MAP晶体捕集反应器回收猪场厌氧消化液中磷的研究

研究了磷酸铵镁(MAP)结晶法晶体捕集反应器在曝气条件下回收猪场厌氧消化液中磷元素的能力.结果表明,利用曝气方式提高猪场厌氧消化液的p H值,进行MAP结晶回收磷完全可行.MAP的饱和度指数(SI)与废水p H值呈多项式函数关系,结晶反应的最佳p H值为8.5~9.0;随着曝气时间延长至180 min,反应器内废水p H值可提高至8.5;常温下(25℃),反应器内MAP回收磷的反应动力学的反应级数(n)为1.98,速率常数(K25)为7.04×10-4L·mg-1·min-1;反应器单个运行周期为270 min;磷的平均去除率为82%左右.MAP晶体捕集反应器上的晶体在一个反应周期内即可成形,随着反应周期的增加,晶体颗粒逐渐增大.利用扫描电镜和X射线衍射仪对捕集器所捕集的晶体进行了表征,证实晶体为高纯度的MAP.     

Preparation of n-Octadecane@MF resin microPCMs and its application in temperature control of esterification reactions

Reaction thermal runaway accidents occur frequently and occupy a high proportion in chemical accidents. Reducing accidents by controlling reaction temperature is of great implication to enhance the safety level of chemical processes. Phase change materials (PCMs) have a good energy storage potential, which can rapidly convert the reaction exotherm in the reaction process into its own phase change latent heat, urgently control the reaction temperature, and enhance the process thermal safety level. In this study, using n-octadecane as the core and melamine-formaldehyde (MF) resin as the shell, microencapsulated phase change materials (microPCMs) was made, which has a smooth spherical shape, good thermal stability, and a phase change enthalpy up to 162.87 J/g. The homogeneous esterification reaction of 2-butanol (2 B) and propionic anhydride (PA) was selected as the target reaction, and then the reaction was scaled up equivalently to investigate the effect of amplification to the reaction system. The results indicated that the temperature control of the esterification reaction system by microPCMs is the synergy between physical inhibition and chemical inhibition. The reaction temperature could be controlled by adding microPCMs, and the temperature control effect improved with the increase of microPCMs addition. In large scale reactors, microPCMs still has certain temperature control ability after being added.     

双驱动反应器中热钾碱吸收二氧化碳的动力学研究

采用双驱动反应器研究了热钾碱吸收二氧化碳的反应动力学,根据双膜理论,应用CO_2-H_2O体系,实验首先对气相传质过程进行了研究,结果表明:当气相体积流量为80 m L·min~(-1)时,气相搅拌速度在100 r·min~(-1)时可认为气膜阻力消去.通过改变液相搅拌转速,研究了液相传质系数kL变化规律,获得了k_L的无因次关联式.根据热钾碱吸收CO_2反应机理,获得了宏观动力学方程,并结合溶液的非理想性,对速率方程中的浓度效应进行了校正,通过实验测定并进行了模型参数估值,各参数分别为:表观活化能E_(ob)=21.9308 k J·mol~(-1),表观反应级数n=0.1399,表观指前因子K'_0=1.1908×10~(-4)mol·m~(-2)·s~(-1)·Pa~(-1).在此基础上,通过计算获得了热钾碱吸收CO_2的本征动力学方程,各模型参数分别为:本征反应活化能E=59.57 k J·mol~(-1),指前因子k_0=2.1802×1011m~3·mol~(-1)·s~(-1).为进行整个过程反应机制的判断,计算了膜内转化系数γ,结果表明该值远大于2,可知CO_2吸收为快速反应过程,反应主要集中在膜内完成,并由此可知工业反应器选型应采用比相界面积较大的填料塔为优.     

UV/H2O2氧化降解克拉霉素的反应动力学及影响因素

克拉霉素用量大、检出频率高、生态风险大,已被欧盟列为优先监测污染物.针对传统污水处理厂难以完全去除克拉霉素的问题,主要研究了UV/H_2O_2降解克拉霉素的效果和反应动力学,探讨了pH、天然有机质(NOM)和水中共存阴、阳离子对UV/H_2O_2降解克拉霉素的影响.结果表明:单一UV对克拉霉素的光降解符合准一级反应动力学模型,其反应速率常数为0.0016 min~(-1).UV/H_2O_2对克拉霉素的降解符合准一级反应动力学模型,且克拉霉素的降解速率随H_2O_2浓度的增大而增大,在H_2O_2浓度为40 mmol·L~(-1)时,克拉霉素降解的反应速率常数为0.0284min~(-1).克拉霉素与·OH的二级反应速率常数为(2.36±0.20)×10~(10)L·mol~(-1)·s~(-1).碱性条件有利于克拉霉素的降解;NOM(2~10 mg·L~(-1))会抑制克拉霉素的降解,且随NOM浓度增大而增大;共存阴离子CO_3~(2-)对克拉霉素降解无影响,HCO_3~-、NO_3~-、Cl~-会抑制克拉霉素的降解,抑制程度的大小顺序为NO_3~-HCO_3~-Cl~-;共存阳离子Ca~(2+)、Mg2+、Cu~(2+)、Fe~(3+)会抑制克拉霉素的降解,抑制程度的大小顺序为Fe~(3+)Cu~(2+)Mg2+Ca~(2+).     

