晶种法回收和去除高浓度含氟废水中的氟

以氟化盐厂3 100 mg/L含氟废水为处理对象,提出了以氢氧化钙清液为沉淀剂,添加晶种回收废水中氟化物的新工艺。结果表明,采用氟化钙回收装置对废水进行处理,当Ca/F=1.2∶2、反应终点pH=6.1～6.6时,出水氟离子质量浓度低于20 mg/L,达到国家二级排放标准,氟化钙污泥呈砂状,含水率低,易于回用,氟回收率高于99.5%,可以有效降低氟污染和资源浪费。     

运用相图理论回收缩合废水中的氯化钠和氯化铵

研究了0℃,10℃,60℃时NaCl－NH4 Cl－H2 O三元水盐体系的固液相平衡关系,测出了NaCl和NH4 Cl在水中的溶解度数据,并绘制了相图。运用该三元相图理论,采用结晶法从缩合工段母液废水中回收NaCl和NH4 Cl。讨论了回收过程原理,介绍了回收工艺的操作步骤和工艺参数。回收的NaCl纯度达到95％,总回收率大于77％,NH4 Cl纯度达到92％以上,总回收率大于40％,产品分别达到HG／T 5462—2003,GB／T 2946—2008的标准。     

油田采出液乳化程度的影响因素试验研究

通过模拟油田采出液,考察了油水比、聚合物、表面活性剂及天然固体颗粒物对油田采出液乳化程度的影响。试验表明:随着油水比下降,模拟水样含油量降低,油珠Zeta电位升高,平均粒径变大,水样乳化稳定性减弱;HPAM会吸附于油珠表面从而增强其负电性,降低油珠间的有效碰撞,使油珠的平均粒径较小,导致油水分离较困难;表面活性剂会直接降低水样的表面张力,增强油水亲和性,导致水样含油量增大,同时增强了油珠的负电性,不利于油珠的集结聚并;天然固体颗粒物本身有一定的电负性,降低了油珠的Zeta电位,增加油珠的静电排斥,妨碍油珠的聚并,同时使水样的含油量升高,最终导致乳状液稳定。     

厌氧膜生物反应器耦联部分亚硝化/厌氧氨氧化用于污水处理研究

本研究构建了厌氧膜生物反应器（AnMBR）-部分亚硝化/厌氧氨氧化（PN/Anammox）污水处理工艺,以探究AnMBR-PN/A工艺处理效果最佳的水力停留时间（HRT）.AnMBR将厌氧生物处理与膜分离技术相结合实现有机物去除,AnMBR出水NH₄⁺-N通过PN部分转化为NO₂^--N,最终通过NO₂^--N氧化剩余NH₄⁺-N去除.实验结果表明：在HRT=11.2 h时,AnMBR-PN/A工艺化学需氧量（COD）去除率稳定在97%以上,COD转化为CH₄效率超过77.5%,总氮（TN）去除率为78%,出水COD和TN浓度分别低于14和11 mg·L^-1.AnMBR段COD去除率达到95%,平均甲烷产率为0.39 L·L^-1·d^-1.PN段实现了NO₂^--N的高效积累,其出水中NO₂^-/NH₄⁺为0.91±0.11.Anammox段出水中的NO₂^--N、NH₄⁺-N和NO₃^--N浓度分别低于1.0、4.9和5.1 mg·L^-1.高通量测序结果表明PN段氨氧化菌主要为Nitrosomonas,丰度为7.09%,Anammox段主要微生物为Candidatus Brocadia,丰度高达21.01%.本研究构建的AnMBR-PN/A工艺实现了污水处理过程的高效能源回收和深度自养脱氮,研究成果为工程应用提供了理论支撑.     

“NEW” resource recovery from wastewater using bioelectrochemical systems: Moving forward with functions

Bioelectrochemical systems (BES) have been extensively studied for resource recovery from wastewater. By taking advantage of interactions between microorganisms and electrodes, BES can accomplish wastewater treatment while simultaneously recovering various resources including nutrients, energy and water (“NEW”). Despite much progress in laboratory studies, BES have not been advanced to practical applications. This paper aims to provide some subjective opinions and a concise discussion of several key challenges in BES-based resource recovery and help identify the potential application niches that may guide further technological development. In addition to further increasing recovery efficiency, it is also important to have more focus on the applications of the recovered resources such as how to use the harvested electricity and gaseous energy and how to separate the recovered nutrients in an energy-efficient way. A change in mindset for energy performance of BES is necessary to understand overall energy production and consumption. Scaling up BES can go through laboratory scale, transitional scale, and then pilot scale. Using functions as driving forces for BES research and development will better guide the investment of efforts.

