7A52铝合金干湿交替情况下电偶腐蚀行为研究

目的研究海洋环境下7A52铝合金在干湿周浸使用过程中的电偶腐蚀现象。方法实验配制3.5%的Na Cl水溶液浸泡试样,实验周期为504 h,全浸试样作为对比试样,在实验周期内一直浸泡在Na Cl水溶液中。测试试样干湿周浸情况下7A52与5A06,38Cr Si之间的电偶电流及电偶电压,使用SEM分析腐蚀后的表面形貌。结果 7A52-5A06干湿周浸试样电偶电流变化不大,全浸试样电偶电流较初期变化较大,后期电偶电流的大小只有初期电偶电流大小的1/8左右,7A52-38Cr Si全浸试样与干湿交替情况下电偶电流基本相同。随着试验的进行,干湿交替及全浸情况下电偶电流的差异逐渐变大,电偶电流增大约为实验初期的10倍;全浸情况下试样表面腐蚀产物较致密,干湿周浸情况下腐蚀产物较为疏松。结论在3.5%的Na Cl水溶液干湿周浸情况下,7A52-5A06,7A52-38Cr Si的平均电偶腐蚀速度要大于全浸状态下的平均电偶腐蚀速度,干湿周浸情况下,7A52-5A06,7A52-38Cr Si腐蚀后试样表面形态具有较大差异,5A06在相同实验条件下的耐腐蚀性要好于7A52。     

A new process to improve short-chain fatty acids and bio-methane generation from waste activated sludge

As an important intermediate product, short-chain fatty acids(SCFAs) can be generated after hydrolysis and acidification from waste activated sludge, and then can be transformed to methane during anaerobic digestion process. In order to obtain more SCFA and methane,most studies in literatures were centered on enhancing the hydrolysis of sludge anaerobic digestion which was proved as un-efficient. Though the alkaline pretreatment in our previous study increased both the hydrolysis and acidification processes, it had a vast chemical cost which was considered uneconomical. In this paper, a low energy consumption pretreatment method, i.e. enhanced the whole three stages of the anaerobic fermentation processes at the same time, was reported, by which hydrolysis and acidification were both enhanced, and the SCFA and methane generation can be significantly improved with a small quantity of chemical input. Firstly, the effect of different pretreated temperatures and pretreatment time on sludge hydrolyzation was compared. It was found that sludge pretreated at 100°C for 60 min can achieve the maximal hydrolyzation. Further, effects of different initial p Hs on acidification of the thermal pretreated sludge were investigated and the highest SCFA was observed at initial p H 9.0with fermentation time of 6 d, the production of which was 348.63 mg COD/g VSS(6.8 times higher than the blank test) and the acetic acid was dominant acid. Then, the mechanisms for this new pretreatment significantly improving SCFA production were discussed. Finally,the effect of this low energy consumption pretreatment on methane generation was investigated.     

Biofilm-overproducing Bacillus subtilis B12ΔYwcc decreases Cd uptake in Chinese cabbage through increasing Cd-immobilizing related gene abundance and root surface colonization

Biofilm-producing bacteria can decrease Cd uptake in vegetables, but mechanisms underlying this effect are poorly characterized. In this study, two mutant strains B12ΔYwcc and B12ΔSlrR were constructed from a biofilm-producing Bacillus subtilis strain B12. Then, the impacts of strain B12 and its high biofilm-producing mutant strain B12ΔYwcc and low biofilm-producing mutant strain B12ΔSlrR on Cd availability and uptake in Chinese cabbage and the related mechanisms were investigated in the Cd-polluted soil. Strain B12 and its mutants B12ΔYwcc and B12ΔSlrR increased the dry biomasses of edible tissues by 54%–130% compared with the controls. Strain B12 and its mutant B12ΔYwcc reduced the soil available Cd content by 36%–50% and root and edible tissue Cd contents by 23%–50% compared with the controls. Furthermore, the mutant strain B12ΔYwcc reduced the edible tissue Cd content by 40% and increased the polysaccharide content by 23%, invertase activity by 139%, and gene copies of the cumA by 4.5-fold, epsA by 7.1-fold, and cadA by 4.3-fold, which were involved in Cd adsorption in the rhizosphere soils, respectively, compared with strain B12. The polysaccharide content and cumA, epsA, and cadA gene copy numbers showed significantly reverse correlations with the available Cd content. Notably, the mutant strain B12ΔYwcc showed better ability to colonize the vegetable root surface than strain B12. These findings demonstrated that the biofilm-overproducing mutant strain B12ΔYwcc increased the polysaccharide production and Cd-immobilizing related cumA, epsA, and cadA gene copies, resulting in lower Cd availability and accumulation in Chinese cabbage in the Cd-polluted soil.     

