过滤-洗涤复合法净化饮食业油烟的试验研究

针对饮食业油烟捕集和清除的特点,开展了过滤-洗涤复合法净化油烟的试验研究。通过模拟试验给出了过滤风速、滤料厚度、喷液量和洗涤液浓度的合理范围,对过滤-洗涤式净化设备的研制与设计具有指导意义。     

干木薯酒精废醪固液分离初探

测定了干木薯酒精废醪在多种条件下的过滤比阻,结果表明,在过滤温度不低于60℃时,用饱和石灰乳(石灰2g/L)复配两性聚丙烯酰胺(APAM5mg/L)或单独用APAM(15mg/L)作为脱水助滤剂,废醪调质后过滤比阻降至4×1011m/kg以下,适合于真空过滤固液分离。调质药剂费0.6元/t。      

污水深度处理技术研究

通过对污水处理装置外排污水进行深度处理中试研究 ,在净化处理中采用沉淀、过滤 ,同时投加混凝剂、助凝剂 ,并采用二氧化氯消毒 ,处理后的污水达到了所定指标要求 ,可作为工业用水     

超稠油废水处理的实验研究

针对超稠油废水污染的问题 ,确定采用混凝沉降、砂滤、活性炭吸附处理超稠油废水 ,处理后的水达到国家排放标准。此方法工艺比较简单 ,处理效果好     

单丝滤布优选及悬浮物特性对其过滤性能的影响

根据国标测定单丝滤布的孔径、过水通量及透水阻力,从而优选出过滤性能最优的滤布。探究了悬浮物粒径、浓度及比表面积对单丝滤布过水通量的影响,并采用HERMIA模型分析了单丝滤布的堵塞机理。实验结果表明:悬浮物粒径越大单丝滤布过水通量的下降越明显,过滤后悬浮物中位粒径与滤布孔径的比值均在0.36～0.46;悬浮物的浓度越高、比表面积越小,在滤布表面的架桥作用越强,形成的滤饼层孔隙越小,滤布越容易被污染。     

The coupling of sand with ZVI/oxidants achieved proportional and highly efficient removal of arsenic

• Simply doping sands with ZVI achieved an even activation of ZVI by oxidants. • Sand doping facilitated proportional As trapping along the ZVI/oxidants column. • ZVI/sand/oxidants are highly efficient for arsenic removal. • ZVI/sand/oxidants reduced significantly the Fe²⁺ leaching and effluent turbidity. • More than 54% of arsenic was reduced to As(III) in ZVI/sand/oxidants system. The coupling of zero-valent iron (ZVI) with common oxidants has recently achieved very rapid and highly efficient removal of Heavy metals from wastewater. However, the uniform activation of ZVI throughout the column and the proportional removal of target contaminants are urgently required for the prevention of premature filter clogging and the extension of the effective column operational time. In this study, we successfully achieved this objective by simply doping granular sand with ZVI at appropriate weight ratios. When pure ZVI packed column was spiked with oxidants, the majority of As trapping occurred between the column inlet and the first sampling point. In a packed column with a 1:20 mixture of ZVI and sand, the average As removal efficiency was 36 (1st), 13.1 (2nd), 18.5 (3rd), 19.2 (4th) and 5.9% (5th outlet). The overall arsenic removal performance of the composite filling system of ZVI/sand was equally as efficient as that of the previous pure ZVI-packed system. Moreover, the leaching of Fe was significantly reduced with an increased sand ratio, resulting in clearer water with less turbidity. The results of X-ray photoelectron spectroscopy (XPS) demonstrated that more than 54% of the arsenic was reduced to As(III). X-ray diffraction (XRD) and scanning electron microscopy (SEM) confirmed the extensive corrosion of the ZVI surface, which resulted in various species of iron oxyhydroxides responsible for the highly efficient sequester of arsenic through reduction, adsorption, and coprecipitation.     

单纤维过滤介质表面尘粒捕集的随机模拟

基于控制面概念和粒子运动轨迹计算,建立单纤维过滤介质表面尘粒捕集的三维随机计算模型,采用Ku-wabara流场表征单纤维表面的气流绕流特征。计算分析了St数、无量纲粒径及单纤维过滤模型填充密度对沉积物形态结构和积尘状态下单纤维捕集效率的影响。结果指出,St数对沉积物形态结构具有显著作用,随St数减小,沉积物由紧密的堆积结构演变为分叉显著的树枝状结构。模拟结果还发现,无论过滤条件如何变化,无量纲单纤维捕集效率随捕集粒子数呈近似线性增加关系。     

碳基高价银分子晶体电池处理LAS污染源水试验研究

以扬州第四水厂沉淀后的出水作为原水,模拟突发LAS污染,通过投加碳基高价银分子晶体电池进行应急处理的实验研究。实验结果表明：碳基高价银分子晶体电池对LAS的吸附,在30min内能达到81％的吸附容量;碳基高价银分子晶体电池对LAS的吸附,符合Freundlich吸附模式;溶液pH小于5时,吸附效果较好;对进水浓度小于4．75mg／L的LAS污染水样,接触时间在10min以内,便能使出水中LAS的浓度达到生活饮用水0．3mg／L的限值。     

多介质过滤-超滤-反渗透法深度处理废水的工艺改进

针对某厂多介质过滤-超滤-反渗透(MMF-UF-RO)废水深度处理工艺发生污堵的问题, 采用在MMF装置前加入NaOH混凝沉淀的改进工艺代替加入聚合氯化铝(PAC)絮凝剂的原工艺.模拟原工艺水样的初始UF膜通量较低,过滤后UF膜通量下降35%左右;模拟改进工艺水样的初始UF膜通量较高,且UF膜通量基本无变化.改进工艺UF装置出水中除SiO_2外,其他物质的质量浓度远小于原工艺UF装置出水,可有效改善RO装置的进水水质.改进工艺的MMF和UF的运行稳定性均明显优于原工艺.     

S-K型管式混合器-微絮凝高速过滤的实验研究

基于2种传统管式混合器的特点,研究了苏尔士-凯尼斯（S-K）新型组合管式混合器在预氧化-微絮凝高速过滤技术中的应用,对苏尔士（Sulzer）管式混合器、凯尼斯（Kenics）管式混合器及s-K型管式混合器高速过滤出水水质进行了对比分析,结果表明,S-K型微絮凝方式对浊度、COD及TP的平均去除率比其他2种混合器混合方式的去除效果提高了5％～10％,分别为80．3％、64．76％和51．15％。S-K型混合器过滤形成的絮体能够充分利用深层滤料,延长过滤周期。