三步法处理大港油田12井综合废水的实验研究

根据大港油田12井综合废水的污染特征,提出了"混凝-内电解-H2O2氧化"三步处理的方法。实验结果表明:三步法处理后可以使原水的CODcr从4930mg/L降低到128mg/L,去除率达到97%。处理后水质达到国家《污水综合排放标准》(GB8978-1996)二级标准要求。     

三维电极电解硝基苯废水处理实验研究

以涂膜活性炭-活性炭为填充粒子,对三维电极电解硝基苯废水进行了研究。通过实验探讨了投盐量、槽电压、主电极间距、反应时间及初始浓度对电解硝基苯废水的影响。结果表明,三维电极在电极间距为9mm、槽电压为20V、硫酸钠投加量为1.5g/L、pH值为6、电解时间为90min的条件下,硝基苯去除率可达90%以上。在三维电极电解作用下,硝基苯转化为可生化和低毒的苯胺,苯胺在三维电极电解作用下还可以得到进一步的降解。     

阳离子染料废水处理的工艺研究

首先采用两级物化－电解－吸附工艺对高浓度阳离子染料生产废水进行预处理,再与低浓度生产废水、生活污水混合生化处理,总脱色率和CODcr去除率均可达到99．9％以上,达标排放。     

含硝基苯、苯胺废水处理的工程实践

采用固定化微生物-曝气生物滤池与铁-炭微电解法联用的工艺方法处理含硝基苯、苯胺的废水。通过培养驯化微生物阶段、半负荷进水阶段、满负荷进水阶段的调试运行,表明:当进水CODCr<1 000mg/L、硝基苯<120mg/L、苯胺<30mg/L时,出水可达到CODCr<300mg/L、硝基苯<5mg/L、苯胺<5mg/L的设计要求。铁-炭微电解法在pH值为3～4时,对废水有一定的脱色作用,但pH值升高后脱色效果不明显。     

Optimum conditions for the formation of Al13 polymer and active chlorine in electrolysis process with Ti/RuO2-TiO2 anodes

A polyaluminum containing a high concentration of Al₁₃ polymer and active chlorine (PACC) was successfully synthesized by a new electrochemical reactor using Ti/RuO₂-TiO₂ anodes. PACC can potentially be used as a dual-function chemical reagent for water treatment. The obtained results indicated that the formation of Al₁₃ polymer and active chlorine, were the most active components in PACC responsible for coagulation and disinfection respectively. These components were significantly influenced by electrolyte temperature, current density, and stirring rate. It was observed that high electrolyte temperature favored the formation of Al₁₃. Increasing current density and stirring rate resulted in high current efficiency of chlorine evolution, thus favoring the generation of Al₁₃ and active chlorine in PACC. When the PACC (Al_T = 0.5 mol/L, basicity = 2.3) was prepared at the optimum conditions by electrolysis process, the Al₁₃ polymer and active chlorine in product reached above 70% of Al_T and 4000 mg/L, respectively. In the pilot scale experiment with raw polyaluminum chloride used as an electrolyte, PACC was successfully prepared and produced a high content of Al₁₃ and active chlorine products. The pilot scale experiment demonstrated a potential industrial approach of PACC preparation.     

微生物反向电渗析反应器产过氧化氢的研究

微生物反向电渗析(Microbial reverse-electrodialysis electrolysis cell, MREC)是一种通过微生物产生的电能与浓淡水盐差能耦合形成的一种新型的生物电化学技术.本文对MREC阴极回收H_2O_2的运行条件与影响因素及同步产能效应进行了研究.结果表明,浓淡水流速及浓度比是影响H_2O_2产生的关键因素.在浓淡水流速为2 mL·min~(-1)、浓/淡水比为100时,MREC可以获得最大H_2O_2产量711.4 mg·L~(-1),产H_2O_2速率达到最大33.65 mg·L~(-1)·h~(-1),阴极回收率为19.77%.同时,对应的产电性能达到1.25 W·m~(-2).MREC反应器能够在无需施加外界能源的情况下获得较高的H_2O_2产量,为H_2O_2绿色生产提供了一条新思路.     

