钢铁企业工作场所煤气泄漏扩散规律的研究

以钢铁企业管网煤气泄漏为研究对象,以煤气泄漏扩散规律为研究主题,在确定煤气泄漏相似于浮力射流的基础上,建立煤气泄漏扩散的数学模型。采用CFD软件PHOENICS数值模拟气体泄漏过程的速度场及其浓度分布。在已有煤气泄漏检测系统的基础上,选择性实验模拟煤气泄漏浓度与扩散时间、扩散方向的变化。数值模拟和实验模拟表明,虽然两种方法所得结果存在一定差异,从定性分析角度而言,却能够反映工作场所煤气泄漏后在有限空间内运移扩散的一般规律。     

高压水射流清洗油井结垢管安全生产问题讨论

针对目前油田开发生产中出现的油井管存在结垢日益严重、清洗难度大、污染环境、影响油水井安全生产等问题,理论与实际结合,提出了利用高压水射流清洗结垢管技术。给出了结垢管安全清洗的工艺流程及清洗装置,并阐明射流清洗的工作原理、结构特点、技术标准、检验方法、安全保护措施等,同时进行了高压旋转喷头的设计和其他技术参数的优选。通过胜利油田孤东采油厂结垢管现场高压水射流安全清洗,证实该技术具有良好的经济效益和社会效益,保证结垢管的安全使用和油水井的安全生产。     

基于Linux的嵌入式无线图像监控系统

介绍一种基于Linux的嵌入式操作系统和CDMA 1X无线数据业务的图像监控系统方案.系统以LvRLinux操作系统为软件平台,以ARM9微处理器AT91RM9200为硬件平台,采用MPEG-4的专用编码芯片G07007SB对采集到的视频信号进行压缩编码.然后生成MPEG-4视频流.AT91RM9200将视频流进行处理、缓存后通过串口发送到CDMA 1X无线模块,通过CDMA 1X业务将图像数据发送到远端服务器.远端服务器具有固定的实IP地址.远端服务器通过SOCK2ET接收图像数据并进行解码显示,还可以通过发送控制信号实现对下位机的控制.     

Advantages and risks of using steel slag in preparing composts from raw organic waste

It had been reported that iron and manganese oxides in steel slag enhanced the production of humic acid (HA) from low-molecular-weight compounds, such as phenolic acids, amino acids, and saccharides. In the present study, this function of steel slag was applied to the composting of raw organic wastes (ROWs). The degree of humification of HAs is an important factor in evaluating compost quality. Thus, HAs were extracted from the prepared composts and the humification parameters were determined, in terms of elemental compositions, acidic functional group contents, molecular weights, spectroscopic parameters from UV–vis absorption and ¹³C NMR spectra. The timing for adding steel slag affected the degree of humification of HAs in the composts. The weight average molecular weight of a HA when slag was added initially (29 kDa) was significantly higher than when slag was added after elevating the temperature of the compost pile (17–18 kDa). These results show that ROWs are decomposed to low-molecular-weight compounds after the pile temperature is elevated and the presence of slag enhances the polycondensation of these compounds to produce HAs with a higher degree of humification. Because the slag used in the present study contained several-tens ng g^?1 to several μg g^?1 of toxic elements (B, Cu, Cr, and Zn), leaching tests for these elements from the prepared composts were carried out. Levels for leaching boron from composts prepared by adding slag (0.2–0.4 mg L^?1) were obviously higher than the corresponding levels without slag (0.05 mg L^?1).     

利用钢铁盐酸酸洗废液在填料塔中制备FeCl3

以钢铁盐酸酸洗废液为原料,亚硝酸钠为催化剂,氧气为氧化剂,在填料塔中催化氧化制备三氯化铁。考察了反应温度、催化剂加入量和添加方式、循环流量等对制备三氯化铁的影响。实验结果表明,在优化的工艺条件为料液预热温度为60 ℃、催化剂加入量为钢铁盐酸酸洗废液总质量的0.30%、料液循环流量6.0 m³/h的条件下,反应80~120 min,酸洗废液中的Fe²⁺完全氧化为Fe³⁺。     

Sustainable supply chains—minerals and sustainable development,going beyond the mine

If the minerals and metals sector is to contribute successfully to sustainable development, it must adopt principles and practices which address the entire life cycle of the materials it creates. This paper examines how the social and environmental sustainability performance of products influences the sustainability agenda of the mining and metals sector. It illustrates how access to markets drives improvements in sustainability. It also considers how the sustainability of metal and non-metal products are using lifecycle approaches and outlines the importance of using appropriate tools for metals.     

村镇供水管网优化设计探讨

如何合理确定村镇供水管网敷设方案,关系到整个供水系统的安全性和可靠性。通过生成树变化法,将环状管网转化成树状管网,确定供水管网中最短供水路线,再计算最短供水路线下的最低综合费用、供水系统的经济管径,以确定最优管道敷设方案。根据该方法对四川省某镇供水系统进行了设计。     

钢渣掺量对泡沫混凝土砌块性能的影响

泡沫混凝土是一种环保、节能的保温隔热材料,以其优良的保温性能,受到越来越多研究者的关注。对钢渣的特性进行了分析测试,对钢渣不同掺量对泡沫混凝土砌块特性的影响进行了研究,结果表明,采用添加5％～35％钢渣所制备的钢渣泡沫混凝土砌块,其密度等级为JC／T1062—2007中的B10级,掺人5％、15％钢渣的泡沫混凝土抗压强度达到A3．5等级,掺人25％、35％钢渣的泡沫混凝土抗压强度达到A2．5等级。随着钢渣掺量的增大,抗压强度、抗折强度降低,吸水率增大。在同一钢渣掺量的情况下,泡沫混凝土砌块的抗压强度变化率增加显著,而且随着钢渣的加入量升高而增大。钢渣的加入有利于提高泡沫混凝土砌块的后期抗压强度。     

SO2在碳钢初期大气腐蚀中的作用

通过自建的模拟大气腐蚀系统,借助金相显微镜、扫描电镜(SEM/EDX)、X-射线衍射(XRD)和x-射线光电子能谱(XPS),研究了SO2对碳钢初期大气腐蚀行为的影响,并进一步用原子力显微镜从更微观的角度观察了在SO2环境中初期阶段腐蚀形貌变化.研究结果表明:在SO2污染大气环境中,随SO2浓度的升高碳钢腐蚀加快.在体积分数为5×10(-6)SO2的大气环境中,碳钢和耐候钢表面腐蚀主要以条状物生长,随着SO2浓度的升高,腐蚀产物的形貌发生改变,在体积分数为5×10(-5)SO2的大气环境中,条状锈和胞状锈同时生长.在锈层中S元素以FeSO4·4H2O的形式存在,腐蚀产物中还有γ-FeOOH.SO2在初期阶段加速了碳钢的腐蚀,降低了碳钢的耐蚀性.     

河北省钢铁工业主要大气污染物减排潜力分析

通过对河北省钢铁工业存在问题的分析,得出我省钢铁行业主要大气污染物为二氧化硫和粉尘.结合我省钢铁企业的实际情况,从工程技术、政策管理等方面提出相应治理措施,并对"十一五"期间我省钢铁行业二氧化硫和粉尘减排效益进行预测.预测结果显示:采用所建议的减排措施后,我省钢铁工业二氧化硫减排量对全省"十一五"减排计划的贡献率为81.4%;粉尘可减排60%.