A new approach to determine relieving temperature and thermodynamic behavior of trapped single and multi-phase fluid exposed to fire

Process safety plays a key role in modern industries. This is more significant specifically in off-shore oil and gas platforms where releasing hydrocarbons could cause irreversible damages to both environment and personnel. An important instrument device which can provide safety for process equipment in oil and gas fields is safety relief valve. Correct sizing procedure of such devices depends strongly on physical properties of fluid and relieving condition. The present study revolved around applying thermodynamic concepts and modeling to throw some light on the behavior of trapped fluid exposed to fire in order to evaluate precise temperature and fluid properties at relieving condition. Peng–Robinson equation of state together with a three phase flash has been utilized to handle the calculation. Effect of different design parameters has been evaluated for three distinct categories of fluids namely natural gas, gas-condensate mixture, and gas-oil mixtures. These parameters encompass of operating temperature, operating pressure, Difference of Operating and Design Pressure, gas and oil specific gravities, gas-oil ratio, and water cut. The study depicted that American Petroleum Institute practice number 521 which suggests an ideal gas assumption fails to provide reliable predictions as it significantly overestimate the relieving temperature. Moreover, black oil correlations were also used for the relief temperature estimation of gas-oil-water mixtures. Comparison with HYSYS results as a prominent engineering software proved that black oil models are reliable tools to predict relief temperature.     

二氧化碳灭火系统扑灭风电机组舱内火灾试验研究

为有效遏制全国多地风力发电机组火灾事故的势头,基于灭火系统在风电机组防火设计中的重要性,提出采用二氧化碳灭火系统对风电机舱进行灭火保护的解决方案。在建造国内首台风电机组火灾模拟试验装置的基础上,通过试验研究二氧化碳灭火系统在常温状态和低温状态下对风电机组火灾的灭火能力。结果表明,该灭火系统能够对风力发电机组进行全淹没灭火保护,适用于空间狭小且结构复杂的风电机舱;在低温条件下,其喷放时间和灭火时间虽比常温状态下长,但灭火效能并未降低。     

三江平原泥炭沼泽孔隙水甲烷浓度变化动态及其影响因子

湿地土壤孔隙水甲烷浓度变化动态对于揭示湿地碳循环过程具有重要作用.于2012年和2013年对三江平原毛苔草泥炭沼泽不同土壤深度孔隙水甲烷浓度的季节变化动态进行监测,并分析了其关键影响因子.结果表明:植物生长季孔隙水甲烷浓度呈单峰变化趋势,不同土层甲烷浓度峰值(80.45~490.95μmol·L-1)主要集中在湿润的生长季末,但年际间存在显著差异;从土壤剖面来看,土壤融通之后,孔隙水中甲烷浓度随着土壤深度的增加而增加;土壤表层(5 cm和10 cm)甲烷浓度主要受到株高(R2=0.6,p=0.005)和土壤充水孔隙率(R2=0.36,p=0.01)的影响,而深层(20~40 cm)甲烷浓度主要受到土壤温度等因素的综合影响.研究还表明,表层土壤孔隙水甲烷浓度能够解释生长季甲烷排放通量变化的26%~60%,而且短期的极端降雨事件可能不会对甲烷浓度以及甲烷排放产生即时影响,而是出现大约一周的延迟(time lag)现象,这主要取决于实际土壤湿度.     

一株高效降解废水有机质耐冷菌的筛选、鉴定及特性研究

利用生物法进行污水处理已被国内外广泛使用,但由于温度影响微生物的生长和繁殖,使其成为生物污水处理效率的限制因子.本研究从污水处理厂活性污泥中分离出5株在低温4℃条件下生长良好的菌株,其中菌株DW1在4℃条件下,96 h时可将初始COD为800 mg·L-1的生活污水有机物去除率高达67.7%.结合菌落形态特征、生理生化特性以及16S r DNA序列分析,将菌株DW1初步鉴定为假单胞菌(Pseudomonas sp.).菌株DW1对COD负荷较高的污水处理效果较好;接种量为3%(体积分数)、p H为7.0时,菌株对污水COD去除率和DHA活性较高.在4℃和25℃条件下,菌株DW1均在96 h对污水COD去除率和DHA活性最高,分别为71.2%、11.35μg·m L·h-1(以TF计)和78.8%、15.11μg·m L-1·h-1(以TF计).     

