蔗糖厂自愿清洁生产审核实例

介绍了蔗糖厂自愿清洁生产审核中的审核重点、审核目标的确定，清洁生产方案的产生和筛选，以及清洁生产审核效果的统计。     

Fulvic acid removal by nanoparticle TiO2 using a submerged membrane photocatalysis reactor

The degradation of fulvic acid（FA） by nanoparticle TiO2 in a submerged membrane photocatalysis（SMPC） reactor was studied. In this reactor, photocatalytic oxidation and membrane separation co-occured. The continuous air supplier provided O2 for the photocatalytical reaction and mixed the solution through an airflow controller. The particle TiO2 could automatically settle due to gravity without particle agglomeration so it could be easily separated by microfiltration（MF） membrane. It was efficient to maintain high flux of membranes. The effects of operational parameters on the photocatalytic oxidation rate of FA were investigated. Results indicated that photocatalyst at 0.5 g/L and airflow at 0.06 m^3/h were the optimum condition for the removal of fulvic acid, the removal efficiency was higher in acid media than that in alkaline media. The effects of different filtration duration on permeate flux rate of MF with P25 powder and with nanoparticle TiO2 were compared. Experimental results indicated that the permeate flux rate of MF was improved and the membrane fouling phenomenon was reduced with the addition of nanoparticle TiO2 catalyst compared with conventional P25 powder. Therefore, this submerged membrane photocatalysis reactor can faciliate potential application of photocatalytic oxidation process in drinking water treatment.     

推行清洁生产实现可持续发展

对集团公司全面开展清洁生产的情况做了综述和总结，几年来的清洁生产实践表明，清洁生产促进了石化企业的发展，同时降低了废物排放，取得了明显的成果。清洁生产是保护环境的有力手段，也是实施可持续发展战略的重要措施     

湿法稀土清洁生产工艺研究

对某稀土湿法冶炼工艺进行了清洁生产主案研究，结果表明，精矿ＲＥＯ浸取率由９０％提高到９７％，从酸浸废液中年回收硫酸亚铁３０００ｔ；从碱转废液中年回收硫酸钠３０００ｔ；废吕中氟回收率８６％；生产废话水排放量削减５８％，废水污泥量削减９０％；经济效益年２００万元以上。     

聚电解质溶液中粘土颗粒的ζ电位

分别测定了 5种不同分子量和 5种不同分子链电荷密度的阴离子聚电解质高分子在钠蒙脱石粘土颗粒表面吸附前后粘粒的ζ电位 ;讨论分析了分子结构和体系环境对粘粒 ζ电位的影响以及聚电解质对粘土 -水分散体系的稳定作用。     

海水中氰化物测定方法探讨

对应用异烟酸 吡唑啉酮分光光度法测定海水中氰化物的方法进行了补充和改进,提高了海水氰化物测定方法的精密度和准确度。     

Analysis of the hydrocyclone stock cleaning process for wasted fibre in a paper mill

The main objective of this project was to evaluate the possibility of reducing the quantity of fibre wasted at one of many hydrocyclone (centrifugal) cleaning processes in a paper mill. It was found that the application of elutriation water to both the tertiary and quaternary cleaners was essential to minimise the fibre discharged to the sewer, and the pressure of this elutriation water had a dramatic effect of reducing the fibre wastage. Accordingly, it has been shown that 150–160 kPa as the optimum pressure range to apply elutriation water to minimise the product grade fibre wasted whilst sending undesired shive fibre to the sewer. Also, monitoring of the press uhle box wastewater revealed that the paper mill has the potential to make substantial cost savings by reducing the waste stream. Further investigation is necessary to determine the types of fibre that are being wasted, and the viability of a screen to recycle the wasted fibre to the process. However, these fibres may be unsuitable to reuse in the process and alternative uses must be found.     

造纸行业的清洁生产示范

文章概述了我国造纸行业清洁生产示范项目审计的成果，从环境、经济及清洁生产方案类型等角度对企业推行清洁生产进行了初步分析，提出了存在的主要问题，并就进一步推动造纸行业的清洁生产提出了建议。     

确定不同保证率下的中国酸沉降临界负荷

在进行中国酸沉降临界负荷区划时 ,通常以 1°× 1°(经纬度 )的网格为单位进行计算 ,难以反映网格内不同生态系统对酸沉降敏感性的差异 .为了便于决策者根据临界负荷确定酸沉降控制对策 ,也为了使 1°× 1°的结果更具代表性和实用性 ,本研究确定了 0 1°× 0 1°网格为单位计算的中国酸沉降临界负荷 ,并在此基础上通过引入保证率的概念 ,得到了一系列与一定的经济技术水平相适应的、允许有一定损失的 1°× 1°的中国酸沉降临界负荷图 .利用累积分布函数 ,本研究还确定了不同保证率下的中国酸沉降超临界负荷分布和各省、市、自治区的酸沉降临界负荷 .     

复合混凝剂处理印染废水

为了处理高浓度、高色度、高COD的印染废水，利用硫酸亚铁、工业废酸和金属下脚料自行配制了复合混凝剂，并将其与聚合双酸铝铁、聚合氯化铝铁、硫酸亚铁对印染废水的混凝效果进行对比。研究表明，复合混凝剂处理印染废水具有成本低、效果好的特点。当硫酸亚铁的投加量为200mg/L，复合混凝剂的投加量为1280mg／L，PAM的用量为2mg／L时，脱色率达94．9％，COD去除率达78．1％，悬浮固体（SS）去除率达90．9％。