飞行器环境适应性设计方法研究与实践

目的针对飞行器环境适应性设计不足的现状提出对策。方法分析飞行器环境适应性设计的特点和当前存在的不足,以某电气设备为对象开展应用研究。结果提出环境适应性设计工作内容、工作流程、设计原则和技术手段等方面的对策。环境适应性设计应采用环境仿真和验证试验相结合的手段,并逐步形成环境适应性设计准则。结论飞行器环境适应性设计应采用系统工程的思路,覆盖产品层级、环境因素和研制阶段。技术手段方面应大力推进环境仿真研究和应用,建立产品环境适应性设计规范。     

GJB 4239《装备环境工程通用要求》在直升机研制中的应用研究

根据直升机及直升机型号的特点,结合直升机环境工程及传统研制、设计经验,提出了直升机及直升机型号研制中贯彻GJB 4239的具体实施程序和方法,试图将GJB 4239的通用要求转化为直升机和直升机型号系统、部件/设备环境适应性分析、设计、试验及管理具体实用,易于操作的工程技术要求,并提出直升机研制中环境试验与评估的实施要求和方法。     

GJB 4239—2001在航空型号研制中的应用

结合GJB 4239—2001《装备环境工程通用要求》在航空重点型号研制中应用案例和工作经验,系统地阐述了环境工程技术体系在立项论证阶段、工程研制阶段和设计定型阶段的实现方式,并着重介绍了近几年以来GJB 4239—2001《装备环境工程通用要求》在重点航空型号项目研制中的应用情况。最后,分别在环境分析、环境设计、环境试验,以及环境工程管理等四个方面分析了实际型号研制工作中工作项目、开展时机、输出形式所存在的突出问题,并给出了今后改进完善的建议。     

液化烃球罐泄漏温度场及材料适应性研究

针对高压储存的液化烃一旦发生泄漏,会迅速气化并吸热,使得球罐温度降低,严重时温度可能低于标准中允许的球罐材质最低适应温度的问题,建立球罐三维物理模型,基于CFD模拟的方法,采用雷诺时均的Navier-Stokes方程和k-ε湍流模型,分析球罐管线发生泄漏时球罐本体及周围环境的温度分布情况,探讨了不同泄漏孔径对球罐温度的影响。研究结果表明球罐发生泄漏时,球罐外部温度会明显降低,由于保温层的存在,球罐本体温度降幅不大。但在泄漏孔附近会形成较小的低温区,超过了16MnR材质的低温承受能力,存在较大的风险。     

厌氧-准好氧联合型生物反应器填埋场产气规律的研究

通过将厌氧型生物反应器填埋场（ANBL）和准好氧矿化垃圾生物反应床（SAARB）串联,组成新型的厌氧-准好氧联合型生物反应器填埋场（AN-SABL）,研究其产气速率、产气量以及产气组分的变化规律,以期为填埋气体的收集、利用和处理提供理论依据.实验表明,AN-SABL中的厌氧填埋单元的产气受到了抑制,其中ANBL2号单元和ANBL3号单元的产气率分别为49 L.kg-1和39 L.kg-1,仅占ANBL1号的94.2%和75.0%,但提高回灌频率,能促进厌氧填埋单元的产气,其甲烷含量最大值可达到62.67%;ANBL夏季产气速率和产气量明显高于冬季,并以12 h为周期交替出现产气高峰;此外,AN-SABL能够促进其厌氧单元的硝化和反硝化作用,N2O的含量受季节和填埋场类型影响显著,其变化范围在0.001 7%～4.017 9%之间.ANBL的累积产气量在初始调整阶段呈对数增长,过渡酸化阶段呈线性增长,酸化产甲烷阶段呈指数增长.     

水溶液中臭氧和溴离子的反应研究

为探明O3氧化Br-的反应机制,采用离子色谱、PDA紫外-可见光度仪研究了水中Br-被O3氧化的反应过程.离子色谱分析表明,被氧化的Br-中只有约10%被O3氧化成BrO3-.进一步研究表明,除了生成BrO3-外,Br-被O3氧化过程中还产生了Br2,Br2又与溶液中存在的Br-结合形成Br3-,并首次得到了Br3-的吸收光谱,测得Br3-的最大吸收峰λmax为260 nm,提出了Br-与O3的基元反应.该研究补充和完善了O3氧化Br-的反应机制,也为O3处理含Br-水时Br-的归趋提供了有益信息.     

