稀土磁盘水处理方案技术经济比较

文章针对日照钢铁集团公司2150热轧水处理工程浊环水处理方案选择,对传统沉淀过滤法和先进的稀土磁盘法进行了对比和分析,稀土磁盘法在效果、占地、投资和运行维护费用上有较多优势,最终选用该工艺。     

沉淀硫酸钡废气治理现状及若干问题初探

以南风集团沉淀硫酸钡生产中废气治理为主,主要介绍了国内硫酸钡生产过程中废气治理现状,总结了废气污染物治理的措施,并针对废气产污环节若干问题进行进一步的分析探讨,提出相应的治理措施.     

水力负荷对辐流式初沉池污染物去除效果的影响

以沉砂池出水为原水,在沉淀试验研究颗粒截留速度u0基础上,通过动态试验考察水力负荷对辐流式初沉池污染物去除效果的影响。研究结果表明无机悬浮固体(FSS)分离和总悬浮固体(TSS)高效去除的颗粒截留速度u0分别为0.025 m/min和0.05 m/min。由于泥层截留作用,水力负荷qA在46.3 m3/(m2.d)时,辐流式初沉池污染去除最高效,TSS、总氮(TN)和总磷(TP)去除率分别达到81%,23%,59%。     

响应面法优化厌氧上清液除磷的研究

在用铁盐对厌氧段富磷上清液进行化学磷沉淀以实现磷的回收和达标排放的SBR系统中,为了减少铁盐化学除磷残余物可能对生物处理系统的影响,采用Box-Benhnken中心组合试验原理和响应面分析法,选择Fe:P、混凝搅拌强度、絮凝搅拌强度、搅拌时间等为自变量,残余铁离子为响应值,研究自变量之间的交互作用,以期优化化学除磷条件.通过Design-Expert 8.0软件得到1个二次响应曲面模型.得出最佳除磷条件:Fe:P比为1.40:1,搅拌强度为275r/min,快速搅拌时间为30s,絮凝搅拌强度为60r/min,絮凝时间为18min,沉淀时间为20min.在此条件下,化学混凝后残余铁离子浓度为0.37mg/L,化学除磷率大于97.66%.     

Compositions and sources of organic acids in fine particles (PM2.5) over the Pearl River Delta region, south China

Organic acids as important constituents of organic aerosols not only influence the aerosols' hygroscopic property, but also enhance the formation of new particles and secondary organic aerosols. This study reported organic acids including C14–C32fatty acids, C4–C9dicarboxylic acids and aromatic acids in PM2.5collected during winter 2009 at six typical urban, suburban and rural sites in the Pearl River Delta region. Averaged concentrations of C14–C32fatty acids, aromatic acids and C4– C9 dicarboxylic acids were 157, 72.5 and 50.7 ng/m3, respectively. They totally accounted for 1.7% of measured organic carbon. C20–C32fatty acids mainly deriving from higher plant wax showed the highest concentration at the upwind rural site with more vegetation around, while C14–C18fatty acids were more abundant at urban and suburban sites, and dicarboxylic acids and aromatic acids except 1,4-phthalic acid peaked at the downwind rural site. Succinic and azelaic acid were the most abundant among C4–C9dicarboxylic acids, and 1,2-phthalic and 1,4-phthalic acid were dominant aromatic acids. Dicarboxylic acids and aromatic acids exhibited significant mutual correlations except for 1,4-phthalic acid, which was probably primarily emitted from combustion of solid wastes containing polyethylene terephthalate plastics. Spatial patterns and correlations with typical source tracers suggested that C14–C32fatty acids were mainly primary while dicarboxylic and aromatic acids were largely secondary. Principal component analysis resolved six sources including biomass burning, natural higher plant wax, two mixed anthropogenic and two secondary sources; further multiple linear regression revealed their contributions to individual organic acids. It turned out that more than 70% of C14–C18fatty acids were attributed to anthropogenic sources, about 50%–85% of the C20–C32fatty acids were attributed to natural sources, 80%–95% of dicarboxylic acids and 1,2-phthalic acid were secondary in contrast with that 81% of 1,4-phthalic acid was primary.     

