应用ANFIS预测蠕虫反应器的污泥减量速率并优化其运行条件

利用水生蠕虫的捕食作用可以有效地实现污泥减量.为了研究环境条件波动对蠕虫捕食污泥减量效率的影响,应用自适应神经模糊推理系统(ANFIS)和人工神经网络(ANN)模型分别预测蠕虫反应器的污泥减量速率.结果表明,溶解氧浓度(D0)、温度(T)、蠕虫密度和污泥负荷是蠕虫捕食过程的主要影响因素,通过性能比较得出ANFIS模型预测值与实验测定值间具有更好的一致性,其相关系数(r)为0.82,绝对平均误差百分比(MAPE)为71.5％,均方根误差(RMSE)为16.7.根据ANFIS模型的预测结果,得出蠕虫反应器的最适运行条件为:DO 1.8 ～3.1mg·L-1,温度18.4～21.7℃,蠕虫密度低于1.7 g·cm-2(以湿重计),污泥负荷563～734 mg·g-1(以TSS计),在此操作条件下获得的污泥减量速率均高于100 mg· g-1·d-1.     

混酸酸雾及氮氧化物净化系统应用实例

酸雾及氮氧化物是冶金行业中混酸酸洗机组的主要污染物.根据国家法规,对此类污染物必须进行净化处理后才能排放.以某工程实践为依托,详细介绍了全部采用自主技术、国内设计、国产设备的混酸及氮氧化物净化系统.该系统节能、高效、运行方便、安全性好,具有广阔的市场前景.     

生活污水与人工配水对好氧颗粒污泥系统的影响

在R1、R2两组序批式活性污泥反应器（SBR）中接种污水处理厂回流污泥,分别以人工配水和实际生活污水为进水,研究常温下（20~30℃）进水水质对好氧颗粒污泥工艺的启动以及温度变化对系统稳定运行的影响.结果表明,R1、R2分别历时25 d、42 d启动成功,颗粒污泥稳定后,其平均粒径分别达到1200 μm、750 μm,R1、R2内出水COD、TP、TN的平均浓度分别为22.53、0.48、7.70 mg·L^-1和49.73、0.49、14.55 mg·L^-1,去除率分别为90.60%、90.34%、87.85%和79.74%、88.59%、79.25%.当温度降低至5~16℃时,R1内颗粒污泥出现解体现象,COD及TP去除能力基本不变,出水TN平均浓度升高为29.03 mg·L^-1,平均去除率降低至48.81%,脱氮性能受到抑制;R2内颗粒污泥运行稳定,出水COD、TP和TN平均浓度分别为14.31、0.50和12.24 mg·L^-1,平均去除率分别为92.42%、93.37%、86.28%,出水满足《城镇污水处理厂污染物排放标准》一级A标准.采用人工配水和生活污水均能成功培养出好氧颗粒污泥,生活污水培养成熟的好氧颗粒污泥结构更密实,当温度降低至5~16℃时,能够有效抑制丝状菌的膨胀,抗冲击负荷能力强.     

ABR除碳-CANON耦合工艺除碳脱氮特性

CANON工艺如能处理低氨氮城市生活污水,将大幅度降低市政污水处理能耗.故以纤维载体为填料,在CSTR反应器中同时接种亚硝化污泥和厌氧氨氧化污泥启动CANON反应器,且在CANON系统前端添加ABR除碳系统,构建ABR除碳-CANON耦合工艺,研究ABR除碳-CANON耦合工艺除碳脱氮性能,并采用MiSeq高通量测序技术分析污泥中微生物菌群结构的变化情况.结果表明,通过同时接种亚硝化污泥和厌氧氨氧化污泥,控制DO为0. 5～2 mg·L-1、HRT为6h、p H值为8左右等措施,在55 d内成功启动CANON系统,TN去除率为81%～87%,氨氮负荷为0. 195 kg·(m3·d)-1. ABR除碳系统出水有机物浓度(120 mg·L-1)不会对后续CANON系统产生不利影响,一体式ABR除碳-CANON工艺TN去除率在74%～87%,出水COD平均浓度为40 mg·L-1.同时,CANON系统启动后变形菌门(Proteobacteria)得到了显著提升,鞘脂杆菌纲(Sphingobacteria)所占比例下降为6. 8%,CANON系统中亚硝化菌和厌氧氨氧化菌不断淘汰劣势菌群成为反应器内优势菌群,一体化ABR除碳-CANON工艺对城市污水具有良好的脱氮除碳效果.     

