混凝-超滤短流程工艺处理北方水库原水简

采用混凝-超滤膜短流程工艺对大伙房水库原水进行处理,考察其除污染性能和膜污染情况,并对该短流程工艺参数进行优化。结果表明,当利用超滤膜直接过滤原水时,膜污染较重,并且对污染物质的去除率较低;而采用混凝-超滤短流程工艺时,膜污染得到一定程度上的缓解;当絮凝剂投加量为7 mg/L、膜清洗周期为30 min时,对浊度、COD_Mn和UV₂₅₄的去除率分别为95.61%、40.42%和37.12%,出水水质能够满足生活饮用水卫生标准。     

高压水射流清洗油井结垢管安全生产问题讨论

针对目前油田开发生产中出现的油井管存在结垢日益严重、清洗难度大、污染环境、影响油水井安全生产等问题,理论与实际结合,提出了利用高压水射流清洗结垢管技术。给出了结垢管安全清洗的工艺流程及清洗装置,并阐明射流清洗的工作原理、结构特点、技术标准、检验方法、安全保护措施等,同时进行了高压旋转喷头的设计和其他技术参数的优选。通过胜利油田孤东采油厂结垢管现场高压水射流安全清洗,证实该技术具有良好的经济效益和社会效益,保证结垢管的安全使用和油水井的安全生产。     

机械清洗法对MBR膜泥饼层的影响

膜污染是制约MBR发展的瓶颈。考察投加ABS颗粒对MBR膜组件上膜泥饼层的影响,并设对照实验。结果表明,对照MBR膜通量下降速度快,膜污染严重,膜表面上累积厚厚的泥饼层,而在ABS MBR中膜通量下降速度则缓慢的多,且膜上泥饼层积累量则明显少于对照MBR;曝气量越大,颗粒运行的速度也越快,泥饼层被撞落量也越多;颗粒以碰撞角度为45°冲刷膜的情况下,泥饼层掉落效果明显增加;泥饼层包裹的膜丝根数越多,泥饼层的静摩擦力和保持泥饼层不被破坏的力也越大,泥饼层就越难被冲刷掉。SEM照片显示,ABS MBR的膜孔堵塞要严重于对照MBR,表面的褶皱要较对照MBR多。     

炼油污水回用处理RO系统的稳定运行及维护

文章介绍了兰州石化公司炼油污水深度处理反渗透(RO)系统的工艺流程及维护。通过进出水电导率、产水回收率等变化情况,分析了RO系统的运行状况。得知:运用此系统,反渗透系统产水回收率达到65%～70%,系统脱盐率在99%以上,产水可以满足一级除盐水要求,实现了装置稳定运行的目标。     

熟料造纸清洁生产量化评价—以承德兴业造纸项目为例

运用专家调查打分法,以具体的承德兴业造纸项目为例,初步探讨了清滞生产量化评价方法,程序以及清洁生产评价指标的应用。     

Wet weather impact on trihalomethane formation potential in tributaries to drinking water reservoirs

During rain storm events, land surface runoff and resuspension of bottom sediments cause an increase in Trihalomethane (THM) precursors in rivers. These precursors, when chlorinated at water treatment facilities will lead to the formation of THMs and hence impact drinking water resources. In order to evaluate the wet weather impact on the potential formation of THMs, river samples were collected before, during and after three rain storms ranging from 15.2 to 24.9 mm precipitation. The samples were tested for THM formation potential and other indicators including UV254 absorbance, turbidity and volatile suspended solid (VSS). Average levels of THMs increased from 61 μg/l during dry weather to 131 μg/l during wet weather, and then went back to 81 μg/l after rain ended. Wet weather values of THM are well above the maximum contaminant level (MCL) 80 μg/l, set by EPA for drinking water. THM indicators also exhibited similar trends. Average levels increased from 0.6 to 1.8 abs; 2.6 to 6 ntu; and 7.5 to 15 mg/l respectively for UV254, turbidity and VSS. A positive correlation was observed between THM formation and THM indicators. The t-test of significance (p-value) was less than 0.05 for all indicators, and R values ranged from 0.85 to 0.92 between THMs and the indicators, and 0.72 to 0.9 among indicators themselves.     

化学沉淀组合电催化氧化处理脱硫废液技术研究

真空碳酸钾脱硫工艺碱洗段废液因含有高浓度硫化物、COD等有毒成分而影响焦化废水后续生物处理。以焦化企业实际碱洗段废液为研究对象,选用化学沉淀和电催化氧化的组合方式对其进行预处理。结果表明,室温下当氧化铜的投加量为65 g/L、反应时间60 min时废液中S2-去除率可达93%,且经过高温灼烧可实现Cu O沉淀剂的再生使用。沉淀后出水经电催化氧化处理,在电流10 A、电压4.9 V、电解时间120 min的条件下,出水COD可降至2 400 mg/L,满足常规生化系统进水的要求。     

Partial neutralization of rain by seaspray: the case of Recôncavo, Bahia-Brazil

In the Recôncavo of Bahia (located between 12°33′ and 13°10′S and 38°00′and 39°00′W), there are significant discharges of SO₂ and NO_x due to local, industrial and urban activities. The incoming air masses from the Atlantic Ocean are enriched with seaspray, which neutralizes part of the rain acidity. The extent of seaspray neutralization of rain acidity was quantified in four sites of the region, each with different loads of seaspray. Rain samples were obtained daily at the same time, integrating the precipitation of the previous 24 h, using wet-only collectors and analyzed for pH by potentiometry and for sodium by flame photometry. The amount of rain acidity in Recôncavo neutralized by seaspray ranged from <1% up to 88% and depended on the site. On average, neutralization ranged from 5% to 18%.     

正渗透去除地表水中DOM的效能研究

采用经砂滤处理后的滆湖水作为原料液,氯化钠溶液作为汲取液,在不同影响因素条件下进行正渗透试验,并对试验后的膜片进行清洗,探究膜污染的可逆性.结果表明:提高汲取液浓度、运行温度及膜面流速均可有效增加膜通量;正渗透对滆湖水体中的溶解性微生物代谢产物、类色氨酸、类富里酸和腐殖酸四种主要DOM成分均有较好的去除效果,DOC、UV₂₅₄截留率均在96%以上;短期运行通过水力清洗几乎可以完全恢复膜通量,而长期运行通过超声清洗可以基本恢复全部膜通量,通过分析膜清洗液可知造成膜污染的主要物质为类色氨酸类和类富里酸类物质.     

A feasibility and cost comparison of perchloroethylene dry cleaning to professional wet cleaning: case study of Silver Hanger Cleaners, Bellingham, Massachusetts

The Toxics Use Reduction Institute (TURI) has been working with the dry cleaning sector for over 10 years - focusing on the ultimate goal of eliminating the use of perchloroethylene in this sector due to the availability of less toxic, feasible alternatives. Professional wet cleaning has been identified as one of these alternatives and has been a focus of the Institute in recent years. In 2008, the Institute provided a matching grant to Silver Hanger Cleaners in Bellingham, Massachusetts to convert their operations from perchloroethylene-based to water-based processes. Two years of data have been collected from the facility, reflecting one year of solvent use and one year of dedicated professional wet cleaning. The analysis of that data is presented here, including capital costs, performance data and associated costs, operational costs, and resource use and associated costs.