谨防"低级失误"

纵观石化企业发生的事故,往往并不是怎么复杂的原因。比如,反应釜之间该关的阀门没关,造成串料,或使一锅料成了废品,或使锅内温度急剧上升,导致火灾爆炸;化工物料装车时,竟然在鹤管没有插入槽车的情况下启动装车仪,致使有毒有害的物料流到了地上。还有,检修时进入刚卸完料的罐内干活,却没有戴上防护面具,结果中毒了。这些事故原因,可以统称为“低级失误”。     

高磷赤铁矿选矿酸性废水处理的试验研究

文章采用自主开发的原位生成型动态膜反应器对高磷赤铁矿选矿酸性废水处理进行了实验研究。实验研究结果表明:选矿酸性废水除磷效果与脱磷剂的投加量、速度梯度(G值)、反应时间及pH等因素有关。对于pH2.25~2.56、含磷50mg/L的模拟选矿废水,最佳反应时间1h,速度梯度(G值)63.6,脱磷剂最佳投加量为11.25g/L,废水脱磷率92.47%。选矿酸性废水处理后出水pH升高,不利于实现废酸全部回用。     

淮河淮南段底泥中酸性挥发硫与同步浸提金属的分布

采用氮载气冷法酸溶硫化物分析技术对淮河淮南段底泥中酸性挥发硫(AVS)以及同步浸提金属(SEM)的含量在河流沿程及垂直方向上的分布进行了测定.结果表明,淮河淮南段5个站点表层底泥中AVS的含量为0.14～0.87 μmol·g-1SEM(Zn、Cu、Ni、Cd、Pb)含量为0.5～1.1 μmol·g-1;其中,峡山口站点AVS最低,姚家湾站点AVS及SEM均为最高;从入境到出境断面,[SEM]/[AVS]摩尔比值呈逐渐下降趋势,数值都在1.0以上.不同站点AVS在垂直方向上的分布较为复杂,峡山口25 cm以上段随深度增加AVS逐渐增大.之后又逐渐降低,30 cm以下段变化很小;姚家湾表层AVS含量较高,20 cm以上段随深度增加AVS逐渐减小,之后又逐渐增大,30～35 cm层含量最高;石头埠和胡大涧站点AVS随深度变化不大.胡大涧以上4个站点柱状底泥中SEM的含量在0.25～0.9 μmol·g-1之间.对[SEM]/[AVS]摩尔比的研究显示,淮河淮南段表层底泥存在轻微的重金属污染.     

酸性矿井水运移的动力学预测模型及模型参数分析

分析了酸性矿井水在含水层中运移的规律,充分考虑了地下水密度变化对浓度分布的影响,提出了酸性矿井水迁移转化的动力学环境预测耦合模型,采用Galerkin有限元方法和Picard迭代法相结合对耦合模型进行了离散,并对酸性矿井水迁移问题进行了模拟分析,通过室内土柱实验求得了基本参数,探讨了模型参数的变化对酸性矿井水运移的影响,为定量研究土壤中酸性矿井水在土壤-水环境中分配与去向提供理论依据。     

你能做什么？

要理解你工厂的物料的特定危害,知道在安全处置这些物料方面,你所肩负的责任。     

尾矿库酸性废水处理研究

介绍了使用两段中和法处理矿山酸性废水,即首先用矿物或废渣作中和剂将废水的pH值调节到4.0左右,再用石灰乳进行中和。在实验室研究的基础上,对某铁矿尾矿库酸性废水采用两段中和法进行试验。试验结果表明,出水pH值达到6~8时,出水水质指标达到国家排放标准。     

Soluble protein and acid phosphatase exuded by ectomycorrhizal fungi and seedlings in response to excessive Cu and Cd

