CaCl2高温热处理垃圾焚烧飞灰中重金属的挥发特性

以深圳市某垃圾焚烧厂飞灰为原料,采用高温管式电阻炉,研究了在0．6L／minN,气氛下,CaCl2在不同添加量、处理温度及处理时间下对飞灰中重金属Pb、Cd、Zn和Cu挥发特性的影响,并对收集到的二次飞灰进行成分及物相分析。结果显示,X射线衍射仪和EDS分析表明,二次飞灰主要是由NaCl、KCl和部分SiCl4组成,zn主要以K2ZnCl4形式挥发,而Pb则主要以氧化物PbO和Pb3SiO5的形式挥发。最终得到CaCl2热处理飞灰的最佳二次气化条件：以0．6L／minN,为载气,添加14wt％的CaCl2,在1100℃高温下处理2．5h。经CaCl2热处理后的剩余飞灰,其浸出毒性达到了《生活垃圾填埋场污染控制标准》要求。     

改性油页岩灰渣对水中DNBP吸附去除效果

采用PDMDAAC改性方法对油页岩灰渣进行改性,确定最佳改性方案,并研究了环境因素对改性油页岩灰渣吸附DNBP的影响。实验研究结果表明,油页岩灰渣经20 g/L 的PDMDAAC处理时,对DNBP的吸附能力最强。在吸附温度为30℃,初始溶液pH值为4的条件下,0.3 g 的改性油页岩灰渣对30.0 mg/L DNBP溶液50 mL,吸附120 min时,其吸附率达到94.48%以上。在实验条件下,改性油页岩灰渣对DNBP的吸附符合Langmuir和Freundlich等温吸附方程,相关系数分别为0.9985和0.9776,其对DNBP的理论饱和吸附量达到6.196 mg/g。改性油页岩灰渣对DNBP的吸附主要归因于离子交换和表面吸附作用。     

CaCl2高温热处理垃圾焚烧飞灰中重金属的挥发特性

以深圳市某垃圾焚烧厂飞灰为原料,采用高温管式电阻炉,研究了在0.6 L/min N₂气氛下,CaCl₂在不同添加量、处理温度及处理时间下对飞灰中重金属Pb、Cd、Zn和Cu挥发特性的影响,并对收集到的二次飞灰进行成分及物相分析。结果显示,X射线衍射仪和EDS分析表明,二次飞灰主要是由NaCl、KCl和部分SiCl₄组成,Zn主要以K₂ZnCl₄形式挥发,而Pb则主要以氧化物PbO和Pb₃SiO₅的形式挥发。最终得到CaCl₂热处理飞灰的最佳二次气化条件:以0.6 L/min N₂为载气,添加14 wt%的CaCl₂,在1 100℃高温下处理2.5 h。经CaCl₂热处理后的剩余飞灰,其浸出毒性达到了《生活垃圾填埋场污染控制标准》要求。     

粉煤灰沸石负载Ce^3＋／TiO2光催化降解水中的菲和荧蒽

以钛酸四丁酯为前驱体,粉煤灰合成沸石为载体,采用溶胶-凝胶方法,在低温条件下制备了稀土铈掺杂的TiO2光催化剂。利用SEM—EDS、XRD、FTIR对催化剂进行了分析和表征。以高压汞灯为灯源,对多环芳烃菲、荧蒽的降解进行了研究。实验考查了稀土铈掺杂质量分数、催化剂用量、溶液pH、目标物初始质量浓度等因素对光催化降解的影响,研究了其光降解动力学。结果表明,当稀土铈含量为0．5％,催化剂用量为3g／L,pH偏碱性时,催化效果最佳。光催化反应符合Langmuir—Hinshelwood动力学规律,菲、荧蒽的降解过程符合一级反应动力学,反应速率常数分别为0．0126min^-1,0．0099min^-1。     

化学絮凝-吸附预处理垃圾填埋场渗滤液试验研究

为改进现有二滩库区垃圾处理填埋场垃圾渗滤液处理工艺,研究絮凝—吸附法预处理工艺,试验以聚合氯化铝作为絮凝剂,最佳投放量为600mg/L,以粉煤灰作为吸附剂,最佳投放量为200g/L。结果表明:CODcr去除率达到79.64%;NH3-N去除率达到83.23%;悬浮物去除率达到58.75%;色度去除率达到92.56%;重金属离子去除率为60.37%～96.33%;研究证明:渗滤液经预处理后可以与城市生活污水合并处理。     

