钻井废液-废水处理一体化设备的研究及应用

介绍了钻井清洁生产的核心设备——钻井废液-废水处理一体化设备的原理、流程和处理效果。实践证明,用这种一体化设备处理普通聚合物钻井液体系产生的钻井废液时,设备排水质量可达到GB8978-1996《污水综合排放标准》(一级标准或二级标准);当用于处理高温深井聚合物-磺酸盐复杂钻井液体系产生的钻井废液时,除了COD外, 排出水的主要水质指标可达到GB8978-1996《污水综合排放标准》(二级标准)。用该设备处理后的泥渣含水率低于55%,泥渣体积减少了88%。     

用酵母菌处理油田钻井废水的研究

从冀东油田钻井现场采集的受钻井废水污染的土壤样品中筛选到2株酵母菌种（Wickerhamiella domercqii和Candida boidinii）。将这2种酵母菌混合后在pH4.0的条件下处理钻井废水,TOC去除率为40．5％,略高于驯化后的活性污泥在中性条件下的处理效果（35．2％）。分子量的切割实验结果表明,在分子量为60000以上的有机质中,也有部分有机质具有生物可降解性。     

Remote sensing-based neural network mapping of tsunami damage in Aceh, Indonesia

In addition to the loss of human life, the tsunami event of 26 December 2004 caused extensive damage to coastal areas. The scale of the disaster was such that remote sensing may be the only way to determine its effects on the landscape. This paper presents the results of a neural network-based mapping of part of the region of Aceh, Sumatra. Before-and-after satellite imagery, combined with a novel neural network methodology, enabled a characterisation of landscape change. The neural network technique used a threshold of acceptance for identification, in combination with a bootstrapped identification method for identifying problem pixels. Map analysis allowed identification of urban areas that were inaccessible by road, and which aid agencies could therefore only reach by air or sea. The methods used provide a rapid and effective mapping ability and would be a useful tool for aid agencies, insurance underwriters and environmental monitoring.     

Evaluation and application of blast furnace slag as a mud cake modifier

The aim of this research was to reuse blast furnace slag (BFS) as a mud cake modifier (MCM) to improve the annular isolation quality in oil and gas wells. For the optimum formula of drilling fluid, the effects of MCM on the drilling fluid rheology were investigated. The relationship between the MCM addition and shear strength at cement–formation interface (SSCFI) was evaluated. The experimental results showed that the optimized formula of the drilling fluid has 1.0 wt% MCM and 0.5 wt% XY-27. The simulation results showed that SSCFI increased significantly with the addition of MCM. Based on the mechanism analysis of BFS as an MCM to improve SSCFI, it is found that the transformation of mud cake to agglomerated cake can be the main reason. The application results showed that the success rate of five wells reached 100%, and the rate of quality in cement was 100%. Especially, the average high quality rate of five wells reached 83.7%. Compared with conventional methods, the average high quality rate is increased by 32.6% points. This research provides a new way for sustainable utilization of BFS.     

三维电极法处理钻井废水影响因素分析

采取电化学法处理某钻井废水,考察了三维电极系统处理钻井废水时,废水浓度、电流密度、处理时间、电解质浓度和pH值对废水COD降解率的影响,实验结果表明,三维电极法处理钻井废水效果显著;增大电流密度、提高电解质浓度和延长处理时间能使COD去除率提高;最佳pH值为9。正交实验得到最优水平组合为A2B3C2D3E4,在此条件下COD去除率为86.56%。     

高浓度钻井废水的混凝-催化氧化处理

以华北油田某深井的高浓度钻井废水(COD高达14 460.0 mg/L)为研究对象,提出了酸化-混凝-催化氧化-吸附的组合处理工艺。重点研制了钻井废水催化氧化处理催化剂(镍基催化剂),通过实验确定了最佳工艺参数条件。着重考察了催化氧化处理的工艺条件,在pH值为4,次氯酸钙投加量为4.4 g/L,催化剂投加量为1.6 g/L的条件下COD降至403.5 mg/L,进一步吸附处理后COD降至139.9 mg/L、色度为30倍、石油类含量为3.8 mg/L、pH为8.0和SS浓度为52mg/L,最终出水水质达到《污水综合排放标准》(GB 8978-1996)二级标准,处理成本为84.8元/m3。     

O_3/Mn_2O_3对钻井废水多相催化臭氧化试验研究

通过静态试验,探讨了Mn2O3催化剂对钻井废水催化臭氧化处理效果.分别考察了催化剂加量、pH值、反应时间、反应温度和强化剂对钻井废水COD去除率的影响,通过正交试验得到了最佳工艺条件,对钻井废水氧化过程中的产物进行了分析,并探讨了Mn2O3催化剂的稳定性能.结果表明:Mn2O3加量从25 mg·L-1增加到50 mg·L-1时,COD去除率由43.6%增加到54.3%;pH分别为5、11时,COD去除率分别为45.4%和64.3%;反应温度为20℃时,COD去除率最高达到59.1%;随着反应时间的延长,COD去除率也随之增加,反应时间为40 min时,COD去除率达到85.3%;由正交试验得知影响因素的主次关系为催化剂加量反应pH反应温度反应时间,最佳处理工艺条件为催化剂加量50mg·L-1、pH值11,反应温度25℃、反应时间35 min;在25 min时,Ca2+的引入使COD去除率增大了7.1%;钻井废水中的有机物得到降解和矿化;Mn2O3催化剂重复使用10次后,对钻井废水COD降解率影响不大,锰离子的溶出量在反应15 min后稳定在3 mg·L-1,Mn2O3催化剂稳定性能较好.     

钻井废液的超临界水氧化处理及动力学分析

在反应温度为500～600℃、压力为25～30 MPa、停留时间为30～600 s的条件下,在连续式反应器中研究了钻井废液的超临界水氧化反应.结果表明:钻井废液的COD去除率可达90.00%以上;在600℃、停留时间为600 s时,钻井废液氧化后,剩余收集液的COD＜120 mg/L,满足《污水综合排放标准》(GB 8978-1996)中的二级标准.用幂函数方程描述了氧化剂过量时钻井废液超临界水氧化的反应动力学规律,反应速率常数与温度的关系符合Arrhenius公式,随停留时间的增加、温度的升高,有机物的去除率显著增加;反应速率常数随压力升高而增加,但反应速率常数的增幅随压力的升高而减小,反应活化体积不是常数.在25 MPa时,反应活化能和频率因子分别为(17 745.430 40±1 114.983 42)kJ/mol和1.152 3×10-4s-1模型计算值与实验值的误差在±15%以内.     

庙平9井大位移水平井钻井技术

庙平9井位于松辽盆地南部新庙油田庙22区块,区内大部分区域处于松花江内或江湾,由于环境因素的影响,直井无法实施,本区采用水平井整体开发。庙平9井水平井在钻井技术和安全管理方面精心组织,克服了水平井段（大斜度井段）长,井眼轨迹控制困难、井壁易垮塌、携砂困难、起下钻摩阻大、下油层套管困难、固井水泥环质量控制难、钻具事故几率大等困难,不仅避免和降低了井下事故的发生,且施工井满足开发要求,同时进行简化钻具结构和安全管理技术措施等方面取得了显著效果,为该区块水平井安全钻井工艺技术总结出几点结论及认识。