UASB反应器反硝化处理工业废水

采用絮状污泥成功启动升流式厌氧污泥床(UASB)反应器处理含甲酸、苯胺、环已酮、NO3-等的工业废水。UASB反应器以低负荷启动,10天后逐渐提高进水COD,出水COD保持在710~770 mg/L,COD去除率为40%~60%;出水TOC保持在115~314 mg/L,TOC去除率由60.3%逐渐升高至87.2%,最终维持在81%左右;出水中ρ(NO3-)维持在134~176 mg/L,NO3-去除率为90%左右,系统稳定后NO3-去除率几乎为100%。在进水COD容积负荷不超过5.00 kg/(m3·d)的条件下,实际COD容积负荷稳定在2.00 kg/(m3·d)左右,实际TOC容积负荷稳定在1.00 kg/(m3·d)以上。当进水COD容积负荷不大于4.48 kg/(m3·d)时,COD去除率为55%~74%,TOC去除率为63%~87%,NO3-去除率大于95%。     

染化废水厌氧生物处理技术的研究

鉴于厌氧微生物对偶氮染料的还原裂解作用，开发了以易降解工业有机废水作为外加碳源的染化废水厌氧生物处理的新技术．试验结果表明：在进水ＣＯＤ３１００—３５００ｍｇ／Ｌ，ＣＯＤ总／ＣＯＤ染化比值４０，ＨＲＴ３．０ｄ下，ＣＯＤ去除率＞８０％，最低染化ＣＯＤ去除率＞４５％，色度去除率＞８５％；实验证实，在厌氧处理过程中，染料组分的结构已发生了明显的变化；反应器内的污泥大多呈颗粒状；污泥活性和工艺性能可控制工艺运行参数得以维持．     

Enhancement of thermophilic anaerobic digestion of thickened waste activated sludge by combined microwave and alkaline pretreatment

Pretreatment of thickened waste activated sludge (TWAS) by combined microwave and alkaline pretreatment (MAP) was studied to improve thermophilic anaerobic digestion efficiency. Uniform design was applied to determine the combination of target temperature (110–210°C), microwave holding time (1–51 min), and NaOH dose (0–2.5 g NaOH/g suspended solids (SS)) in terms of their effect on volatile suspended solids (VSS) solubilization. Maximum solubilization ratio (85.1%) of VSS was observed at 210°C with 0.2 g-NaOH/g-SS and 35 min holding time. The effects of 12 different pretreatment methods were investigated in 28 thermophilic batch reactors by monitoring cumulative methane production (CMP). Improvements in methane production in the TWAS were directly related to the microwave and alkaline pretreatment of the sludge. The highest CMP was a 27% improvement over the control. In spite of the increase in soluble chemical oxygen demand concentration and the decrease in dewaterability of digested sludge, a semi-continuous thermophilic reactor fed with pretreated TWAS without neutralization (at 170°C with 1 min holding time and 0.05 g NaOH/g SS) was stable and functioned well, with volatile solid (VS) and total chemical oxygen demand (TCOD) reductions of 28% and 18%, respectively, which were higher than those of the control system. Additionally, methane yields (L@STP/g-CODadded, at standard temperature and pressure (STP) conditions of 0°C and 101.325 kPa) and (L@STP/g VSadded) increased by 17% and 13%, respectively, compared to the control reactor.     

初始pH对厌氧环境下污泥中抗生素抗性基因行为特征的影响

污水处理厂产生大量的剩余污泥中含有丰富的抗性基因,给环境带来了潜在风险。以城市污水处理厂的剩余污泥为研究对象,在不同初始p H(对照组、初始p H=3、5、7、9、11)下观察厌氧条件下,8种抗生素浓度以及四环素类抗性基因(tet A、tet G、tet L、tet M、tet O、tet Q、tet W、tet X)、磺胺类抗性基因(sul I、sul II)和Ⅰ类整合子(int I 1)的行为特征。研究结果显示,初始p H对抗生素的降解影响较小,污泥中总抗生素的平均去除率为42%。对照组及初始p H为3、5、7、9、11下的总四环素类抗性基因分别削减0.65 log、0.96 log、0.75 log、0.62 log、0.86 log和0.98 log。不同四环素类抗性基因表现相似,在初始p H=3和初始p H=11下部分抗性基因削减较多,特别是tet A、tet G、tet L、tet O和tet X。2种磺胺类抗性基因均无削减,浓度平均上升0.18log。相关性分析显示,总抗性基因与TN、NH3-N、TP、SCOD(溶解性COD)均存在显著相关性(P0.05)。上述研究结果为污泥厌氧消化中抗生素抗性基因减量条件提供参考依据。     

