Drying of granulated wood ash by flue gas from saw dust and natural gas combustion

At the district heating plant of Kalmar, Sweden an on-line unit for production of granulated wood ash for nutrient recycling on forest soils is being applied. Currently, the granules are dried by hot air from an oil-fired burner. The objective of this work was to investigate how drying by flue gas affects the hardening of granules, or impacts their chemical composition and properties. Ninety-six granule samples were treated by flue gas from natural gas combustion in a laboratory pilot scale flue gas generator. CO₂, CO, O₂, C₃H₈ and NO concentrations were varied during the experiment. Additionally, some samples were treated by flue gas from combustion of sawdust at the heating plant in Kalmar. Drying by flue gases did not affect the chemical composition of granules, but minor effects were seen in their mineralogy. The carbonate content was slightly higher in granules treated with flue gas from natural gas combustion compared to the granules dried by hot air only, when measured by wet chemical methods. Results from XRD analysis imply that the calcite content is higher and the portlandite and arcanite content slightly less in granules treated with flue gas from sawdust combustion compared to the granules dried by hot air only. The results from this investigation showed no negative effects on ash granule composition or physical structure by the use of a flue as a drying medium.     

在降雨量极少的条件下日本琵琶湖北湖主要环境因子的动态变化和机理的研究(Ⅰ)(英文)

琵琶湖是日本第一大淡水湖,20世纪60年代以来,由于经济的发展,湖水水质逐步变坏。1977年湖的北部出现赤潮,1 983年湖的南部出现了湖泊富营养化的产物微囊藻。多年来,在深水区湖水温度分层情况下,叶绿素α或浮游植物主要分布在湖的表层。但在1 994年夏季降雨量极少的情况下,在深水区叶绿素α或浮游植物主要分布在温跃层的附近,这种现象在琵琶湖是罕见的。分析发现叶绿素的峰值在湖水温度分层时出现在温跃层的上部,而且底边界层同时出现了低溶氧和高浊度的现象。叶绿素α和溶氧、浊度的对应关系表明温跃层是一光合成活跃的区间。本文通过流体力学方程计算,结果表明随着温度的降低,粘滞力就会增加,在温跃层出现了随水深增加,粘滞力急剧增大的情况。由此可见颗粒物在温跃层顶的上部沉降速度比温跃层内快,因此颗粒物高浓度出现在温跃层内。计算结果同时发现,在水深10～20 m(对应于温跃层),分子扩散系数最小,一旦颗粒物进入这一区间就不易扩散出去。由于温跃层是一分子扩散系数小、粘滞力高的区间,所以温跃层是颗粒物和营养盐的富集区,出现了藻类和叶绿素浓度的峰值。     

在降雨量极少的条件下日本琵琶湖的环境因子的分布(英文)

琵琶湖是日本第一大淡水湖,20世纪60年代以来,由于经济的发展,湖水水质逐步变坏。1977年湖的北部出现赤潮,1983年湖的南部出现了湖泊富营养化的产物微囊藻。多年来,在深水区湖水温度分层情况下,叶绿素a或浮游植物主要分布在湖的表层(Tezuka,1984)。但在1994年夏季,降雨量极少的情况下,在深水区叶绿素a或浮游植物主要分布在温跃层附近,这种现象在琵琶湖是罕见的(Nakanishi,1995)。最近,琵琶湖北湖的藻类爆发显著增加了溶氧的消耗,导致了湖底层溶氧的减少。如果湖底层溶氧持续减少,底泥储存的磷就会释放到湖水中,从而加快湖泊富营养化的进程。本文分析了琵琶湖南北10个点1994年4月至1995年3月每月1次的常规观测资料,深入剖析了全湖物理化学参数的时空分布,不仅发现叶绿素的峰值在湖水温度分层时出现在温跃层的上部,而且湖底边界层同时出现了低溶氧和高浊度的现象。分析认为绿素a和溶氧、浊度的对应关系表明温跃层是一光合成活跃的区间。     

在降雨量极少的条件下日本琵琶湖北湖主要环境因子的动态变化和机理的研究(Ⅰ)

琵琶湖是日本第一大淡水湖,20世纪60年代以来,由于经济的发展,湖水水质逐步变坏.1977年湖的北部出现赤潮,1983年湖的南部出现了湖泊富营养化的产物微囊藻.多年来,在深水区湖水温度分层情况下,叶绿素α或浮游植物主要分布在湖的表层.但在1 994年夏季降雨量极少的情况下,在深水区叶绿素α或浮游植物主要分布在温跃层的附近,这种现象在琵琶湖是罕见的.分析发现叶绿素的峰值在湖水温度分层时出现在温跃层的上部,而且底边界层同时出现了低溶氧和高浊度的现象.叶绿素α和溶氧、浊度的对应关系表明温跃层是一光合成活跃的区间.本文通过流体力学方程计算,结果表明随着温度的降低,粘滞力就会增加,在温跃层出现了随水深增加,粘滞力急剧增大的情况.由此可见颗粒物在温跃层顶的上部沉降速度比温跃层内快,因此颗粒物高浓度出现在温跃层内.计算结果同时发现,在水深10～20 m(对应于温跃层),分子扩散系数最小,一旦颗粒物进入这一区间就不易扩散出去.由于温跃层是一分子扩散系数小、粘滞力高的区间,所以温跃层是颗粒物和营养盐的富集区,出现了藻类和叶绿素浓度的峰值.     