污泥厌氧消化液中碳酸盐对回收磷的影响

为探讨污泥厌氧消化液中碳酸盐对以磷酸钙盐形式回收磷的影响,以粉煤灰浸出液为钙源,考察了消化液中的碳酸盐对磷回收过程和磷回收产物性质的影响。实验结果表明,在反应pH为10、反应钙磷摩尔比为1.67、反应时间为10 m in的条件下,消化液碳酸盐浓度为2 400 mg/L(以CaCO3计)时,磷的回收率为78.53%,回收产物中磷含量(以P2O5计)为28.93%;对消化液进行盐酸预酸化使pH达到4及以下时,磷回收率接近100%,回收产物中磷含量(以P2O5计)达到43.08%。消化液中碳酸盐的存在易形成碳酸钙沉淀,从而降低了磷回收率、回收产物中磷含量以及回收产品的纯度;预酸化能够有效地去除消化液中的碳酸盐并降低了其对磷回收的不利影响。     

旋风除尘器流场及浓度场实验与模拟

在研究旋风除尘器内气固两相的运动状况及分离机理方面,计算机模拟替代部分实验的方法能够优化设计旋风除尘器结构参数,提高其对微细颗粒的捕集效率,减少运行压力损失。本研究采用RSM模型和随机轨道模型对旋风除尘器内流场及浓度场进行模拟及实验。研究表明,旋风除尘器压力损失模拟结果与实验结果吻合较好,对于大于5μm的颗粒其捕集效率模拟结果与实验结果基本吻合;旋风除尘器外壁的颗粒浓度呈螺旋带状分布;如将排气管管径减少至原直径0.8倍,可使其对2μm颗粒捕集效率提高6.6%,但压力损失提高36.5%;颗粒的凝并作用有利于提高旋风除尘器微细颗粒的捕集效率。     

烧结烟气脱硫剂性能的研究

为了提高脱硫效率和合理利用烧结过程中产生的机头灰,在半干法烟气脱硫剂生石灰中,加入一定量的烧结机头灰作为脱硫催化剂。在测定机头灰与生石灰化学成分、粒度和比表面积的基础上,研究和分析了机头灰与生石灰的质量配比对于脱硫效率的影响。结果表明,脱硫剂与机头灰在粒径分布和比表面积上都较接近,但经过消化活化后的混合脱硫剂的比表面积明显增大。当机头灰添加量为脱硫剂质量的2%～5%时,脱硫效率提高了2%～3%。机头灰与生石灰的胶凝反应以及机头灰中Fe2O3的催化作用是主要的作用机理。     

Modeling batch leaching behavior of arsenic and selenium from bituminous coal fly ashes

Correctly predicting the leaching potential of arsenic (As) and selenium (Se) is critical for assessing the environmental impact of coal fly ash. This study investigated the impacts of several key environmental factors, including pH, leaching time, and ash washing on the batch leaching behavior of As and Se from bituminous coal fly ashes. The experimental results demonstrated that As and Se leaching from fly ash increased beyond the minimal leaching pH ranges. Increasing leaching time increased As leaching but decreased Se leaching in the alkaline pH condition. A speciation-based adsorption model was used to quantify the batch leaching data, and determine the intrinsic leaching parameters including the total batch leachable mass and the adsorption constant of As or Se. The modeling approach was validated by correctly predicting the independent batch leaching data in a broad pH range and a different L/S condition. Experimental and modeling results also demonstrated that ash washing and ash aging (longer leaching time) did not change the adsorption constants of As and Se on the ash surface. However, ash washing could increase the availability of As and Se for leaching.     

Influence of arbuscular mycorrhizal fungi on the growth and nutrient status of bermudagrass grown in alkaline bauxite processing residue

A nursery experiment was conducted to evaluate the potential role of arbuscular mycorrhizal (AM) fungi in encouraging the vegetation cover on bauxite residue (red mud) sites. An alkali tolerant bermudagrass (Cynodon dactylon) adapted to local conditions were grown in red mud with different amendments with and without AM fungi to assess mycorrhizal effects on plant growth, mineral nutrition, metal uptake and neutralization of bauxite residue. Inoculation of AM fungi significantly increased the plant growth, nutrient uptake and reduced Fe, Al accumulation in plant tissue and also improved the soil physico-chemical and biochemical properties. Gypsum and sludge amended treatments inoculated with AM fungi had maximum biomass, nutrient uptake and reduced accumulation of metals. The neutralization of red mud was significant in presence of AM fungi than control. The experiment provided evidence for the potential use of bermudagrass in combination with AM fungi for ecological restoration of bauxite residue sites.