臭氧氧化—钙法吸收工艺对烟气的同步脱硫脱硝

针对中国石化镇海炼化乙烯动力锅炉烟气的特点,进行烟气模拟,采用臭氧氧化—钙法吸收同时脱硫脱硝工艺处理模拟烟气。实验对比了单独脱硫和脱硝过程与同时脱硫脱硝工艺的脱硫、脱硝效果,探究了烟气在反应器中的停留时间、臭氧投加量和烟气含氧量对SO₂去除率和NO_x去除率的影响。实验结果表明：SO₂和NO的共存可促进污染物的去除;烟气停留时间延长,SO₂去除率提高,NO_x去除率先升高后降低;臭氧与NO摩尔比增加,NO_x去除率提高,SO₂去除率略有降低。综合考虑选择烟气停留时间3.4 s,烟气含氧量12%（φ）,臭氧与NO摩尔比0.7,在此工艺条件下反应70 min,NO_x去除率为73.8%,SO₂去除率为74.1%。     

次氯酸钙溶液的脱硫脱硝特性

采用Ca(ClO)2溶液在高效反应瓶中与模拟烟气进行脱硫脱硝实验,考察了模拟烟气中SO2和NOx的去除效果,以动力学为理论基础研究了Ca(ClO)2的脱硫脱硝性能。实验结果表明:在模拟烟气中SO2,NO,NO2的质量浓度分别为3700,1300,820 mg/m^3及Ca(ClO)2溶液浓度为0.35 mol/L的条件下,SO2去除率达到100%,NOx去除率达到67%。脱硫过程中吸收液中的ClO-是100%脱硫率的保障。Ca^2+吸收SO2的反应速率呈现一级反应的特征。得到的脱硫产物CaSO4·2H2O达到了工业石膏的品质要求。同时脱硫脱硝时NOx和SO2具有协同作用。     

晶种及晶型助长剂对磷石膏制备硫酸钙晶须的影响

实验以磷石膏为原料,硫酸钙为晶种,镁盐为晶型助长剂,采用水热法制备硫酸钙晶须。实验详细考察了晶种的用量,镁盐晶型助长剂种类及用量,晶种、晶型助长剂、结晶稳定剂三者的协同效应等对硫酸钙晶须形态的影响。用偏光显微镜和扫描电镜(SEM)及X射线衍射分析了硫酸钙晶须的形貌和相组成。结果表明在硫酸镁作为晶型助长剂,晶种∶晶型助长剂∶结晶稳定剂的用量为1∶3∶4时制备出的硫酸钙晶须产品优,其光滑,反应完全,长度最长可达150μm左右,直径细度可细达0.5μm。     

利用白云石回收污泥厌氧消化液中的磷

为经济有效地从污泥厌氧消化液中回收磷,构建了以白云石提供钙镁源的磷回收方法,探讨了磷回收的工艺条件与效果。通过盐酸酸化厌氧消化液以降低其碳酸盐含量,同时利用白云石溶于冷稀盐酸的特性使其钙镁缓慢释放到酸化的厌氧消化液中形成第一步磷回收体系,考察体系酸化pH、白云石与厌氧消化液的固液比以及反应pH对白云石的钙镁释放和磷回收效果的影响;第一步磷回收后的上清液为第二步厌氧消化液磷回收提供钙镁源,研究投加钙磷摩尔比对磷回收效果的影响。实验结果表明,当固液比为5.0时,在酸化pH为4.0～4.5且酸化溶出时间为10 h以及反应pH为9.0的条件下,第一步磷回收产物以磷酸钙盐沉淀为主,厌氧消化液磷回收率及回收产物含磷率（以P2O5计）分别达到99.43%和38.49%;第一步磷回收后的上清液按一定的钙磷摩尔比投加到酸化后的厌氧消化液中进行第二步磷回收,当投加钙磷摩尔比为0.20时,在反应pH为9.0的条件下,回收产物同时含有磷酸钙盐和磷酸铵镁,厌氧消化液中氮、磷回收率分别达到13.19%和90.90%,回收产物氮、磷含量（以P2O5计）分别为0.26%和39.58%;经XRD、XRF、ICP及SEM等分析表征,2步磷回收的产物以磷酸钙盐和磷酸铵镁为主要成分,杂质少。研究表明,利用白云石为钙镁源,通过分别构建不同的磷回收体系可以分步从污泥厌氧消化液中经济有效地回收磷,且磷回收率和回收产物含磷率高。     

Sources and Sinks of Phosphorus for a Perturbed Stream and the Effects of Mineral Deposits1

Effler, Steven W., Anthony R. Prestigiacomo, David A. Matthews, and Feng Peng, 2012. Sources and Sinks of Phosphorus for a Perturbed Stream and the Effects of Mineral Deposits. Journal of the American Water Resources Association (JAWRA) 48(2): 321‐335. DOI: 10.1111/j.1752‐1688.2011.00617.x Abstract: Patterns of concentrations and loading rates of multiple forms of phosphorus (P) are resolved and analyzed along Ninemile Creek, New York, a stream perturbed by a domestic waste discharge and residual effects of a closed industry. This analysis is based on biweekly monitoring of total, dissolved, and soluble reactive P (SRP) for 19 months at four sites that bracket each of these effects, and 15 years of biweekly measurements at the two sites that bound industrial deposits. The minerogenic particle populations of the stream and the surficial sediments along the reach with extensive CaCO₃ and clay mineral deposits are characterized with an individual particle analysis technique. Mass balance analyses depict: (1) increasing nonpoint inputs of particulate and dissolved organic P along the stream length; (2) input of P from a domestic waste facility, almost entirely in the form of SRP; and (3) a compensating downstream loss of SRP over the reach with the extensive industrial deposits of CaCO₃. The downstream sink process for SRP is attributed to sorption processes with minerogenic deposits. The domestic waste‐based source and the compensating industrial waste‐based sink are noteworthy fluxes relative to other prevailing loads received by downstream Onondaga Lake, for which a major rehabilitation program targeting cultural eutrophication is underway. The P source/sink conditions of this stream are considered in the context of this rehabilitation program.     