Open image in new window

     

End-of-life batteries management and material flow analysis in South Korea

Analysis of collection and recycling system of end-of-life batteries was examined. Relatively limited fractions of portable batteries were collected by EPR system. More effective and diverse collection pathways should be developed. Consumers increasingly have worn-out batteries as electrical and electronic equipment with new technical developments are introduced into the market and quickly replace older models. As a result, large amounts of end-of-life (EOL) or waste batteries are generated. Such batteries may contain a variety of materials that includes valuable resources as well as toxic elements. Thus, the proper recycling and management of batteries is very important from the perspective of resource conservation and environmental effect. The collection and recycling of EOL batteries is relatively low in South Korea compared to other countries, although an extended producer responsibility (EPR) policy was adopted for battery recycling in 2003. In this study, the management and material flow of EOL batteries is presented to determine potential problems and quantitative flow, based on literature review, site visits to battery recycling facilities, and interviews with experts in the Korea Battery Recycling Association (KBRA), manufacturers, and regulators in government. The results show that approximately 558 tons of manganese-alkaline batteries, the largest fraction among recycling target items, was disposed in landfills or incinerators in 2015, while approximately 2,000 tons of batteries were recovered at a recycling facility by simple sorting and crushing processes. By raising environmental awareness, more diverse and effective collection systems could be established for consumers to easily dispose of EOL batteries in many places. Producers, retailers and distributors in South Korea should also play an important role in the collection of EOL batteries from consumers. Lithium-ion batteries from many electronic devices must be included in the EPR system for resource recovery.     

Ammonia removal from low-strength municipal wastewater by powdered resin combined with simultaneous recovery as struvite

• Powdered resin was employed for ammonia recovery from municipal wastewater. • Powdered resin achievedefficient ammonia removal under various working conditions. • Co-existing cations indicated competitive adsorption of ammonia. • Ammonia was recoveredby two-stage crystallization coupled with ion exchange. Low-strength municipal wastewater is considered to be a recoverable nutrient resource with economic and environmental benefits. Thus, various technologies for nutrient removal and recovery have been developed. In this paper, powdered ion exchange resin was employed for ammonia removal and recovery from imitated low-strength municipal wastewater. The effects of various working conditions (powdered resin dosage, initial concentration, and pH value) were studied in batch experiments to investigate the feasibility of the approach and to achieve performance optimization. The maximum adsorption capacity determined by the Langmuir model was 44.39 mg/g, which is comparable to traditional ion exchange resin. Further, the effects of co-existing cations (Ca²⁺, Mg²⁺, K⁺) were studied. Based on the above experiments, recovery of ammonia as struvite was successfully achieved by a proposed two-stage crystallization process coupled with a powdered resin ion exchange process. Scanning electron microscopy (SEM) and X-ray diffractometry (XRD) results revealed that struvite crystals were successfully gained in alkaline conditions (pH= 10). This research demonstrates that a powdered resin and two-stage crystallization process provide an innovative and promising means for highly efficient and easy recovery from low-strength municipal wastewater.     

铜镍电镀退镀废液资源化处理工艺

针对硝酸型铜镍退镀废液,确定了蒸馏法回收硝酸、溶剂萃取法分离提取铜、沉淀分离法回收镍的工艺路线.探讨了采用P507煤油体系萃取分离硝酸介质中的铜和镍及用硫酸反萃铜的条件及影响规律,确定了最佳工艺参数.结果表明,硝酸回收率可达97.8%;当最佳萃取工艺条件为:料液浓度Cu 15～20mg/mL,Ni 5～10 mg/mL,料液pH为1～2,萃取剂体积分数35%,皂化度60%,相比为1∶1,振荡时间2min,温度20℃～25℃,铜的一级萃取率达90%以上,铜镍分离系数为75,经过三级逆流萃取废液中的铜镍已达到完全分离;以NaOH作沉淀剂,溶液的pH为10～11,镍的回收率可达99.9%.经上述处理后,使排放液达到国家工业废水排放标准要求.     

There's nowhere to go: counting the costs of extreme weather to the homeless community

People experiencing homelessness are vulnerable to extreme weather in unique ways. The entrenched inequalities that underpin disaster vulnerability are compounded by extreme isolation and the stress of transient living on mental and physical health. However, the impacts of extreme weather on the homeless in Australia are largely undocumented and rarely incorporated in emergency planning. Interviews with and surveys of emergency and homeless services and service users revealed that the primary ramifications of losing shelter and worsening mental health deepen the cycle of homelessness and trauma. Consequently, homeless shelter losses, such as tents, should be included in pre‐ and post‐event impact statistics and subsequent recovery support. Extreme weather response plans should include early triggers and strategies for ‘non‐severe’ weather events, as the homeless community is affected earlier and by a wider range of meteorological conditions. Moreover, this study also explores the benefits of a trauma‐informed response to extreme weather when working with the homeless.     

Complexity,continuity and change: livelihood resilience in the Darfur region of Sudan

Darfur farming and pastoralist livelihoods are both adaptations to the environmental variability that characterises the region. This article describes this adaptation and the longer‐term transformation of these specialised livelihoods from the perspective of local communities. Over several decades farmers and herders have experienced a continuous stream of climate, conflict and other shocks, which, combined with wider processes of change, have transformed livelihoods and undermined livelihood institutions. Their well‐rehearsed specialist strategies are now combined with new strategies to cope. These responses help people get by in the short term but risk antagonising not only their specialist strategies but also those of others. A combination of factors has undermined the former integration between farming and pastoralism and their livelihood institutions. Efforts to build resilience in similar contexts must take a long‐term view of livelihood adaptation as a specialisation, and consider the implications of new strategies for the continuity and integration of livelihood specialisations.