改性粉煤灰处理氨氮废水实验研究

采用H2SO4和HCl改性粉煤灰,在酸改性基础上用2mol/L NaOH进行改性。对比了原状粉煤灰,酸改性粉煤灰和酸加碱改性粉煤灰分别处理氨氮废水的效果。研究了pH值、粉煤灰投加量、反应时间对处理效果的影响。对于100mg/L氨氮废水最佳处理工艺：粉煤灰投加量2g,pH 11左右,搅拌时间60 min,静置1h,其氨氮去除率可达84%。     

有机改性膨润土对海水中石油的吸附效果及其影响因素研究

研究了有机改性膨润土对海水中柴油的吸附作用及其影响因素。结果表明,有机改性膨润土可以较好地吸附海水中的油,在温度为25℃、盐度33‰、振荡频率150r/min、pH为8的环境下,除油率可以达97%以上。该过程的吸附等温线符合Freundlich方程。     

Use of coupling agents to stabilize asphalt–rubber–gravel composite to improve its mechanical properties

The mechanical performance of rubber-modified asphalt roads depends, besides the intrinsic properties of the constituents (asphalt, rubber and gravel), on their interfaces. To improve the adhesion between constituents, two different coupling agents were required: one to link asphalt with the rubber particles to stabilize the composite creating an elastic network in the interior of the material to improve its elastic recovery, and other to increase the adhesion between the hydrophobic asphalt and the hydrophilic gravel. A phenolic resin was used to link the rubber particles with the asphalt, while a switterionic molecule (phosphatidyl-choline) was used to change the OH groups on the gravel surface by hydrocarbon chains to make it compatible with the asphalt.     

推流式SBR工艺可行性研究

根据我国中小型城市生活污水处理的需要,改进SBR部分结构,设计出推流式SBR装置,通过试验寻找推流式SBR运行条件,验证装置对有机物降解效率,同时亦验证装置对氮、磷的脱除效果。研究表明推流式SBR工艺由于特殊的运行方式,对NH3-N和TP的去除彻底,NH3-N去除率最高达到92%,TP的去除率最高达到98.76%,TN的去除率73%,COD去除率达90%。     

Engineering layout of fuel tanks in a tank farm

The present paper deals with the location of tanks in a tank farm, in chemical and allied industries. Ideally the tanks are so placed and installed that in case of fire, the neighbouring tanks could remain safe. The safe distance of separation among the tanks is calculated in no wind condition, as well as, in the presence of wind. The paper uses the methods available in literature and modifies the point source model to include the effect of wind vector on the flame height during the calculation of safe inter-tank distance. It is found that for wind velocity > 4 m/s, the modified point source model provides appropriate inter-tank distance. However, for no wind and with wind velocity < 4 m/s, the Shokri-Beyler’s method provides safe inter-tank distance.     

Se（IV）在改性水滑石和膨润土的吸附行为

79Se是高放废物地质处置安全评价中的重点关注的核素之一,如何有效地阻滞其在处置库环境中的迁移扩散是目前研究的热点。将金属盐溶液和有机溶剂与水滑石和膨润土混合制备,分别得到2种无机改性水滑石和9种不同的有机和无机改性膨润土,通过批次实验研究这些改性材料对Se(IV)的吸附性能。结果表明无机改性的水滑石和膨润土对Se(IV)均有较好的吸附,吸附率超过57%。而有机改性的膨润土吸附效果很差,吸附率低于10%。采用SEM和XRD对这些改性材料进行表征,结果表明：无机改性后的膨润土的比表面积和层间距均增大,有利于对Se(IV)的吸附。     

Experimental study of the influence of particle size on Minimum Explosible Concentration of sulfur dust

Despite the extensive use of sulfur in the industry, very little information is available in the literature on its key dust explosion properties. The work presented in this paper contributes to filling the current knowledge gaps on sulfur dust explosion properties and focuses on the experimental determination of the MEC of sulfur dust using a Modified Hartmann Tube and a 20 L dust explosion sphere. First, the MEC of sulfur dust samples collected at a sulfur production facility from areas prone to the generation of fine sulfur dust was measured. The results showed that these sulfur dust samples are fine enough to cause dust explosions with 55 ± 5< MEC <105 ± 5 g/m³. Second, the influence of the particle size of sulfur dust was investigated with both equipment. The use of the Modified Hartmann Tube for MEC determination showed that the MEC increases with increasing particle size in the particle size range of 0–2000 μm. Unlike the Modified Hartmann Tube, MEC experiments done in the 20 L Sphere did not allow the quantification of the influence of the particle size on the MEC. These results were explained by the phenomenon of particle breakage induced by the 20 L Sphere's dispersion mechanism. Additional experiments with the 20 L sphere confirmed the particle breakage of sulfur dust particles and showed that it is inversely proportional to dust concentration and proportional to the dust's original particle size distribution.