土壤及铁锰结核中锰氧化菌的氧化特性分析

利用从土壤铁锰结核及其附近土壤中分离筛选得到的4株锰氧化菌,研究了不同pH、Mn(Ⅱ)初始浓度下菌株的锰氧化效率及生长情况,并用SEM-EDS及TEM对菌株WHS26、GY16形成的生物氧化锰及水羟锰矿进行了表征.结果表明,pH及Mn(Ⅱ)初始浓度对菌株的锰氧化效率均有影响,4株菌在pH 7~8、Mn(Ⅱ)初始浓度为10~20 mmol·L-1时,锰氧化效率最高;GY16、WHS26形成的生物氧化锰的形貌与化学合成的水羟锰矿存在明显差异,前者呈胶膜状附着在菌株表面,后者呈结晶态.该结果可为生物氧化锰应用于重金属污染修复提供技术支撑.     

Sensitivity of veliger larvae of Mytilus edulis and mussel of various sizes to chlorination

The blue mussel Mytilus edulis is one of the dominant fouling organisms in cooling water systems. In this work, how veliger larvae and different size groups of the mussels responded against chlorine dosage was examined. Veliger larvae mortality was studied at different residual chlorine concentrations (0.05–0.5 mg L^?1), and it was found that a chlorine dose of 0.5 mg L^?1 is 4 times as effective as 0.05 mg L^?1 and twice as effective as 0.1 mg L^?1. Mortality of 100% for three size groups (1.4, 14, and 25 mm) and relative physiological activities of two size groups (14 and 25 mm) were observed. The exposure duration for 100% mortality of mussels decreased with the increasing residual chlorine concentration (0.1–4.0 mg L^?1). Mussel size was also found to be an important factor, considering that the continuation times for mussel mortality were 28 h for the 1.4 mm and 410 h for the 25 mm size groups. All size groups showed progressive reduction in physiological activities, such as oxygen consumption, foot activity, and byssus thread production with increasing chlorine dose (0.05–1.0 mg L^?1); the two data-sets were strongly correlated with each other. The results of this study should be of significance for optimizing the chlorine content, and minimize the environmental threat to industries where mussels are the dominant fouling organisms.     

一株产电菌嗜根考克氏菌(Kocuria rhizophila)的分离及其产电性能优化

本研究以天津泰达污水处理厂污泥浓缩间的污泥为接种物,启动并运行了微生物燃料电池(MFCs).从富集的阳极生物膜上分离得到了一株纯培养的微生物菌种,命名为P2-A-5.研究发现,菌株P2-A-5的16S rDNA序列与菌株Kocuria rhizophila DC2201具有100%的同源性,结合该菌的形态特征和生理生化实验,将其归属为嗜根考克氏菌(Kocuria rhizophila).通过化学剂处理、底物种类和浓度的优化,进一步提高其在微生物燃料电池中的产电性能.结果表明,菌株K.rhizophila P2-A-5经0.5 mg·L-1溶菌酶处理45 min后,接种到以2.0 g·L-1海藻糖为底物的阳极液中运行MFCs,其功率密度达到314.8 m W·m-2,比优化前(74.9 m W·m-2)提高了320.3%.这是首次对K.rhizophila种内微生物产电性能及其在微生物燃料电池中应用的报道,其成果对于丰富产电微生物的多样性,挖掘更多具有高电化学活性的微生物菌种,提高其产电性能具有重要的理论意义.     

