微生物法烟气脱硫技术研究

采用微生物（氧化亚铁硫杆菌，简称TF菌）法脱除烟气中的二氧化硫。在相同操作条件下，比较了传统的工业化 方法稀硫酸吸收法（千代田法）与本法的优劣，研究了液气化、二氧化硫浓度、三价铁离子浓度等因素对吸收效率的影响；分析了脱硫反应前后吸收率pH值、三价铁离子浓度的变化。研究结果表明：适宜的液气比（12.5L/Nm^3 以上）、二氧化硫浓度（1000－5000ppm)和三价铁离子浓度（0.6g/L以上）能使该法具有较高（＞98％）的脱硫率。在常温常压操作条件下，微生物法的脱硫率远优于千代田法，具有一定的工业化价值。     

上海电厂FGD产物循环利用的可行性分析

按照上海市第三轮环保三年行动计划的要求,未来3年,上海电厂烟气脱硫规模已经确定,650.8×10~4kW 装机容量.35台燃煤机组在3年中,将先后安装湿法烟气脱硫装置,届时可减少约(16～20)×10~4t/a的 S0_2排放量,将产生约(54～72)×10~4t 的脱硫石膏。文章分析了上海市电厂烟气脱硫产物在生产石膏、水泥中循环利用的可行性,对上海市未来3年中脱硫产物的循环利用,进行了经济分析,按上海市目前 SO_2排污费0.63元/kg计,若煤含硫量以0.8%、1%计算,预计每年可节省 SO_2排污费用约1.02、1.28亿元:电厂脱硫石膏销售将获得约2160～2880万元/a;上海石膏板或水泥企业利用(54～72)×10~4t/a 的脱硫石膏,可使企业的原料购买成本节约3250～3650万元/a;提出了促进上海市电厂脱硫及其产物应用的建议。     

大口径薄壁无缝铝管变薄旋压工艺

介绍采用离心铸坯——变薄旋压方法制作大口径薄壁铝管的工艺.包括简要工艺流程、特点、适用范围等.该工艺为解决国内大口径薄壁无缝铝管提供了新的途径.     

电站锅炉内部检验要点及典型缺陷处理措施研究

电站锅炉运行压力大、工作温度高,锅炉本体系统多且复杂,锅炉内部检验对锅炉运行安全显得尤为重要。本文根据广州市近4年电站锅炉定期检验情况,以南沙区某运行小时数超10万的电站锅炉内部检验为依据,对电站锅炉内部检验中检验要点、检验方法以及典型缺陷进行阐述与总结,及时跟踪缺陷处理状况,消除电站锅炉潜在的安全隐患。     

Cadna/A噪声预测软件在火电厂工程环评中的应用

火电厂较一般的工业项目源强较多,以某35万千瓦超临界间接空冷火电厂为例,采用Cadna/A噪声预测软件预测了投产后产生的噪声影响,预测结果表明火电厂企业采取相应的降噪措施后,厂界噪声能够满足《工业企业厂界环境噪声排放标准》(GB12348-2008)中的3类标准要求,对环境敏感点昼夜噪声预测值能满足《声环境质量标准》(GB3096-2008)的2类标准要求,说明该项目的降噪设计可行。     

Attack vulnerability of self-organizing networks

There are several self-organizing networks in the real world, and these networks severely affect the development of the modern society. This paper investigates the vulnerability of self-organizing networks subject to malicious attacks according to a new framework. Assuming the initial load of node i as L_i=αk_i+(1-α)∑_j∈Γik_j with k_i and Γ_i being the degree and the set of neighbor nodes of the node i, where α is a tunable parameter and control the strength of the initial loads of nodes. The node with the maximum degree is considered as the attacked node, and with the changes of the parameter α, cascading failures will be investigated in this paper. Local redistribution rule has been adopted to study the cascading breakdowns of the US power grid and IEEE-118 networks. Additionally, the capacity of the node i is defined as C_i = (1 + β)L_i, the critical threshold β_c of the US power grid and IEEE-118 networks will be obtained from the evolutional process of cascading failures. Finally, an optimal design of US power grid network is given in this paper.     

电厂山区性河流取水工程安全设计分析

通过对代表性山区河流电厂的取水工程安全实例分析 ,根据取水方式不同 ,建议应采取的措施分为 :直接在天然河道上布置取水构筑物时 ,取水头部上下端加设三角形挡沙板 ,取水口上游设导沙丁坝 ,抬高取水头高程和进水底槛高程 ,并且可考虑设置两套取水系统 ,枯水期直接利用河道取水头取水 ,洪水期从移动式泵车取水 ;在河道上设置拦河低坝取水时 ,必须设置配套取水防沙设施 ,如排沙闸或冲沙闸 ,进水闸前设导沙坝 ,冲刷闸前设导沙坎 ,泄洪闸前设冲沙廊道和导流堤 ,还可在河道上设置潜水丁坝等。     

石化企业燃煤电厂二氧化硫控制对策研究

通过对国内外燃煤电厂二氧化硫控制现状、政策及技术的对比分析，提出了石化企业燃煤电厂二氧化硫控制的战略性对策。     

Relation between mechanochemical dechlorination rate of polyvinyl chloride and mill power consumption

A sample of polyvinyl chloride (PVC) powder was milled with CaO powder in a planetary mill for various mill operational parameters. The milled product consisted of dechlorinated hydrocarbon and water-soluble CaOHCl. The dechlorination rate of PVC was determined by the concentration of Cl⁻ ions measured in solution after dispersing the milled product in water. To evaluate the power consumption during PVC dechlorination, the mill power consumption was measured during each experimental run. In addition, media motion during planetary milling was simulated using the discrete element method (DEM), enabling calculation of the mill power consumption. The power consumption calculated by the DEM simulation compared well with the power consumption measured experimentally. The dechlorination rate correlated well with the specific mill power consumption, regardless of the sample weight. The dechlorination rate of PVC when milled with oyster shells (CaCO₃) was observed to be faster than that of the PVC/CaO system, and oyster shells could be used as a reactant for the treatment of PVC wastes. This work should be useful for the design of a reactor for the dechlorination of PVC. Chemical Feedstock Recycling & Other Innovative Recycling Techniques 6     

A GIS-based evaluation of the effect of decontamination on effective doses due to long-term external exposures in Fukushima

Despite the enormous cost of radiation decontamination, there has been almost no quantitative discussion on how much it would reduce the long-term external radiation exposure in the Evacuation Zone and Planned Evacuation Zone (restricted zone) in Fukushima. The aim of this study is to assess the effectiveness of decontamination and return options and to identify important parameters for estimating the long-term cumulated effective dose (CED) during 15, 30 and 70 year period using data on land-use, population and decontamination in the restricted zone (about 1100 km²) in Fukushima.