Ti/SnO_2-Sb阳极-空气阴极电催化降解染料废水

为解决电化学法处理高盐染料废水存在的能耗大、成本高等问题,分别采用溶胶-凝胶法和辊压法制备Ti/SnO_2-Sb阳极和空气阴极,构建了Ti/SnO_2-Sb阳极-空气阴极双极体系(TSSA-ADC)。甲基橙(MO)作为高盐染料废水的典型污染物,考察了电流强度、MO浓度、电解液浓度和初始p H对TSSA-ADC体系和TSSA单阳极体系降解MO的影响。结果表明:与TSSA单阳极体系相比,TSSA-ADC体系具有更好的抗有机负荷冲击、抗盐分冲击、抗酸碱波动能力,能够维护酸碱平衡防止硬度离子结垢。最佳反应条件为电流强度为0.030 A,电解液浓度为3%,MO浓度为100 mg/L,初始pH=6。以MO去除率达到98%为基准,TSSA-ADC体系比TSSA体系可节能74.26%。     

废旧印刷线路板电解过程中铜的分布特性

以废旧印刷线路板粉末为原材料,采用压片电解方法回收单质铜,研究了CuSO_4·5H2O浓度、H_2SO_4浓度、电流密度、电解时间和NaCl浓度对电解过程中Cu分布特性的影响。结果表明:废旧印刷线路板中的Cu以Cu2+的形式进入溶液,最终以粉末形式沉积在阴极;过高的H_2SO_4浓度、电流密度和NaCl浓度会导致析氢反应等,从而降低Cu在阴极和溶液中的分布;当CuSO_4·5H_2O浓度、H_2SO_4浓度、电流密度、电解时间、NaCl浓度分别为50 g/L、6 mol/L、80 m A/cm~2、5 h、40 g/L时,Cu在阴极、溶液、阳极泥中的分布比率分别为63.16%、34.14%和2.70%。     

铁炭内电解垂直流人工湿地对污水厂尾水深度脱氮效果

针对污水厂尾水总氮(TN)含量偏高、微生物可利用碳源低的问题,构建铁炭内电解垂直流人工湿地(ICIE-VFCW)装置,研究了ICIE-VFCW对尾水的处理效果,并采用紫外-可见光光谱(UV-VIS)、凝胶过滤色谱(GFC),进一步探讨了ICIEVFCW强化脱氮机制.结果表明,ICIE-VFCW可提高系统对尾水中COD的去除,出水COD可稳定在30 mg·L~(-1)以下,全年、暖季、寒季COD平均去除率较普通垂直流人工湿地分别可提高10.16%、9.81%、11.22%.系统出水TN可维持在10 mg·L~(-1)以下,全年、暖季、寒季TN平均去除率较普通垂直流人工湿地分别提高13.72%、12.90%、16.17%.经过人工湿地处理后,污水中有机物的腐殖度、芳香度及相对分子质量(Mr)均有所下降,且ICIE-VFCW中Mr下降更为明显.湿地基质掺杂铁炭可促进尾水中大分子有机物转化为小分子,为微生物提供更多可利用碳源,从而提高脱氮效率.     

Degradation of monofluorophenols in water irradiated with gaseous plasma

Decomposition of aqueous monofluorophenols (MFPs) was investigated by contact glow discharge electrolysis (CGDE). During CGDE, both MFPs and the corresponding total organic carbon (TOC) in water were consumed smoothly, suggesting that carbon atoms of benzene nucleus could be eventually mineralized to inorganic carbon (IC). And all the fluorine atoms in the MFPs were equally converted to fluoride ions. Based on the primary intermediates from each starting materials, it showed that aromatic hydroxylation preferentially occurred at the para- or ortho- position to the phenolic OH group of each MFPs. The disappearance of both MFPs and TOC followed the first-order rate law. The apparent rate constants for the decay of MFPs were independent from the pK_a values of MFPs.