利用率分别为42%~87%、0%~3%和5%~15%,覆膜处理一般高于不覆膜处理,特别是在高施肥量情况下更为明显.通过8次径流水的收集测定,无薄膜覆盖的施肥处理的地表径流N、P和K平均浓度分别为27.72、2.70和7.07 mg.L-1,薄膜覆盖技术处理降低N、P、K浓度的效果分别达到了39.54%、28.05%、43.74%,对于减少农业面源污染和水体富营养化可起到明显效果.     

Influences of working pressure on properties for TiO2 films deposited by DC pulse magnetron sputtering

TiO2 films were deposited at room temperature by DC pulse magnetron sputtering system.The crystalline structures,morphological features and photocatalytic activity of TiO2 films were systematically investigated by X-ray diffraction (XRD),atomic force microscopy and ultraviolet spectrophotometer,respectively.The results indicated that the working pressure was the key deposition parameters influencing the TiO2 film phase composition at room temperature,which directly affected its photocatalytic activity.With increasing the working pressure,the target self-bias decreases monotonously.Therefore,low temperature TiO2 phase (anatase) could be deposited with high working pressure.The anatase TiO2 films deposited with 1.4 Pa working pressure displayed the highest photocatalytic activity by decomposition of Methyl Orange solution,which the degradation rate reached the maximum (35%) after irradiation by ultraviolet light for 1 h.     

Photocatalytic degradation of methyl orange over ITO/CdS/ZnO interface composite films

ITO/CdS/ZnO interface composite films were successfully prepared by subsequent electrodeposition of CdS and ZnO onto indium tin oxide (ITO) glass substrates. The obtained ITO/CdS/ZnO composite films were characterized with X-ray diffraction (XRD), scanning electron microscopy (SEM), and UV-Vis spectroscopy. The photocatalytic activity of ITO/CdS/ZnO composite films were investigated using methyl orange (MO) as a model organic compound under UV light irradiation. The influence of operating parameters on MO degradation including initial concentration of MO, pH value of solution, and inorganic anion species over the composite films were examined. A blue shift of absorption threshold was observed for the ITO/CdS/ZnO film in comparison with ITO/ZnO film. ITO/CdS/ZnO composite films prepared under specific conditions showed a higher photocatalytic activity than that of ITO/ZnO films. It was also found that the photocatalytic degradation of MO on the composite filing followed pseudo-first order kinetics.     

金属掺杂纳米TiO2薄膜的制备和抗菌性能研究

采用sol—gel法在载玻片表面制备了Ce,Cu,i．a,Ag掺杂的锐铁矿相TiO2薄膜,并通过SEM,XRD．FT—IR及UVVIS进行了表征,比较了薄膜的抗菌性能．UV—VIS研究表明,金属掺杂纳米TiO2薄膜在近紫外区吸光度有明显提高。抗菌实验表明掺Ag的TiO2薄膜抗菌效果最佳。     

Particle properties in granular activated carbon filter during drinking water treatment

The elemental composition and bacteria attached in particles were investigated during granular activated carbon (GAC) filtration.The experimental results showed that trapped influent particles could form new,larger particles on GAC surface.The sloughing of individuals off GAC surface caused an increase in effluent particles in the size range from 5 to 25 μm.The selectivity for element removal in GAC filters caused an increasing proportion of metallic elements in the effluent particles.The distribution of molar ratio indicated a complicated composition for large particles,involving organic and inorganic substances.The organic proportion accounted for 40% of total carbon attached to the particles.Compared with dissolved carbon,there was potential for the formation of trihalomethanes by organic carbon attached to particles,especially for those with size larger than 10 μm.The pure carbon energy spectrum was found only in the GAC effluent and the size distribution of carbon fines was mainly above 10 μm.The larger carbon fines provided more space for bacterial colonization and stronger protection for attached bacteria against disinfection.The residual attached bacteria after chorine disinfection was increased to 10 2-10 3 CFU/mL within 24 hours at 25°C.     

热轧厂的高速过滤器改造及效果分析

对八钢公司热轧厂浊循环水工艺中的主要水处理设备高速过滤器的运行结果进行了分析,认为高速过滤器存在设计缺陷。针对高速过滤器存在的问题,对其进行了改造,改造后,其出水水质显著提高,运行效果良好。