四环素类抗生素和铜复合污染对猪粪厌氧消化的影响

兽用抗生素和矿物元素添加剂可起到预防动物疾病、促进动物生长、提高饲料转化率等作用,因此被广泛应用于畜禽养殖业。本研究以猪粪中温厌氧消化为研究目标,采用全自动甲烷潜势测试系统,考察了一定浓度的四环素(TC:30 mg·kg~(-1)dry weight,DW)、土霉素(OTC:50 mg·kg~(-1)DW)和金霉素(CTC:15 mg·kg~(-1)DW)对厌氧累积产甲烷量和日产甲烷速率的影响。结果表明,TC、OTC和CTC对猪粪中温厌氧消化累积产甲烷量和日产甲烷速率均有促进作用(累积产甲烷总量提高比例分别为7.9%、0.4%和5.4%)。另外,采用超高效液相色谱-四极杆串联质谱对猪粪厌氧消化前后样品中四环素类抗生素及其代谢产物进行了分析。结果表明,液相中的四环素类抗生素在猪粪厌氧消化过程中得到了明显的去除,去除率达到90%~100%;而固相中只有金霉素和差向异构金霉素有明显的去除效果,去除率分别为41.69%和41.58%。采用Tessier连续提取法对猪粪厌氧消化前后样品中5种形态的铜包括可交换态、碳酸盐结合态、铁锰氧化结合态、有机物结合态、残渣态进行了分析,结果表明,猪粪厌氧消化后,可交换态、碳酸盐结合态和铁锰结合态的铜浓度比厌氧消化前分别降低了1%~9%、0.1%~3%、12%~19%,而有机态和残渣态的铜浓度却在厌氧消化后分别增加了15%~35%、1%~2%。厌氧消化后,70%~80%的铜都是以有机铜的形态存在。铜逐渐从不稳定态转化为相对稳定的有机态和残渣态铜,因此,厌氧消化过程使铜从可生物利用态转变为不可生物利用态,趋于稳定化。     

智能化控制SBBR处理不同C/N城市污水脱氮除磷性能研究

采用自主研发的智能化控制系统,以智能化控制的运行方式使序批式生物膜反应器(SBBR)形成交替运行的好氧-缺氧环境,对不同C/N人工模拟城市污水进行了脱氮磷实验研究.该实验中控制反应器内水温为25℃±1℃,曝气量为150 L/h,进水COD浓度为300 mg/L、TP浓度为5 mg/L,以TN浓度为30、60、90 mg...     

餐厨垃圾和剩余污泥厌氧混合发酵过程的动态膜强化特性研究

比较了厌氧动态膜生物反应器（DMBR）与完全混合式反应器（CSTR）在处理餐厨垃圾（FW）和剩余污泥（WAS）时的发酵产气过程,验证了高负荷餐厨垃圾和剩余污泥混合发酵时DMBR系统运行的稳定性,考察了动态膜（DM）基材孔径（300目、200目和100目）对DMBR运行性能及其固液分离效果的影响.结果表明：一体式DMBR能够强化餐厨垃圾和剩余污泥混合发酵的高负荷稳定运行,DMBR过膜滤液中平均总挥发性脂肪酸（TVFA）为86.1 mg·L^-1,低于CSTR排泥中TVFA的浓度（527.3 mg·L^-1）.当动态膜基材孔径为300目时,DMBR过膜滤液中总有机物（TCOD）为（1.6±1.1）g·L^-1,相应的固液分离效果优于200目（（3.2±1.9）g·L^-1）和100目（（32.0±1.3）g·L^-1）动态膜基材,即当动态膜基材孔径为100目时,DMBR过膜滤液中TCOD比300目动态膜基材高6.7倍.与200目动态膜基材孔径相比,300目动态膜基材相应的跨膜压差增长缓慢,反洗频率和运行能耗均较低,而100目动态膜基材孔径过大,固液分离效果较低.因此,在高负荷餐厨垃圾和剩余污泥混合发酵系统中,选用300目动态膜基材形成的动态膜过滤效果最优.此外,本文还对比分析了有机废物和废水处理领域中较优的动态膜基材孔径及DMBR的应用情况,为拓展DMBR在有机物处理领域的应用提供依据.     

