Enhancement of thermophilic anaerobic digestion of thickened waste activated sludge by combined microwave and alkaline pretreatment

Pretreatment of thickened waste activated sludge (TWAS) by combined microwave and alkaline pretreatment (MAP) was studied to improve thermophilic anaerobic digestion efficiency. Uniform design was applied to determine the combination of target temperature (110–210°C), microwave holding time (1–51 min), and NaOH dose (0–2.5 g NaOH/g suspended solids (SS)) in terms of their effect on volatile suspended solids (VSS) solubilization. Maximum solubilization ratio (85.1%) of VSS was observed at 210°C with 0.2 g-NaOH/g-SS and 35 min holding time. The effects of 12 different pretreatment methods were investigated in 28 thermophilic batch reactors by monitoring cumulative methane production (CMP). Improvements in methane production in the TWAS were directly related to the microwave and alkaline pretreatment of the sludge. The highest CMP was a 27% improvement over the control. In spite of the increase in soluble chemical oxygen demand concentration and the decrease in dewaterability of digested sludge, a semi-continuous thermophilic reactor fed with pretreated TWAS without neutralization (at 170°C with 1 min holding time and 0.05 g NaOH/g SS) was stable and functioned well, with volatile solid (VS) and total chemical oxygen demand (TCOD) reductions of 28% and 18%, respectively, which were higher than those of the control system. Additionally, methane yields (L@STP/g-CODadded, at standard temperature and pressure (STP) conditions of 0°C and 101.325 kPa) and (L@STP/g VSadded) increased by 17% and 13%, respectively, compared to the control reactor.     

废弃线路板热解油中酚类物质的提取与分离

将FR-4型废弃线路板热解,并对热解油中含量最多的组分-酚类物质进行分离提取.比较研究线路板热解油的分离提取方法,探索出"碱液处理-酸化-萃取-减压蒸馏"的新方法,对分离出的组分进行GCMS(气质联用)测试.结果显示运用该方法对FR-4型线路板的热解油进行提取分离,得到的总酚占热解油的62.0%,其中苯酚的最高纯度可达...     

稀土磁盘水处理方案技术经济比较

文章针对日照钢铁集团公司2150热轧水处理工程浊环水处理方案选择,对传统沉淀过滤法和先进的稀土磁盘法进行了对比和分析,稀土磁盘法在效果、占地、投资和运行维护费用上有较多优势,最终选用该工艺。     

Removal of phosphate from wastewater using alkaline residue

Alkaline residue(AR) was found to be an efficient adsorbent for phosphate removal from wastewater. The kinetic and equilibrium of phosphate removal were investigated to evaluate the performance of modified alkaline residue. After treatment by NaOH(AR-NaOH), removal performance was significantly improved, while removal performance was almost completely lost after treatment by HCl(AR-HCl). The kinetics of the removal process by all adsorbents was well characterized by the pseudo second-order model. The Langmuir model exhibited the best correlation for AR-HCl, while AR was effectively described by Freundlich model. Both models were well fitted to AR-NaOH. The maximum adsorption capacities calculated from Langmuir equation were in following manner: AR-NaOH AR AR-HCl. Phosphate removal by alkaline residue was pH dependent process. Mechanisms for phosphate removal mainly involved adsorption and precipitation, varied with equilibrium pH of solution. For AR-HCl, the acid equilibrium pH( 6.0) was unfavorable for the formation of Ca-P precipitate, with adsorption as the key mechanism for phosphate removal. In contrast, for AR and ARNaOH, precipitation was the dominant mechanism for phosphate removal, due to the incrase on pH( 8.0) after phosphate removal. The results of both XRD and SEM analysis confirmed CaHPO4·2H2O formation after phosphate removal by AR and AR-NaOH.     