Aureobasidium pullulans UVMU3-1产耐热性胞外漆酶活性物质培养基优化及其对染料脱色作用

对出芽短梗霉无色素突变株Aureobasidium pullulans UVMU3-1产耐热性胞外漆酶活性物质培养基进行优化,并研究其分子量大小、热稳定性及对三苯甲烷类染料孔雀石绿和结晶紫的脱色作用.结果表明:蔗糖、NaNO_3为UVMU3-1产耐热性胞外漆酶活性物质的最佳碳源和氮源,产酶优化培养基配方为:蔗糖66.5 g·L~(-1),NaNO_338.4 g·L~(-1),NaCl 1.08 g·L~(-1),酵母浸粉0.2 g·L~(-1),KH_2PO_41 g·L~(-1),pH=6.0.影响UVMU3-1产耐热性胞外漆酶活性物质的因素依次为:起始pH蔗糖NaClNaNO_3,培养7 d时产生最大酶活(94.81 U·L~(-1)),比对照提高3.85倍.其分子量小于1000 D,具有良好的热稳定性,煮沸30 min后高温酶活仍残留72.50%.粗酶液(7.5 U·L~(-1))与三苯甲烷类代表性染料孔雀石绿和结晶紫75℃反应5 min后,脱色率分别为76.3%、77.5%,反应35 min后脱色率分别达到96.3%、95.3%.     

Cu(II), Fe(III) and Mn(II) combinations as environmental stress factors have distinguishing effects on Enterococcus hirae

Pollution by various heavy metals as environmental stress factors might affect bacteria. It was established that iron (Fe(III)), manganese (Mn(II)) and copper (Cu(II)) ion combinations caused effects on Enterococcus hirae that differed from the sum of the effects when the metals were added separately. It was shown that the Cu²⁺-Fe³⁺ combination decreased the growth and ATPase activity of membrane vesicles of wild-type E. hirae ATCC9790 and atpD mutant (with defective F_oF₁-ATPase) MS116. Addition of Mn²⁺-Fe³⁺ combinations within the same concentration range had no effects on growth compared to control (without heavy metals). ATPase activity was increased in the presence of Mn²⁺-Fe³⁺, while together with 0.2 mmol/L N,N'-dicyclohexylcarbodiimide (DCCD), ATPase activity was decreased compared to control (when only 0.2 mmol/L DCCD was present). These results indicate that heavy metals ion combinations probably affect the FOF1-ATPase, leading to conformational changes. Moreover the action may be direct or be mediated by environment redox potential. The effects observed when Fe³⁺ was added separately disappeared in both cases, which might be a result of competing processes between Fe³⁺ and other heavy metals. These findings are novel and improve the understanding of heavy metals ions effects on bacteria, and could be applied for regulation of stress response patterns in the environment.     

Cu(II), Fe(III) and Mn(II) combinations as environmental stress factors have distinguishing effects on Enterococcus hirae

Pollution by various heavy metals as environmental stress factors might affect bacteria. It was established that iron (Fe(III)), manganese (Mn(II)) and copper (Cu(II)) ion combinations caused effects on Enterococcus hirae that differed from the sum of the effects when the metals were added separately. It was shown that the Cu^2 +–Fe^3 + combination decreased the growth and ATPase activity of membrane vesicles of wild-type E. hirae ATCC9790 and atpD mutant (with defective F_oF₁-ATPase) MS116. Addition of Mn^2 +–Fe^3 + combinations within the same concentration range had no effects on growth compared to control (without heavy metals). ATPase activity was increased in the presence of Mn^2 +–Fe^3 +, while together with 0.2 mmol/L N,N′-dicyclohexylcarbodiimide (DCCD), ATPase activity was decreased compared to control (when only 0.2 mmol/L DCCD was present). These results indicate that heavy metals ion combinations probably affect the F_OF₁-ATPase, leading to conformational changes. Moreover the action may be direct or be mediated by environment redox potential. The effects observed when Fe^3 + was added separately disappeared in both cases, which might be a result of competing processes between Fe^3 + and other heavy metals. These findings are novel and improve the understanding of heavy metals ions effects on bacteria, and could be applied for regulation of stress response patterns in the environment.