Human factors applied to alarm panel modernization of nuclear control room

Human factors deal with issues related to humans, their behavior and the physical aspect of the environment in which they work. A control room is a complex system where operators perform plant operation using control systems and carry out monitoring and administrative responsibilities. For safe operation of industrial installation, the performance of the control room crew plays an important role. In this respect, a well designed control room is crucial for safe and efficient operation. The aim of this paper is to propose a methodological framework applied to nuclear control room evaluation, through participatory ergonomics, using operator activity analysis and human factors questionnaire as aid tools. We describe a case study in which the methodology framework was used in the evaluation process of a nuclear control room. The information gathered made possible a series of recommendation for the adequacy of the control room design, assisting in the safety assessment of the nuclear plant operation and justifying the alarm panel modernization.     

苯酐生产氧化反应器组火灾爆炸危险性分析与对策

为预防苯酐生产中最危险部位氧化反应器组发生火灾、爆炸事故 ,详细分析了苯酐生产中氧化反应器组各部位的火灾、爆炸危险性 ,在危险性分析基础上 ,提出了可行的安全对策与措施 ,对苯酐装置的安全生产和管理具有重要的指导意义和参考价值     

应用CAMEO软件包预测聚合反应器丙烯泄漏影响范围

为了能够准确地预测聚合反应器发生泄漏时丙烯的扩散分布,提高应急救援工作效率,应用CAMEO软件包进行预测,通过该软件包中ALOHA、MARPLOT软件连用,解决了量化和图形显示问题。     

高磷赤铁矿选矿酸性废水处理的试验研究

文章采用自主开发的原位生成型动态膜反应器对高磷赤铁矿选矿酸性废水处理进行了实验研究。实验研究结果表明:选矿酸性废水除磷效果与脱磷剂的投加量、速度梯度(G值)、反应时间及pH等因素有关。对于pH2.25~2.56、含磷50mg/L的模拟选矿废水,最佳反应时间1h,速度梯度(G值)63.6,脱磷剂最佳投加量为11.25g/L,废水脱磷率92.47%。选矿酸性废水处理后出水pH升高,不利于实现废酸全部回用。     

Effcient degradation of lube oil by a mixed bacterial consortium

A laboratory study was performed to assess the biodegradation of lube oil in bio-reactor with 304# stainless steel as a biofilm carrier. Among 164 oil degrading bacterial cultures isolated from oil contaminated soil samples, Commaonas acidovorans Px1, Bacillus sp. Px2, Pseudomonas sp. Px3 were selected to prepare a mixed consortium for the study based on the e ciency of lube oil utilization. The percentage of oil degraded by the mixed bacterial consortium decreased slightly from 99% to 97.2% as the concentration of lube oil was increased from 2000 to 10,000 mg/L. The degradation of TDOC (total dissolved organic carbon) showed a similar tendency compared with lube oil removal, which indicated that the intermediates in degradation process hardly accumulated. Selected mixed bacterial consortium showed their edge compared to activated sludge. Scanning electron microscopy (SEM) photos showed that biofilms on stainless steel were robust and with a dimensional framework constructed by EPS (extracellular polymeric substances), which could promote the biodegradation of hydrocarbons. The increase of biofilm followed first-order kinetics with rate of 0.216 g glucose/(cm2 day) in logarithm phase. With analysis of Fourier transform infrared spectroscopy (FT-IR) and gas chromatography-mass spectrometry (GC-MS) combined with removal of lube oil and TDOC, mixed bacterial consortium could degrade benzene and its derivatives, aromatic ring organic matters with a percentage over 97%.     

以MnOx/TiO2作为催化剂的低温SCR反应过程中还原剂NH3的作用

研究了在以MnOx/TiO2作为催化剂的低温SCR反应过程中,还原剂NH3所起的作用.当系统中NH3浓度较低时,增加气相中NH3的浓度可以大幅度提高NO的去除率.但当系统中NH3浓度较高时,NO去除率基本不随NH3浓度变化而变化.并且瞬态研究中,NH3对NO去除率的影响较为复杂.为了探明NH3在SCR反应中的作用,用原位傅立叶红外检测了各个反应历程中NH3在催化剂表面形成的基团变化及其活性特征.结果表明,在SCR反应过程中,在催化剂表面形成的配位态的NH3是参与反应的主要物质.并且在催化剂表面,此种NH3会与NO生成的硝酸盐形成竞争吸附,当催化剂活性点首先被硝酸盐占领时,将会影响配位态NH3的生成,从而在一定程度上降低了NO的转化率.