再论高压水射流清洗技术应用的专业化、规模化与社会化

高压水射流技术在清洗领域的应用，因其具有一系列优势，越来越为社会所认同和欢迎。以何种模式运行才能使其发展的更快、更好，是在该领域的工作者所普遍关注的问题。在理论与实践相结合的基础上，再次讨论并提出高压水射流清洗技术应用的专业化、规模化与社会化，以期在更大的范围引起同行的参与，共同寻求发展我国高压水射流清洗技术应用的最佳战略、策略和实施的方式。实践证明，高压水射流清洗技术应用的专业化、规模化与社会化是可以实现的。坚持为国民经济建设服务，使其专业化、规模化与社会化并逐步充实、完善，定能使之有更大的发展     

声波反吹清灰对除尘效率的影响

声波反吹清灰会使除尘效率略有降低，已被实验和统计资料所证实。为减小其对除尘效率的影响，又要达到降低除尘器运行阻力的目的，必须选择合适的鸣喇叭次数。对于较难脱落的粉尘应选较多的鸣喇叭次数，而对较易脱落的粉尘则不需每次清灰都鸣喇叭，仅需偶而启动一次。本文通过实验证明，对本实验所用的除尘系统，每四次反吹清灰后鸣喇叭一次是合适的。     

化学清洗技术在安钢D900风机冷却系统的应用

利用化学清洗技术，对风机循环系统、油冷却系统进行杀灭微生物、除垢、去锈、管壁钝化、预膜处理，既保证了高炉的正常生产，又延长了风机的使用寿命。     

垂直层流清净室新送风方式

分析了在空气净化中利用吊顶上方空间作静压室的送风方式的不合理之处，提出了1种管道送风方式。     

洛铜集团除尘系统的改造

洛铜集团有5台低频炉，均设有滤袋式除尘系统。但除尘效果不理想，厂房内烟尘四溢，污染严重。尤其在加料和转炉时，排烟量剧增，岗位工作环境恶劣。对系统进行改造后，效果较好。     

南钢炼铁厂4#高炉矿槽除尘系统的改造

从吸尘罩、系统管网、电改袋、卸输灰系统等方面介绍了南钢炼铁厂4#高炉矿槽除尘系统的改造情况,总结了4#高炉矿槽除尘系统改造的经验,为类似除尘系统的改造提供了范例.     

矿用旋流除尘器用子午加速除尘风机的研制

针对国内煤矿掘进工作面用湿式过滤式旋流除尘器配套除尘风机的工作特点,指出了解决矿用除尘风机安全可靠性的关键技术.特别介绍了新研制的矿用子午加速除尘风机的除尘原理、结构特点、性能指标以及配套除尘器使用效果.     

Effectiveness of HVAC Duct Cleaning Procedures in Improving Indoor Air Quality

Indoor air quality has become one of the most seriousenvironmental concerns as an average person spends about 22 hrindoors on a daily basis. The study reported in this article, wasconducted to determine the effectiveness of three commercialHVAC (Heating Ventilation Air Conditioning) duct cleaning processes in reducing the level of airborne particulate matterand viable bioaerosols. The three HVAC sanitation processeswere: (1) Contact method (use of conventional vacuum cleaning ofinterior duct surfaces); (2) Air sweep method (use of compressedair to dislodging dirt and debris); (3) Rotary brush method(insertion of a rotary brush into the ductwork to agitate anddislodge the debris). Effectiveness of these sanitationprocesses was evaluated in terms of airborne particulate andviable bioaerosol concentrations in residential homes. Eightidentical homes were selected in the same neighborhood. Twohomes were cleaned using each procedure and two were used ascontrols. It was found that both particle count readings andbioaerosol concentrations were higher when cleaning was beingperformed than before or after cleaning, which suggests thatdirt, debris and other pollutants may become airborne as aresult of disturbances caused by the cleaning processes.Particle count readings at 0.3 micron size were found to haveincreased due to cigarette smoking. Particle counts at 1.0micron size were reduced due to HVAC duct cleaning. Post-levelbioaerosol concentrations, taken two days after cleaning, werefound to be lower than the pre-level concentrations suggestingthat the cleaning procedures were effective to some extent.Homes cleaned with the Air Sweep procedure showed the highestdegree of reduction in bioaerosol concentration among the threeprocedures investigated.     

阻力平衡器在除尘管网中的应用

通过对在除尘系统中作为流体阻尼元件的阻力平衡器和调节阀门的对比分析,阐述了除尘管网中采用阻力平衡器的意义, 并对阻力平衡器的结构、工作原理和设计计算进行了介绍,最后强调了阻力平衡器使用时应注意的事项.     

汽车乘务舱半物理环境模拟的甲醛光净化效果分析

汽车乘务舱半物理环境模拟系统,以测试室作为汽车乘务舱的模拟环境,采用平衡子系统作为甲醛污染物生成装置,用于研究在不同条件下甲醛污染物的光净化效果。实验结果表明:良好的通风条件可以改善甲醛的降解效果;甲醛初始浓度升高后虽然其降解效果有所下降,但是降解效果仍然可以达到80%以上;用改变电压来改变光强,9V和12V不同光强条件下,12V的效果好于9V;光照面积的增加可以明显地改善光催化降解的效果;玻璃和皮革作为载体时,皮革载体的降解效果要远好于玻璃载体。实验研究证明,光净化材料完全可以应用于汽车内环境中,且对甲醛空气污染物具有良好的净化效果。