Fungi and their symbionts can alleviate heavy metal stress by exuding soluble proteins and enzymes. This study examined the role of soluble protein and acid phosphatase (APase) exuded by Xerocomus chrysenteron, an ectomycorrhizal fungus, and the seedlings of its symbiont, Chinese pine (Pinus tabulaeformis), under conditions of excessive Cu and Cd. The growth type showed that this poorly studied ectomycorrhizal fungus was capable of tolerating high concentrations of Cu, and may be useful in phytoremediation. X. chrysenteron grew well at 80 mg/L Cu, and the EC50 for Cd was 17.82 mg/L. X. chrysenteron also showed enhanced exudation of soluble protein in both isolated and inoculated cultivations under the influence of Cu and Cd. Soluble protein exudation, however, di ered under Cu and Cd stress in isolates. In mediums containing Cu, soluble protein exudation increased with concentration, but in mediums containing Cd the content of soluble protein increased to a comparable level at all concentrations. This study demonstrated that soluble protein was related to heavy metal tolerance, although the di erent ions played di erent roles. While APase activity in exudates of fungi and seedlings decreased under Cu and Cd stress in comparison to the control, the APase activity in seedlings was maintained by inoculation. Thus, X. chrysenteron facilitated the ability of plant to maintain a normal nutrient uptake, and therefore to protect it from heavy metal toxicity.     

化学发光法检测空气中NO_2研究

以0.2%的三乙醇胺水溶液作为二氧化氮吸收液,将空气中二氧化氮转化为亚硝酸盐,进而测出空气中二氧化氮的浓度。通过实验发现,进样方式、载流速度、硫酸浓度、溴酸钾浓度和酸性铬蓝K的浓度对该体系的发光强度都有影响,确定了体系的最优条件,建立了标准曲线,亚硝酸根的浓度在6.0×10-9～1.0×10-5mol/L范围内分段有很好的线性关系,检出限为8.5×10-11mol/L。对1.0×10-8mol/L和1.0×10-6mol/L的亚硝酸根进行11次平行测定,相对标准偏差分别为1.8%和2.2%。用该方法对氧化剂实验室空气中的二氧化氮含量进行了检测并进行标准加入和回收实验,回收率在95%～104%之间,该法可用于大气环境中的NO2测定。     

Determination of haloacetic acids in hospital e uent after chlorination by ion chromatography

The ion chromatography combined solid phase extraction （SPE） method was developed for the analysis of low concentration haloacetic acids （HAAs）, a class of disinfection by-products formed from chlorination of hospital wastewater. The monitored HAAs included monochloroacetic acid, monobromoacetic acid, dichloroacetic acid, dibromoacetic acid and trichloroacetic acid. The method employed a sodium hydroxide eluent at a flow rate of 0.8 ml/min, electrolytically generated gradients, and suppressed conductivity detection. To analyze the HAAs in real hospital wastewater samples, C18 pretreatment cartridge was utilized to reduce samples＇ turbidity. Preconcentration with SPE and matrix elimination with treatment cartridges were investigated and found to be able to obtain acceptable detection limits. Linearity, repeatability and detection limits of the above method were evaluated. The detection limits of monobromoacetic acid and dibromoacetic acid were 2.61 μg/L and 1.30 μg/L, respectively, and the other three acids are ranging from 0.48 to 0.82μg/L under 25-fold preconcentration. When the above optimization procedure was applied to three hospital wastewater samples with different treatment processes in Tianjin, it was found that the dichloroacetic acid was the major compound, and the growth ratios of the HAAs after disinfection by sodium hypochlorite were 91.28%, 63.61% and 79.50%, respectively.     

污泥屏障氧化缓冲容量与重金属再溶出关系研究

借助微生物厌氧活动特别是硫酸盐还原反应,污泥屏障可用来固定尾矿堆场重金属.针对尾矿风化淋滤形成的酸性采矿废水(AMD)与污泥之间发生的氧化还原反应导致的重金属溶出问题,通过氧化滴定实验研究了不同污泥悬液的氧化缓冲容量及其与重金属浓度的关系.结果表明,污泥悬液的氧化缓冲容量随着悬液固液比的增大略有减小,但随着悬液厌氧培养时间的延长而增加.污泥的氧化缓冲容量主要来自Eh≤-150mV的强烈还原区间,可达氧化缓冲容量的50%以上.氧化滴定过程中发现,当Eh≥-150mV时,Zn首先明显溶出;当Eh≥150mV时,Cu和Pb明显溶出.基于实验结果,建立了污泥屏障在AMD渗流条件下氧化缓冲容量消耗的数学模型.模拟计算结果表明,当AMD水头高度为10m时,厚度2m的污泥屏障经历AMD溶液38787a的渗透氧化,仍可保持原有的强烈还原状态,具备对重金属的固定效果.