基于层次分析法评估长江上游宜宾段工业园区环境风险

长江宜宾段工业园区中分布着众多化工企业,对周边流域生态环境具有潜在风险。选择环境风险源、管控机制、风险受体3个准则层,包括行业类型、园区企业生产工艺、环境管理体系、环境风险管理体系、受纳水体环境等13个指标层建立评估模型体系;采用层次分析法(AHP)评估了宜宾市6家工业园区(A~F)的环境风险评。结果表明,6家工业园区准则层权重总占比表现为环境风险源(69.939)>环境风险受体(38.076)>风险管控机制(33.420),各园区环境风险综合值表现为B园区(19.147)相似文献   

可见光促有机物诱导铁还原的多相类芬顿体系强化效能与机制

近年来,亚铁离子活化过硫酸盐的类芬顿(Fe²⁺-PMS/PS)高级氧化技术发展日趋成熟,但因Fe³⁺无法还原导致反应停止的问题仍制约其大规模应用.结果发现,当把以双酚A（BPA）为代表的某些有机物与Fe³⁺和TiO₂混合,所形成的某种络合物可以拓宽TiO₂光响应范围捕获可见光,通过TiO₂将光生电子传递给Fe³⁺进行还原,从而实现Fe³⁺/Fe²⁺的无限循环.依据上述原理,构建了可见光下BPA-TiO₂-Fe³⁺-PS复合体系来降解BPA,并对其催化性能、催化机制和影响因素进行探讨.结果表明,该体系具有突出的催化性能,60 min内BPA(50 mg·L^-1)降解率达到93.1%,矿化度达到70%.同时验证该体系可以通过双酚A自生光电子还原Fe³⁺, 60 min还原得到的Fe²⁺稳...     

铁法煤业集团三台子污水处理厂的工艺改造

介绍了将铁法煤业（集团）有限责任公司三台子矿区污水处理工程工艺由以卡鲁塞尔氧化沟为主体的二级生化处理工艺改造为更适宜在北方气候条件下运行的A-O法工艺；同时对系统的启动进行了介绍。     

Water quality characteristics along the course of the Huangpu River （China）

Huangpu River is about 114.5 km from upriver Dianfeng to downriver Wusong,near the estuary of the Yangtze River.It plays a key role in supplying water for production,life,shipment and irrigation.With the industrial development,the pollution of the Huangpu River has become serious recently.The biological oxygen demand (BOD),total nitrogen (TN),total phosphorus (TP),oil,phenol and suspended solids (SS) were lower in the upstream sites than in the downstream sites,indicating pollutants being input along its course. Water quality was the worst in the Yangpu site,near the center of Shanghai City.Dissolved oxygen (DO) content was less than 2 mg/L in the site of Yangpu in July.Among relations between thirteen characteristics,relations between BOD,DO,TN,TP,NH_4~ -N, NO_3~--N and the count of total bacteria or Escherichia coli were significant and interdependent.Inner relationships between these main characteristics in the Huangpu River were studied.High nutrient concentration led to growth of microorganisms,including E.coli. Degradation of organic matters and respiration of bacteria made oxygen concentration decreased in the water body,and DO was a key factor for nitrification-denitrification process of nitrogen.In the Yangpu site,DO was decreased to less than 3.0 mg/L with BOD higher than 7.5 mg/L in May and July.Low DO concentration will decrease nitrification rate.Nitrification need at higher DO value than other organic substrate oxidation.Consequently,river water contains low NO_3~--N values with high amounts of TN and NH_4~ -N there.This will block the self-purification of surface water,by decreasing the rate of nitrification-denitrification transformation process in the water body.     

Adsorption thermodynamics and kinetic investigation of aromatic amphoteric compounds onto different polymeric adsorbents

The adsorption behavior of p-aminobenzoic acid and o-aminobenzoic acid onto the different polymeric adsorbents was systematically investigated as a function of the solution concentration and temperature.Experimental results indicated that the equilibrium adsorption data of the four polymeric adsorbents fitted well in the Freundlich isotherm.The adsorption capacity of multi-functional polymeric adsorbent NJ-99 was the highest,which might be attributed to the strong hydrogen-bonding interaction between the amino groups on the resin and the carboxyl group of aminobenzoic acid.The adsorption capacity of o-aminobenzoic acid onto any adsorbent was higher than p-aminobenzoic acid.Thermodynamic studies suggested the exothermic,spontaneous physical adsorption process.Adsorption kinetics results showed that the adsorption followed the pseudo-second-order kinetics model and the intraparticle mass transfer process was the rate-controlling step.     

医院污水处理系统工艺改进的研究初探

通过对昆明某医院污水处理系统工艺两次改造的实验研究表明：医院污水经深化处理后比未经深化处理污水的COD、SS、氨氮、色度、粪大肠菌群数都大幅度降低，达到了GB18466-2005《医疗机构水污染物排放标准》和GB18920-2002《城市污水再生利用城市杂用水水质》中冲厕及绿化用水。建议循环再利用。     

氨法脱硫技术在化工企业燃煤锅炉中的应用

介绍了LS氨法喷雾烟气脱硫技术在云南解化集团有限公司的使用情况，针对化工企业实际情况和应用过程中出现的问题，提出改进措施和技术创新，使该项技术在应用中更加完善。