微波-混凝处理高炉煤气洗涤水的实验研究

本文探索了微波作为辅助手段处理高炉煤气洗涤水过程中,微波辐射功率、微波辐射时间、聚合氯化铝(PAC)加入量、磷酸加入量对高炉煤气洗涤废水处理效果的影响。结果表明,微波和PAC混凝联用处理高炉煤气洗涤废水具有作用时间短、聚沉能力强等特点,可以有效去除废水中悬浮物,降低硬度及浊度。     

黄壤表面电场作用下Cu~(2+)与Zn~(2+)的吸附/解吸动力学研究

利用静态恒流法研究了黄壤表面电场作用下Cu2+与Zn2+的吸附/解吸动力学.结果发现:考虑黄壤表面电场作用下,Cu2+和Zn2+的吸附实验呈现初期强吸附作用下的零级动力学过程和一定时间之后弱吸附作用下的一级动力学过程,与理论预期一致;在Cu2+和Zn2+的解吸实验中,只有前期出现了弱吸附作用下的一级动力学过程,实验结果与理论预期存在差别,原因在于专性吸附的Cu2+、Zn2+很难被解吸下来;在交换/吸附实验中,Cu2+的吸附速率值和平衡吸附量均大于Zn2+,且Cu2+-K+体系的表面电化学参数φ0、σ0、E0均大于Zn2+-K+体系中的对应值,证明了黄壤颗粒表面对Cu2+的吸附作用强于Zn2+;在交换/解吸实验中,Zn2+的解吸速率值和平衡解吸量均大于Cu2+,Zn2+-K+体系的表面电化学参数φ0、σ0、E0均大于Cu2+-K+体系中的对应值,证明Zn2+-K+体系中Zn2+的解吸作用比Cu2+-K+体系中的Cu2+解吸作用强.     

A fouling suppression system in submerged membrane bioreactors using dielectrophoretic forces

A novel method was developed to suppress membrane fouling in submerged membrane bioreactors. The method is based on the dielectrophoretic (DEP) motion of particles in an inhomogeneous electrical field. Using a real sample of biomass as feed, the fouling-suppression performance using DEP with different electrical field intensities (60–160 V) and different frequencies (50–1000 Hz) was investigated. The fouling-suppression performance was found to relate closely with the intensity and frequency of the electrical field. A stronger electrical field was found to better recover the filtrate flux. This is because of a stronger DEP force acting on the biomass particles close to the membrane's surface. Above an intensity and frequency value of 130 V and 1 kHz, respectively the permeate flux was reduced due to an electrothermal effect.     

Biogenic volatile organic compound analyses by PTR-TOF-MS: Calibration, humidity effect and reduced electric field dependency

Green leaf volatiles(GLVs) emitted by plants after stress or damage induction are a major part of biogenic volatile organic compounds(BVOCs). Proton transfer reaction time-of-flight mass spectrometry(PTR-TOF-MS) is a high-resolution and sensitive technique for in situ GLV analyses, while its performance is dramatically influenced by humidity, electric field,etc. In this study the influence of gas humidity and the effect of reduced field(E/N) were examined in addition to measuring calibration curves for the GLVs. Calibration curves measured for seven of the GLVs in dry air were linear, with sensitivities ranging from 5 to10 ncps/ppbv(normalized counts per second/parts per billion by volume). The sensitivities for most GLV analyses were found to increase by between 20% and 35% when the humidity of the sample gas was raised from 0% to 70% relative humidity(RH) at 21°C, with the exception of(E)-2-hexenol. Product ion branching ratios were also affected by humidity,with the relative abundance of the protonated molecular ions and higher mass fragment ions increasing with humidity. The effect of reduced field(E/N) on the fragmentation of GLVs was examined in the drift tube of the PTR-TOF-MS. The structurally similar GLVs are acutely susceptible to fragmentation following ionization and the fragmentation patterns are highly dependent on E/N. Overall the measured fragmentation patterns contain sufficient information to permit at least partial separation and identification of the isomeric GLVs by looking at differences in their fragmentation patterns at high and low E/N.     