Spatial Variability of Pool-Tail Fines in Mountain Gravel-Bed Stream Affects Grid-Count Results1

Bunte, Kristin, John P. Potyondy, Kurt W. Swingle, and Steven R. Abt, 2012. Spatial Variability of Pool-Tail Fines in Mountain Gravel-Bed Stream Affects Grid-Count Results. Journal of the American Water Resources Association (JAWRA) 48(3): 530-545. DOI: 10.1111/j.1752-1688.2011.00629.x Abstract: Fine sediment (<2 and <6 mm) particles underlying a 49-intersection grid placed on a streambed at 25, 50, and 75% of the wetted pool-tail width are commonly counted to assess the status and trend of aquatic ecosystems or to monitor changes in the supply of fines in mountain gravel-bed streams. However, results vary even when crews perform nearly identical procedures. This study hypothesized that spatial variability of pool-tail fines affects grid-count results and that a sampling scheme can be optimized for precision and accuracy. Grid counts taken at seven evenly spaced locations across the wetted width of 10 pool tails in a pool-riffle study stream indicated a bankward fining trend with secondary peaks of fines within the stream center. Sampling locations close to the waterlines harbored more than twice as many fines as central locations. Most of the five grid-count schemes derived from the seven sampled locations produced significantly different results. Compared with sampling at all seven locations, schemes that focus near waterlines overpredicted fines, while those that focus on the center underpredicted them. Variability of fines among pool tails was the highest within a broad band along the waterlines; hence, focusing sampling there yielded the most variable results. The scheme sampling at 25, 50, and 75% of the wetted width had the lowest precision and moderate accuracy. Accuracy and precision of grid-count results can be greatly improved by sampling at seven even-spaced locations across the pool tail.     

混凝吸附及化学氧化深度处理焦化废水

以蒙脱石、凹凸棒石、次氯酸钙和PAC、PAM为基本材料,对焦化废水二级生化出水进行深度处理。实验结果表明：蒙脱石与凹凸棒石以4：1的比例配合使用,可明显提高焦化废水中COD和色度去除率;采用次氯酸钙作为氧化剂,可进一步提高焦化废水的脱色率和COD去除率,处理间差异达到极显著和显著水平;去除COD的最优实验条件为：粘土矿物（蒙脱石：和凹凸棒石=4：1）添加量4．0g／L、氧化剂（次氯酸钙）添加量1．0g／L、絮凝剂（聚合氯化铝：聚丙烯酰胺=15／1）添加量0．15g／L,处理后色度去除率达到97．0％,COD去除率达到69．1％;脱色的最优实验条件为：粘土矿物添加量4．0g／L、氧化剂添加量1．0g／L、絮凝剂添加量0．2g／L,处理后色度去除率达到98．5％,COD去除率达到66．4％。     

过量生石灰对污泥含水率和有机物含量的影响

为了研究生石灰(氧化钙,CaO)处理活性污泥对污泥含水率和有机物含量的影响,通过向南京某城市污水处理厂出厂污泥投加过量CaO进行脱水实验,测定投加CaO后污泥的含水率;烘干后的脱水污泥进行热重实验,研究CaO投加量对污泥中有机组分含量的影响.脱水实验表明:随着CaO与污泥质量比的增大,污泥含水率迅速减小,当质量比达到1.5时,污泥达到完全脱水;投加过量CaO的脱水污泥呈干燥的粉末状,粒度均匀,可作为水泥生产的辅料。热重实验表明:投加CaO后单位干泥失重百分比随CaO与污泥质量比增大而逐渐减小,向污泥中投加CaO有利于污泥中有机组分的释放和去除,实现污泥的稳定化。     

水合改性对钙基吸收剂循环捕集CO2的影响

在钙基吸收剂捕集CO2的过程中,吸收剂转化率会随着循环次数的增加而迅速降低。钙基吸收剂的水合改性作为改善吸收剂循环转化率的主要方法之一受到了国内外学者的广泛关注。总结了目前国内外研究者对不同的吸收剂、循环捕集条件下的水合改性方法的研究成果。结果表明,在循环过程中的不同阶段对吸收剂进行水合处理后得到的效果不同。其中,在碳酸化阶段、煅烧阶段、循环捕集前预处理以及煅烧后对吸收剂水合改性．吸收剂捕集CO2的能力均得到了改善;碳酸化反应后对吸收剂进行水合处理是否对循环吸收有利还存在争议。目前,利用水合改性的方法提高钙基吸收剂循环捕集CO2能力的机理还存在争议,且水合改性后的吸收剂机械性能差以及此方法能耗高的问题尚待解决。     

Assessment of nematode community structure as a bioindicator in river monitoring

Nematode communities from river water and sediments were assessed for the abundance, feeding types, maturity indices and nematode channel ratio (NCR). The sampling sites studied included different levels of pollution and contamination from agricultural, industrial and sewage sources. The nematode abundance found in the sediment samples was more than that in the water samples. The lowest nematode abundance in sediment samples and the lowest NCR in water samples were both found at the industrial pollution site. Water samples showed positive correlation between the NCR and river pollution index (RPI). Mean maturity indices in sediment samples were inversely correlated with RPI. The pollutant source determined the relationship between NCR and pollution level, while maturity index always showed negative correlation with pollutant level regardless of the pollutant sources. The nematode abundance and its community structure were both reliable bioindicators for monitoring long-term river pollution in both qualitative and quantitative aspects.