胡敏酸改性膨润土钝化污染土壤Pb&Cd及机理

通过盆栽试验,探讨了胡敏酸改性膨润土对重金属铅、镉污染土壤的钝化效果及机理。结果表明,铅、镉污染土壤中施加胡敏酸改性膨润土能显著降低小白菜中Pb、Cd的含量,在添加Cd(3 mg/kg)/Pb(250 mg/kg)污染土壤和Cd(1 0 mg/kg)/Pb(5 00 mg/kg)污染土壤上小白菜地上部分Pb含量分别比对照降低19.08%和47.91%,Cd含量分别比对照降低9.79%和14.89%。土壤本身对添加的重金属Pb/Cd有一定的耐受力和自我净化能力,在添加重金属后,添加的Pb/Cd元素大部分直接转化为较为稳定的碳酸盐结合态和铁锰氧化结合态。相关性分析显示小白菜的鲜重与小白菜Pb/Cd含量极显著负相关,进一步说明胡敏酸改性膨润土是通过提高小白菜的生物量,从而降低Pb/Cd在小白菜中的含量。     

神东矿区矿井水悬浮物处理技术

煤矿矿井水伴随煤炭开采过程产生,不同程度受煤粉、岩粉等悬浮物污染,有效降低悬浮物浓度是矿井水处理技术核心之一,本文以神东矿区含悬浮物矿井水为例对悬浮物处理技术进行说明,并进一步探讨工程应用中存在的常见问题。     

天津市夏季蜂窝状溶蚀器涂层溶液浓度确定的实验研究

于2013年7月1日～8月31日,在天津市南开大学理化楼楼顶,采用蜂窝状溶蚀器进行了溶蚀器涂层溶液最适浓度的探究实验.结果表明,在天津夏季,蜂窝状溶蚀器的碳酸钠涂层溶液最适浓度为3%,柠檬酸涂层溶液最适浓度为6%.含有溶蚀器系统的颗粒物采样法与传统采样法对比发现,含蜂窝状溶蚀器的采样系统所得到的PM2.5样品浓度有86%低于传统方法所得到的PM2.5样品浓度,其原因主要为1酸/碱性气体被去除,使其无法与富集在采样膜上的颗粒物发生反应,也无法吸附到颗粒物上;2溶蚀器系统采样过程中,部分颗粒物被捕集到溶蚀器上;3酸/碱性气体被去除,导致气-粒平衡被打破,部分颗粒物组分向气态转化.     

压力强化混凝除藻工艺中藻毒素安全性研究

为了研究预压力强化混凝沉淀蓝藻水处理工艺中,外加压力是否会引起藻细胞破裂,导致细胞内藻毒素泄漏到水体中,影响供水安全,实验对比研究了预压力和预氧化含藻水后藻毒素浓度的变化,以及预压力混凝沉淀和预氧化混凝沉淀除藻工艺中藻毒素浓度的变化和藻类去除效果.结果表明,含藻水经0.4~0.8 MPa压力加压后,水中藻毒素浓度没有增加,而次氯酸钠预氧化后水中藻毒素浓度大幅度增加.在0.5~0.8 MPa压力范围内,加压后混凝沉淀取得了较好的除藻除浊效果,蓝藻去除率达到90%~93.5%,浊度1.23~1.95 NTU,而次氯酸钠预氧化混凝沉淀后,蓝藻去除率56.2%~78.8%,浊度8.01~10.7 NTU,说明压力强化混凝沉淀除藻工艺是安全有效的.     

硫黄联合装置停工密闭吹扫的实现

介绍了中国石化济南分公司硫黄回收联合装置安全环保停工的过程,在硫黄回收联合装置停工前,研究讨论各装置停工密闭吹扫的流程及方法,并确定各装置停工吹扫的顺序、注意事项和前期准备工作。在各装置停工吹扫过程中,严格按照停工方案,采取了分装置吹扫,该装置吹扫完毕后立即加盲板隔离,最后放火炬公用系统采取倒吹扫,实现了装置停工密闭吹扫,达到了各装置停工酸性气系统吹扫不放火炬的要求。