Removal of hydrophobic volatile organic compounds with sodium hypochlorite and surfactant in a co-current rotating packed bed

A co-current flow rotating packed bed was applied to remove volatile organic compounds(VOCs) by sodium hypochlorite(Na Cl O) and surfactant(sodium dodecyl benzene sulfonate,SDBS) from air stream. Xylene was used as a model VOC herein. The effect of p H,concentration of Na Cl O and SDBS solution, liquid flow rate, gas flow rate and rotational speed on xylene removal efficiency and overall mass transfer coefficient(KGa) were discussed. Then, a correlation for KGa of the co-current rotating packed bed was proposed by fitting the experimental data of KGa and independent variables of liquid/gas ratio,rotational speed, p H, Na Cl O concentration and treatment time, which was in good agreement with the experimental data(the deviation ≤± 30%).     

Selection of cost-effective magnesium sources for fluidized struvite crystallization

Struvite crystallization has been considered a promising approach to recover phosphorus from wastewater. However, its practical application is limited, probably because of the high cost of magnesium(Mg). In this study, a comprehensive economic analysis was conducted using five Mg sources(MgCl_2, MgSO_4, MgO, Mg(OH)_2, and bittern) during the operation of a pilot-scale fluidized bed reactor(FBR), using swine wastewater as the case matrix. First, the economic operating conditions were investigated, and subsequently, the performance and the costs of the five Mg sources were compared. The results indicated that the FBR could be operated most economically at pH of 8.5 and Mg to phosphorus(Mg/P) molar ratio of 1.5. Under these conditions, no significant differences in phosphorus removal and product quality could be found between the five Mg sources. Selecting the most economical Mg source was thus highly dependent on the prices of the reagents and Mg sources. Low-solubility Mg sources were preferable when NaOH was priced higher, while high-solubility Mg sources proved more economical when HNO_3 was expensive. The bittern was the most economical choice only when the distances for total inorganic orthophosphate removal and struvite recovery were shorter than 40 and 270 km, respectively. The current study provides an overview of the economic selection of an Mg source, which can help reduce the cost of struvite crystallization.     

Particles and porous tablets based on Fe0/ZSM-5 composites prepared by ball-milling for heavy metals removal: Dissolved Fe2 +, pH, and mechanism

Novel, low-cost Fe~0/ZSM-5-based particles and porous tablets were prepared by a ballmilling method and used for the removal of Pb~(2+) in solution. Solid-phase characterization by scanning electron microscopy coupled with energy-dispersive X-ray spectroscopy(SEMEDS) and transmission electron microscopy(TEM) revealed that the Fe0 microparticles were evenly loaded and tightly immobilized on the surface of ZSM-5 because of the extrusion/welding impact during ball-milling. For different Pb~(2+) concentrations, batch experiments indicated that the removal of Pb~(2+) increased with the decline of dissolved Fe2+and p H value in the solution for particles; opposite results were obtained for the tablets. The differences in the contact between both materials and Pb~(2+) were the main factor controlling Pb~(2+) removal in the solution. Investigation into the effect of initial p H value revealed that high p H reduced the number of electrons released from Fe corrosion. Consequently, low levels of removed Pb~(2+) and dissolved Fe~(2+) were synchronously observed. Also, simulated electroplating wastewater was treated using the prepared particles and porous tablets,and the removal order of Pb~(2+) Cr~(6+) Cu~(2+)≈ Cd~(2+) was observed. The Fe~0/ZSM-5 particles and tablets prepared through ball-milling show potential as materials for treatment of Pb~(2+) and other toxic metals.     

利用人工湿地脱除废水中氨氮和磷的统计分析

论述了利用人工湿地脱除废水中氨氮和正磷酸盐类污染物的统计分析,调查基于国外文献报道的研究数据和实际运行数据.结果表明,污染物输入和输出浓度关系可以由线形规律获得关联,这些污染物因子脱除动力学也可以用适于BOD降解的Kichuth一级脱除方程来描述.由不同人工湿地关联的一级动力学常数具有较好的相关性.     

生活污水二级生物处理后的铁盐混凝除磷试验研究

以生活污水二级生物处理后的出水为研究对象，考察了铁盐对浓度在2－4mg/L范围内的总磷的混凝去除效果及影响因素。结果表明，铁盐除磷的最佳pH为7.5-8；铁盐投加量较低时，适当提高GT值可使总磷去除率增加15％－20％；在适当的混凝搅拌条件下，三阶铁盐和聚合硫酸铁对总磷的去除率均在70％以上，混凝后过滤可使出水中总磷降至0.5mg/L以下。     

移动床生物膜反应器及其应用

介绍了移动床生物膜反应器（MBBR）的特点，讨论了MBBR中填料的材质、大小、形状、比重、数量及其有效比表面积，搅拌类型和搅拌方式，有机负荷的大小，水力停留时间，废水pH的变化等因素对移动床生物膜反应器运行效果的影响，综述了单独MBBR工艺、MBBR与活性污泥共池工艺，MBBR与其他工艺的组合工艺在废水处理中的应用现状。     

低负荷运行对城市污水生物除磷的影响

针对目前国内较多的城市污水处理厂长期处于低负荷运转的状态，进行了现场生产性与静态模型的试验研究。结果表明，长期低负荷运行是导致生物除磷效率下降的主要原因。长期低负荷运行使聚磷菌微生物细胞内储存物质（PHB、Glycogen、poly-P等）含量下降，使生物除磷能力丧失。为了保证生物脱氮除磷处理系统的除磷效率，可通过调节生化反应容积、控制好氧区的曝气等手段，使处理系统的负荷控制在适合的范围内。     

Study on the effect of landfill leachate on nutrient removal from municipal wastewater

In this study, landfill leachate with and without pre-treatment was co-treated with municipal wastewater at different mixing ratios. The leachate pre-treatment was achieved by air stripping to removal ammonia. The objective of this study was to investigate the effect of landfill leachate on nutrient removal of the wastewater treatment process. It was demonstrated that when landfill leachate was co-treated with municipal wastewater, the high ammonia concentration in the leachate did not have a negative impact on the nitrification. The system was able to adapt to the environment and was able to improve nitrification capacity. The readily biodegradable portion of chemical oxygen demand (COD) in the leachate was utilized by the system to improve phosphorus and nitrate removal. However, this portion was small and majority of the COD ended up in the effluent thereby decreased the quality of the effluent. The study showed that the 2.5% mixing ratio of leachate with wastewater improved the overall biological nutrient removal process of the system without compromising the COD removal efficiency.     

亚氯酸钠/纯碱溶液处理硝基甲烷工艺废气的脱硝研究

针对硝基甲烷工艺尾气中的高浓度氮氧化物的去除问题,在自行设计的四级填料喷淋吸收塔中进行湿法脱硝研究,实验条件下总脱硝效率能达到85%。实验先采取亚氯酸钠溶液对尾气进行氧化处理,后使用纯碱溶液对尾气进行吸收处理,并对气速、液气比、温度、溶液pH值等工况参数进行了研究,确定了最佳实验条件。     

巢湖合肥地区洗衣粉排磷占入湖磷贡献率的研究

合肥地区人均洗衣粉用量为3．12kg/a,洗衣粉总用量为8345t/a,洗衣粉带入水体的总磷量为256．08t/a,占入湖总磷负荷量的13．62％。因此,实行“禁磷”措施后,可削减该地区入湖总磷负荷量的13．62％,对改善巢湖水质将会起到一定的积极作用。