土壤重金属钝化修复剂生物炭对镉的吸附特性研究

目前以生物炭为代表的生物质对重金属的吸附表现出良好的应用前景.为确定生物炭对溶液中镉的吸附性能,选用由棉花秸秆制备的生物炭,研究吸附等温线、吸附动力学以及温度、pH和离子强度等对生物炭吸附Cd2+的影响.研究表明,生物炭对Cd2+的吸附可以用Freundlich等温线较好地拟合,在不同温度下其饱和吸附量分别为9.738 mg.g-1(288.15 K)、10.14 mg.g-1(298.15 K)、10.40 mg.g-1(308.15 K)和10.71 mg.g-1(318.15 K),热力学参数表明生物炭吸附Cd2+的过程是自发的吸热过程;吸附动力学过程符合二级动力学模型,在40 min即可达到平衡;pH对生物炭吸附Cd2+的影响较大,在pH2～8范围时,生物炭对Cd2+的吸附量随pH的增加先上升后下降;生物炭对Cd2+的吸附量随着溶液离子强度的增大呈降低趋势.该项研究可为生物炭在土壤重金属污染修复中的应用提供一定的理论基础.     

La3+掺杂对吸附相反应制备TiO2复合催化剂的结晶过程及弱紫外光下活性的影响

利用吸附相反应技术制备弱紫外光响应的高效催化剂,并通过XRD、XPS以及HRTEM探索了不同焙烧温度下La3+掺杂量对TiO2结晶过程的影响.结合弱紫外光下甲基橙的降解反应,深入研究催化剂结晶过程的变化对弱紫外光下催化剂活性的影响.结果表明,La3+掺杂会抑制TiO2的结晶过程.当焙烧温度或者掺杂量较低时,La3+不能进入TiO2的晶格结构但会轻微地抑制TiO2的结晶过程;未进入晶格结构的La3+存在会引入光生载流子的浅能级捕获中心,在弱光体系中极大提升了催化剂的活性.当La3+的掺杂量为0.05%(原子分数)时,经过900℃焙烧后催化剂降解能力最高,其活性超过商用P25的2倍多.在较高La3+掺杂量(超过0.20%)时,900℃焙烧后一定量La3+进入TiO2的晶格结构而大大抑制了TiO2结晶;这种强烈的抑制作用使得催化剂中存在大量无定形结构TiO2,无定形TiO2甚至多于700℃焙烧后的催化剂,反而大大抑制了弱光体系中催化剂活性.     

A pilot-scale study of cryolite precipitation from high fluoride-containing wastewater in a reaction-separation integrated reactor

Fluoride removal by traditional precipitation generates huge amounts of a water-rich sludge with low quality, which has no commercial or industrial value. The present study evaluated the feasibility of recovering fluoride as low water content cryolite from industrial fluoride-containing wastewater. A novel pilot-scale reaction-separation integrated reactor was designed. The results showed that the seed retention time in the reactor was prolonged to strengthen the induced crystallization process. The particle size of cryolite increased with increasing seed retention time, which decreased the water content. The recovery rate of cryolite was above 75% under an influent fluoride concentration of 3500 mg/L, a reaction temperature of 50℃, and an influent flow of 40 L/hr. The cryolite products that precipitated from the reactor were small in volume, large in particle size, low in water content, high in crystal purity, and recyclable.     

Soil microbial community structure and function responses to successive planting of Eucalyptus

Many studies have shown soil degradation after the conversion of native forests to exotic Eucalyptus plantations. However, few studies have investigated the long-term impacts of short-rotation forestry practices on soil microorganisms. The impacts of Eucalyptus successive rotations on soil microbial communities were evaluated by comparing phospholipid fatty acid （PLFA） abundances, compositions, and enzyme activities of native Pinus massoniana plantations and adjacent 1st, 2nd, 3rd, 4th generation Eucalyptus plantations. The conversion from P. massoniana to Eucalyptus plantations significantly decreased soil microbial community size and enzyme activities, and increased microbial physiological stress. However, the PLFA abundances formed ＂U＂ shaped quadratic functions with Eucalyptus plantation age. Alternatively, physiological stress biomarkers, the ratios of monounsaturated to saturated fatty acid and Gram＋ to Gram- bacteria, formed ＂∩＂ shaped quadratic functions, and the ratio of cy17：0 to 16： 1ω7c decreased with plantation age. The activities of phenol oxidase, peroxidase, and acid phosphatase increased with Eucalyptus plantation age, while the cellobiobydrolase activity formed ＂U＂ shaped quadratic functions. Soil N：P, alkaline hydrolytic nitrogen, soil organic carbon, and understory cover largely explained the variation in PLFA profiles while soil N：P, alkaline hydrolytic nitrogen, and understory cover explained most of the variability in enzyme activity. In conclusion, soil microbial structure and function under Eucalyptus plantations were strongly impacted by plantation age. Most of the changes could be explained by altered soil resource availability and understory cover associated with successive planting of Eucalyptus. Our results highlight the importance of plantation age for assessing the impacts of plantation conversion as well as the importance of reducing disturbance for plantation management.