内蒙古羊草草原根呼吸和土壤微生物呼吸区分的研究

利用根生物量回归法对内蒙古锡林河流域羊草草原根呼吸和土壤微生物呼吸进行了区分.结果表明,根呼吸占土壤呼吸的比例在13%~52%之间,平均为(24±3)%;土壤微生物呼吸占土壤呼吸的比例在48%~87%之间,平均为(76±3)%.土壤呼吸与根生物量的线性相关性不稳定.根呼吸活力与根冠比具有负指数相关关系(R2=0.661,P=0.20),与0~10、10~20、20~30和30~40 cm土壤含水量均有极显著的正指数相关关系(P<0.000 1).根呼吸与根呼吸活力具有极显著的指数相关关系(R2=0.848,P=0.01),根呼吸对土壤呼吸的贡献量与根呼吸活力具有显著的指数相关关系(R2=0.818,P=0.01).     

提高污泥碱性发酵挥发酸积累的新方法

为了加大剩余污泥在碱性条件下的水解酸化程度,本研究尝试了两种新的能促进污泥碱性发酵产酸的方式,分别是向批式的污泥碱性发酵系统中投加未灭菌发酵污泥和投加灭菌发酵污泥,结合温度的影响(10℃和35℃)分别考察了这两种方式对污泥水解酸化效果的影响.结果表明,中温有利于水解酶和产酸菌作用的发挥,增大了污泥的水解酸化程度,体系内有明显的挥发酸(VFAs)积累.35℃条件下,两种方式都在很大程度上促进了新鲜污泥的水解酸化程度,经灭菌后的发酵污泥的投加较等量的未灭菌的发酵污泥的投加效果更为显著.前者的水解速率是后者的2倍,发酵末期酸积累量为后者的1.5倍,且前者在较长的发酵时间内VFAs含量维持恒定.分析两种方式能促进污泥水解酸化的原因得到:未灭菌发酵污泥的投加是向系统中引入了一定量的产酸菌,灭菌发酵污泥的投加引入了大量的较易水解的有机底物.水解产物的增加能在更大程度上影响产酸的效果.因此,中温条件下向污泥碱性发酵系统中投加经灭菌处理后的发酵污泥是提高剩余污泥发酵产酸量更为有效的方式.     

羟基磷灰石-四氧化三铁-沸石复合材料制备及去除水中刚果红研究

采用可溶性磷酸盐、钙离子、二价铁离子、三价铁离子和天然沸石等材料制备了羟基磷灰石-四氧化三铁-沸石(HAPFe3O4-沸石)复合材料,对该复合材料进行了表征,并考察了该复合材料对水中刚果红的吸附作用.结果表明,HAP-Fe3O4-沸石复合材料对水中的刚果红具备良好的吸附能力.当pH由3增加到4或由7增加到11时,HAP-Fe3O4-沸石复合材料对水中刚果红的去除能力下降;当pH由4增加到7时,对刚果红的吸附能力基本保持不变.HAP-Fe3O4-沸石复合材料对水中刚果红的去除率随吸附剂投加量的增加而增加,而对水中刚果红的单位吸附量则随吸附剂投加量的增加而降低.HAP-Fe3O4-沸石复合材料对水中刚果红的吸附动力学过程可以较好地采用准二级动力学模型加以描述,对刚果红的吸附平衡数据可以采用Langmuir和Freundlich等温吸附模型加以描述.根据Langmuir模型确定的最大吸附容量为117 mg·g-1.(pH 7和303 K).HAP-Fe3O4-沸石复合材料对水中刚果红的吸附是自发吸热并伴随熵增加的过程.当pH为7时,HAP-Fe3O4-沸石复合材料吸附水中刚果红的主要机制包括表面配位作用、氢键作用以及路易斯酸碱反应.采用热再生的方法可以使吸附刚果红后的HAP-Fe3O4-沸石复合材料得到再生,热再生后的复合材料可以循环使用并且对水中刚果红的吸附性能良好.X射线衍射分析结果表明HAP-Fe3O4-沸石复合材料含Fe3O4,磁滞回线结果表明HAP-Fe3O4-沸石复合材料具备较高的磁饱和强度,复合材料吸附刚果红后可以很容易地通过外加磁场的作用快速地与水溶液分离.结果表明,HAP-Fe3O4-沸石复合材料适合作为一种吸附剂去除废水中的刚果红.     