纳米磁铁矿/生物质炭催化对Fenton氧化降解苯酚的增强机理

以生物质炭负载纳米磁铁矿(nMBC)作为催化剂,采用非均相Fenton反应体系对模拟苯酚废水进行氧化降解处理研究,确定n MBC—Fenton法处理苯酚废水的最佳工艺条件,并揭示其强化机理。实验结果表明:对于质量浓度为50 mg/L的苯酚废水,其最佳降解条件为温度为45℃,pH为3.0,H_2O_2浓度为5 mmol/L,nMBC用量为2.0 g/L。反应进行20 min后,苯酚去除率可达约100%。nMBC剂量、废水初始pH和温度等因素均对处理效果有较大影响,其中pH决定苯酚去除率,而nMBC剂量是影响降解速率的主要因素。此外,nMBC—Fenton法催化氧化降解苯酚过程符合准一级动力学反应(R~2>0.97)。     

N,N’-二(2-羟丙基)哌嗪-H2SO4水溶液吸收SO2动力学

在鼓泡式反应器中,以N,N’-二(2-羟丙基)哌嗪(HPP)-硫酸水溶液为吸收剂,利用初始速率法探讨了SO2吸收反应动力学.结果表明:HPP-H2SO4水溶液吸收SO2为快速反应;吸收速率NA随着SO2进口体积浓度yA和吸收剂浓度CN的增大而增大,随着吸收温度T的升高而降低;吸收速率对CN是0.5级反应,对yA为0.85级反应.同时,建立了HPP-H2 SO4水溶液吸收SO2的吸收速率NA与CN、yA及T之间的经验关系式,发现该经验关系式的预测值与实验值符合较好,可用于工程设计计算.     

纳米Fe3 O4-H2 O2 非均相Fenton反应催化氧化邻苯二酚

由四氧化三铁(Fe3O4)-过氧化氢(H2O2)构成的非均相Fenton体系主要利用H2O2分解产生的羟基自由基氧化去除难降解有机污染物.研究了邻苯二酚在纳米Fe3O4-H2O2构成的非均相Fenton体系中的催化氧化特征,同时对实验室制备的纳米级Fe3O4和商品微米级Fe3O4两种催化剂的催化活性进行比较,并考察了H2O2初始浓度对邻苯二酚的催化氧化的影响.结果表明,自制纳米Fe3O4-H2O2体系较商品Fe3O4-H2O2体系,能更快速地去除溶液中的邻苯二酚和总有机碳(TOC),邻苯二酚的去除率接近100%,同时能迅速催化H2O2分解.邻苯二酚的催化氧化反应遵循准一级反应动力学方程,H2O2的分解反应能用三级反应动力学方程较好拟合.此外,反应过程中铁释放低于0.3 mg.L-1,不足以启动均相Fenton反应,反应机制为由界面反应控制的非均相反应机制.     

Destruction of 4-phenolsulfonic acid in water by anodic contact glow discharge electrolysis

Destruction of 4-phenolsulfonic acid (4-PSA) in water was carried out using anodic contact glow discharge electrolysis. Accompanying the decay of 4-PSA, the amount of total organic carbon (TOC) in water correspondingly decreased, while the sulfonate group of 4- PSA was released as sulfate ion. Oxalate and formate were obtained as minor by-products. Additionally, phenol, 1,4-hydroquinone, hydroxyquinol and 1,4-benzoquinone were detected as primary intermediates in the initial stages of decomposition of 4-PSA. A reaction pathway involving successive attacks of hydroxyl and hydrogen radicals was assumed on the basis of the observed products and kinetics. It was revealed that the decay of both 4-PSA and TOC obeyed a first-order rate law. The effects of different Fe ions and initial concentrations of 4-PSA on the degradation rate were investigated. It was found that the presence of Fe ions could increase the degradation rate of 4-PSA, while initial concentrations lower than 80 mmol/L had no significant effect on kinetic behaviour. The disappearance rate of 4-PSA was significantly affected by pH.     

针铁矿/H_2O_2体系对染料橙黄Ⅱ光化学脱色的实验研究

以针铁矿(α-FeOOH)为光催化剂,在金属卤灯(λ≥365 nm)照射下,对α-FeOOH与H2O2组成的非均相Fenton体系内橙黄Ⅱ的脱色进行了研究。考察了初始pH值、α-FeOOH用量、H2O2浓度和反应时间对橙黄Ⅱ脱色过程的影响。结果表明,在α-FeOOH用量为0.3 g/L,H2O2浓度为6 mmol/L,pH 3.0时,橙黄Ⅱ的脱色效果最好,光照90 min后脱色率达到99.4%。橙黄Ⅱ的光降解反应动力学符合Langmuir-Hinshelwood(L-H)动力学方程。对不同时间溶液中的总有机碳(TOC)监测,结果表明体系中橙黄Ⅱ的矿化率较低,通过对溶液中铁(Fe2+和总铁)溶出的测定,说明可能的反应涉及针铁矿表面的铁循环。     

Photocatalytic degradation of C. I. Reactive Red 24 solution with K6SiW11O39SnII

Environmental friendly materials, K₆SiW₁₁O₃₉Sn (SiWSn), was synthesized. SiWSn photocatalytic decomposition of C. I. Reactive Red 24 (RR24) with the UV-lamp (253.7 nm, 20 W), Xenon lamp filtered less than 390 nm light (500 W) and sun light was investigated. The results showed that RR24 solution could be effectively decolorized with the SiWSn photocatalyst. The photocatalytic degradation efficiency of RR24 with SiWSn was affected by the initial concentration of RR2 solution, the amount of SiWSn and the photolysis time. It is demonstrated that the process of photodegradation of RR24 with SiWSn is a pesudo first-order reaction, which can be described by Langmuir-Hinshelwood equation. Hydroxyl radicals and holes are both the main oxidants in the photocatalytic reaction of RR24 with SiWSn.