Degradation of polyacrylamide (PAM) and methane production by mesophilic and thermophilic anaerobic digestion: Effect of temperature and concentration

• PAM degradation in thermophilic AD in comparison with mesophilic AD. • PAM degradation and its impact on thermophilic and mesophilic AD. • Enhanced methane yield in presence of PAM during thermophilic and mesophilic AD. • PAM degradation and microbial community analysis in thermophilic and mesophilic AD. Polyacrylamide (PAM) is generally employed in wastewater treatment processes such as sludge dewatering and therefore exists in the sludge. Furthermore, it degrades slowly and can deteriorate methane yield during anaerobic digestion (AD). The impact or fate of PAM in AD under thermophilic conditions is still unclear. This study mainly focuses on PAM degradation and enhanced methane production from PAM-added sludge during 15 days of thermophilic (55°C) AD compared to mesophilic (35°C) AD. Sludge and PAM dose from 10 to 50 g/kg TSS were used. The results showed that PAM degraded by 76% to 78% with acrylamide (AM) content of 0.2 to 3.3 mg/L in thermophilic AD. However, it degraded only 27% to 30% with AM content of 0.5 to 7.2 mg/L in mesophilic AD. The methane yield was almost 230 to 238.4 mL/g VSS on the 8th day in thermophilic AD but was 115.2 to 128.6 mL/g VSS in mesophilic AD. Mechanism investigation revealed that thermophilic AD with continuous stirring not only enhanced PAM degradation but also boosted the organics release from the sludge with added PAM and gave higher methane yield than mesophilic AD.     

易腐有机垃圾单级高固体厌氧消化实验研究

在中温(35～37℃)条件下,对连续式单级高固体厌氧消化反应器处理易腐有机垃圾进行了试验研究,连续试验时间达半年以上.结果表明,系统稳定运行时,在进料TS为24.79%、VS为23.06%的情况下,单位体积反应器产气效率最高达到3.69L/(L·d),易腐有机垃圾的产气能力(以VS计)为746.33 L/kg,有机负荷(以VS计)达到4.94 kg/(m3·d),水力停留时间47 d,此时期处理效果理想;试验启动之初易发生酸化,其抑制情况严重,出现0产气,经碱性溶液调节后情况得到较好解决;反应进行至80 d后产气速率降至最高速率的一半以下,推断是氨氮浓度超过2000mg/L而产生氨氮抑制,经过投加化学药剂和调节进料C/N抑制情况得到缓解.     

Nitrogen-retaining property of compost in an aerobic thermophilic composting reactor for the sanitary disposal of human feces

Aerobic composting is a method for the sanitary disposal of human feces as is used in bio-toilet systems. As the products of composting can be utilized as a fertilizer, it would be beneficial if the composting conditions could be more precisely controlled for the retention of fecal nitrogen as long as possible in the compost. In this study, batch experiments were conducted using a closed aerobic thermophilic composting reactor with sawdust as the bulk matrix to simulate the condition of a bio-toilet for the sanitary disposal of human feces. Attention was paid to the characteristics of nitrogen transformation. Under the controlled conditions of temperature at 60°C, moisture content at 60%,anda continuous air supply, more than 70% fecal organic removal was obtained, while merely 17% fecal nitrogen loss was observed over a two-week composting period. The nitrogen loss was found to occur mainly in the first 24 h with the rapid depletion of inorganic nitrogen but with an almost unchanged organic nitrogen content. The fecal NH₄-N which was the main component of the inorganic nitrogen ( > 90%) decreased rapidly in the first day, decreased at a slower rate over the following days, and finally disappeared entirely. The depletion of NH₄-N was accompanied by the accumulation of NH₃ gas in the ammonia absorber connected to the reactor. A mass balance between the exhausted NH₃ gas and the fecal NH₄-N content in the first 24 hours indicated that the conversion of ammonium into gaseous ammonia was the main reason for nitrogen loss. Thermophilic composting could be considered as a way to keep a high organic nitrogen content in the compost for better utilization as a fertilizer.