天津市夏季蜂窝状溶蚀器涂层溶液浓度确定的实验研究

于2013年7月1日～8月31日,在天津市南开大学理化楼楼顶,采用蜂窝状溶蚀器进行了溶蚀器涂层溶液最适浓度的探究实验.结果表明,在天津夏季,蜂窝状溶蚀器的碳酸钠涂层溶液最适浓度为3%,柠檬酸涂层溶液最适浓度为6%.含有溶蚀器系统的颗粒物采样法与传统采样法对比发现,含蜂窝状溶蚀器的采样系统所得到的PM2.5样品浓度有86%低于传统方法所得到的PM2.5样品浓度,其原因主要为1酸/碱性气体被去除,使其无法与富集在采样膜上的颗粒物发生反应,也无法吸附到颗粒物上;2溶蚀器系统采样过程中,部分颗粒物被捕集到溶蚀器上;3酸/碱性气体被去除,导致气-粒平衡被打破,部分颗粒物组分向气态转化.     

有机无机缓释复合肥对不同土壤微生物群落结构的影响

缓控释肥料作为一类新型肥料已成为近年来的研究热点,但对土壤微生物群落多样性影响规律的研究甚少.研究采用磷脂脂肪酸法分析缓释复合肥(SRF)、化肥(CF)和普通复合肥(CCF)分别施入酸性土和微碱性土恒温培养10、30、60和90d后的微生物群落结构多样性.结果表明,缓释复合肥等肥料施入2种土壤恒温培养(10~90 d)后检测到多种细菌(13:0,i14:0,14:0,i15:0,a15:0,i16:0,16:12OH,16:1w5c,16:0,i17:0,a17:0,cy17:0,17:02OH,i18:0,18:0,cy19:0w8c),2种放线菌(10Me17:0和10Me18:0)和1种真菌(18:1w9c).SRF在酸性土壤培养前期(10 d和30 d)较CF显著增加真菌PLFA含量8.3%和6.8%,在培养后期(60 d和90 d)较CCF显著增加真菌PLFA含量22.7%和17.1%;SRF较CF和CCF显著增加微碱性土壤在整个恒温培养期(30 d除外)土壤细菌、真菌和革兰氏阳性菌PLFA含量.酸性土壤培养30 d和90 d时一般饱和脂肪酸/单烯不饱和脂肪酸PLFA值以SRF显著高于不施肥(CK)、CF和CCF,而在微碱性土壤上SRF仅在恒温培养60d时显著高于CK、CF和CCF;SRF较CCF显著降低酸性土壤(30~90 d)和微碱性土壤(10~60 d)异构PLFA/反异构PLFA值.从2种土壤PLFA种类、含量以及相对丰度等可知缓释复合肥较化肥和普通复合肥提高了土壤微生物PLFA种类和含量以及减弱对微生物生存环境的胁迫,缓释复合肥在2种土壤中尤其对酸性土的作用明显.通过研究缓释复合肥对土壤微生物群落结构多样性的影响,以期为农业生产上广泛施用缓释复合肥提供科学依据.     

常规金属离子对Fe3O4磁性纳米颗粒悬浮和沉降的影响

水体中的有机质、无机盐及酸碱度是影响纳米材料迁移转化的主要因素.考察了Na~+、Mg~(2+)、Ca~(2+)、Sr~(2+)和Ba~(2+)对Fe_3O_4磁性纳米材料(Magnetic Nanoparticles,MNPs)的沉降作用.结果表明,Fe_3O_4MNPs的沉降作用是水体pH、金属离子化合价、离子强度共同影响的结果.整体上,碱土金属离子较Na~+更能加速Fe_3O_4MNPs的沉降.当pH为5.0时,浓度低于1.0 mmol·L~(-1)的Na~+、Mg~(2+)和Ca~(2+)有助于Fe_3O_4MNPs的悬浮;当浓度大于1.0 mmol·L~(-1)时,较强的离子强度促使Fe_3O_4MNPs团聚,发生沉降.当pH为9.0时,碱土金属离子较Na~+更能促使Fe_3O_4MNPs聚沉.因此,纳米颗粒在水体中的扩散和聚沉需要综合考虑金属离子种类和浓度.