井下火花——矿井火灾的点燃源

考察了各类井下火花诱发灾害的典型实例以及８０年代以来国内外的研究状况，指出深入开展这一课题的研究对防灾的重要性．     

回采工作面瓦斯涌出量预测的神经网络方法

回采工作面瓦斯涌出量受煤层瓦斯含量、工作面产量和采煤方法等各种因素的影响 ,笔者通过研究得出 :回采工作面瓦斯涌出量与煤层的赋存条件和开采条件之间是一种非线性关系 ,但目前还难以用精确的数学建模来求解。因此 ,提出了一种应用BP人工神经网络模型和算法 ,建立工作面瓦斯涌出量预测模型 ,从而预测不同开采条件下回采工作面瓦斯涌出量。实际应用表明 ,模型精度能满足要求。笔者还对隐含层神经元数目对步长影响作了讨论。     

City hazardous gas monitoring network

In our today's societies, many dangerous chemicals are produced and transported. Due to the vast use of chemicals, more chemical accidents are taking place with huge losses. In this study a city hazardous gas monitoring network was designed to detect the dispersion of toxic and combustible gases in the primary stages. The network could cover hazardous chemical facilities, important hazardous chemical routes, warehouses and special locations which may be the targets of terrorist attacks. The network is consisted of several local networks and a central control panel complex. Each local network has a local control panel in the center and many detectors and sounders around it at distances less than 3000 m that communicate with the local control panels wirelessly. In each location there are two types of gas detectors, toxic and combustible, and a sounder which are equipped with a wireless, radio frequency modem allowing the units to communicate readings and other information on a real-time basis with a remotely located local control panel. High sensitive Photo Ionization Detectors, PIDs, are used to provide fast and low-level on-site screening for chemicals contamination. Combustible gas detectors are the second choice to sense the combustible gas and verify the readings of PIDs in this regard. The central panel consists of several connected control panels work uniquely helping a computer set and the appropriate software and communicate with local control panels via telephone lines. All of the network components are shown on the monitor of central panel with special symbols by geographical information system program. The system is fully addressable so that the high level detection of a detector produces a blinking color double-circle around its symbol in GIS plan. In case of high level gas detection, a team of experts who are fully equipped with different portable detectors depart to the site to test the field to identify the chemicals. All readings of detectors are saved in a data bank and then analyzed to find any chemicals spills and leakages. The network was simulated by a special program so that the components of local networks and the central panel are shown in separate windows. By clicking on one detector on environmental window the formerly designed responses will be activated in central panel window.     

顶空气相色谱法测定食品中甜蜜素含量

采用顶空气相色谱法测定食品中甜蜜素含量,探讨了气液相平衡条件及色谱条件的选择,实验结果表明甜蜜素的标准溶液在0.1-0.4μg/l范围内具有良好的线性关系,回收率为87.5%-101.8%,相对标准偏差为2.6%.     

Systems thinking in a gas explosion accident – lessons learned from Taiwan

On July 31, 2014, at around 23:57, several huge explosions occurred that lasted for 2 h in Kaohsiung City, Taiwan. As a result of a gas leak from a ruptured underground pipeline, the catastrophic incident destroyed more than 6 km of roads, killed 32 people, injured 321 people, and damaged 3259 buildings. Pipeline explosions have been reported as a repeatedly occurring problem, indicating that (1) complex systems are difficult to manage and control, and (2) humans are unable to effectively learn from experiences of accidents. Initial analyses results reveal that root causes of this incident were a combination of a series of complex chain reactions, which eventually led to propylene leakage and explosion. This is a systematic problem, which can hardly be investigated or analyzed by traditional research approaches. Based on the investigation reports and “systems thinking” method, this study develops causal loop diagrams for the Kaohsiung gas explosion to explore the root causes of the disaster. The research results indicate that (1) this pipeline explosion incident was the result of the chain reactions and was the output of a complex system; (2) the mental model of “production first” and “experience gap” were the root causes of the disaster; and (3) to achieve a higher safety standard, continuous education to improve the mental model of “safety first and safety over production” are essential. The findings of this study may contribute toward the improvement of the standard operating procedure for disaster management and preventing similar incidents in the future.     

Experimental study on the synergistic inhibition effect of nitrogen and ultrafine water mist on gas explosion in a vented duct

In this study, in order to research the synergistic inhibition effect of nitrogen and ultrafine water mist on gas explosion in a vented duct, a semi-confined transparent chamber was designed with the size of 120 × 120 × 840 mm, and the experiments were carried out with stoichiometric methane/air premixed mixture (fraction of methane: 9.5%), adding different fractions of nitrogen and ultrafine water mist. The experimental results showed the following: The combination of nitrogen and ultrafine water mist had a synergistic inhibiting effect on methane/air explosion, which was preferable to the single use of any kind. With the increase of spraying time of water mist and fraction of nitrogen, the initial shape of the explosion flame became snakelike, and at the same time the peak flame propagation speed and peak overpressure decreased significantly. When the nitrogen fraction was increased to 10% and the mist spraying time was increased to 2min, synergistic inhibiting effect on overpressure was high efficient. However, with the increase of spraying time of water mist and fraction of nitrogen going on, the amount of increase of explosion inhibition efficiency was gradually reduced.