Preparation of steel slag porous sound-absorbing material using coal powder as pore former

The aim of the study was to prepare a porous sound-absorbing material using steel slag and fly ash as the main raw material, with coal powder and sodium silicate used as a pore former and binder respectively. The influence of the experimental conditions such as the ratio of fly ash, sintering temperature, sintering time, and porosity regulation on the performance of the porous sound-absorbing material was investigated. The results showed that the specimens prepared by this method had high sound absorption performance and good mechanical properties, and the noise reduction coefficient and compressive strength could reach 0.50 and 6.5 MPa, respectively. The compressive strength increased when the dosage of fly ash and sintering temperature were raised. The noise reduction coefficient decreased with increasing ratio of fly ash and reducing pore former, and first increased and then decreased with the increase of sintering temperature and time. The optimum preparation conditions for the porous sound-absorbing material were a proportion of fly ash of 50% (wt.%), percentage of coal powder of 30% (wt.%), sintering temperature of 1130°C, and sintering time of 6.0 hr, which were determined by analyzing the properties of the sound-absorbing material.     

电场作用对不同藻菌体系处理猪场废水的强化机制研究

为解决猪场废水高色、高浊、高盐的水质特征对藻菌微生物体系处理效果的限制作用,采用电场处理与多种不同微藻/细菌(活性污泥)微生物体系处理相结合,考察了电场对微生物处理猪场废水的效果和生长状况的影响和作用机制.同时,通过对比微藻、微藻-活性污泥、活性污泥3种微生物体系对经电场处理养猪沼液中污染物去除效果及微生物生长情况,考察了电场处理对微生物处理效果的影响和作用.结果表明：电场对养猪沼液色度和浊度均有较好的去除效果,去除率分别为90.43%、99.69%;电场处理后的沼液再进行微生物处理可取得更优的处理效果,微生物对总氮和总磷的去除率最高分别为70.65%、67.30%.此外,微藻-活性污泥共生体系在污染物去除效果和生长状况方面均优于单一微生物体系.微藻-活性污泥体系最终叶绿素a含量为接种时的7.65倍,活性污泥生物量为接种时的1.51倍,远高于单一微生物体系.说明电场处理与微藻-活性污泥生物处理相结合,可以有效提高污染物去除效果,同时获得更多有价的生物质资源,实现更为可观的经济价值,具有广阔的应用潜力和发展前景.     

焙烧炉筒体结构强度有限元分析

对焙烧炉筒体结构进行有限元建模仿真,考虑热应力、压力和重力对筒体结构受力的影响,计算了焙烧炉关键部位的蠕变疲劳寿命,同时探究进气温度、保温层及对流系数等参数的影响。结果表明:热应力是影响结构强度的关键因素;焙烧炉筒体在许用蠕变变形量为5%的情况下,其使用寿命超过设计寿命;在筒体加热过渡段铺设保温层,降低与外界空气对流和提高进气温度,有利于降低筒体应力。     

变电站与输电线路的电磁环境影响水平分析与测试评估——以部分220kV及110kV输变电设施为例

通过对220kV及110kV户内布置、户外布置方式的变电站,架空输电线路以及地下电缆线的工频电场强度、工频磁场强度的监测,分析比较了变电站及输电线路对环境的贡献水平以及衰减规律。结果表明输变电设施对环境的贡献值非常有限,且随与之距离的增加而明显衰减。     

高炉出铁场除尘方案研究

某钢铁企业高炉炼铁车间的出铁场在生产过程中产生大量高浓度的烟尘,对厂区的大气环境及周边的环境造成严重污染,同时直接危害了职工的身体健康。通过对整个出铁场除尘工艺系统及通风状况的分析及实际应用情况,总结出了适合该场合的系统除尘方案。     

30MHz以下电动车辆电磁兼容测试方法研究

本文深入研究SAE J551-5:2012,剖析30MHz以下电动车辆的电场辐射发射、磁场辐射发射和传导发射的测试布置、最大发射工况选择、测试过程、场分量和检波器组合、限值等方面;对比SAE J551-5:2004,针对GB/T18387-2008,提出若干修订建议,以提高其实用性和可操作性。