煤气负压管道裂纹的修补

介绍了河南天宏焦化公司采用可赛新金属修补系列产品,对煤气负压管道裂纹进行修补,取得了良好效果,避免了煤气负压管道普通焊补作业的危险性和停机检修对生产造成的诸多不利因素,实现了煤气负压管道补漏作业的安全高效.同时,对可赛新金属修补系列产品的技术性能作了介绍.     

FTA和FMECA综合法对常压炉的风险分析

首先对炼油厂的常压炉系统进行了火灾爆炸事故的FTA分析,在此基础上进行了深入的FMECA分析,绘制出分析表格,并提出将这两种方法结合起来应用的优点以及一般步骤.综合两种分析方法深入分析了引起火灾爆炸事故的原因,指出系统运行的潜在危险因素,根据分析结果提出综合性的安全改进和预防措施.     

Three-fluid retention in porous media involving water, PCE and air

A classical way to obtain three-fluid retention curves in porous media from measured two-fluid retention curves is based on the Leverett concept, which states that the total volumetric liquid content in a water-wet porous medium, containing water, a nonaqueous-phase liquid (NAPL) and air, is a function of the capillary pressure across the interface between the continuous NAPL and air. This functional relationship results from the assumed condition that in a three-fluid porous medium, the intermediate wetting fluid spreads over the water-air interface. Application of Leverett's concept may not be valid, however, for nonspreading NAPLs like perchloroethylene (PCE). This paper discusses measurements of both PCE-air and water-PCE-air retention curves using a long vertical column in conjunction with a dual-energy gamma radiation system. The data indicate that the Leverett concept was applicable only until a critical PCE saturation had been reached.     

Vapour pressures, aqueous solubility, Henry's law constants and air/water partition coefficients of 1,8-dichlorooctane and 1,8-dibromooctane

New data on the vapour pressures and aqueous solubility of 1,8-dichlorooctane and 1,8-dibromooctane are reported as a function of temperature between 20 °C and 80 °C and 1 °C and 40 °C, respectively. For the vapour pressures, a static method was used during the measurements which have an estimated uncertainty between 3% and 5%. The aqueous solubilities were determined using a dynamic saturation column method and the values are accurate to within ±10%. 1,8-Dichlorooctane is more volatile than 1,8-dibromooctane in the temperature range covered (p_sat varies from 3 to 250 Pa and from 0.53 to 62 Pa, respectively) and is also approximately three times more soluble in water (mole fraction solubilities at 25 °C of 5.95 × 10⁻⁷ and 1.92 × 10⁻⁷, respectively). A combination of the two sets of data allowed the calculation of the Henry’s law constants and the air water partition coefficients. A simple group contribution concept was used to rationalize the data obtained.     

受限空间内惰性气体对CH4爆炸抑制特性研究

N2和CO2是常用的惰性抑爆气体,为研究两种气体的抑爆特性,采用20L球形爆炸试验装置,分析了不同浓度配比条件下N2/CH4/空气以及CO2/CH4/空气混合气体的爆炸压力,同时采集爆炸后的气体样品,对比分析爆炸后残留气体的主要成分。结果显示:随CH4浓度从5%增加至12.5%时,完全抑制CH4爆炸需要的惰性气体最小量先增大后降低,CH4浓度在6.5%~7.5%之间时,抑爆需要的惰性气体的量最大;在同一CH4浓度条件下,抑爆需要N2的量大于CO2,并且CH4浓度在5%~6.5%时,抑爆需要两种惰性气体的量值差别最大;当CH4浓度一定时,随着加入惰性气体量的增大,爆炸最大超压逐渐降低,惰性气体浓度和爆炸超压之间基本呈线性关系;在同样条件下,相对于N2,CO2为抑爆气体时,爆炸后腔体内残留的CH4浓度较高。研究成果为惰性气体抑爆技术提供技术支撑,同时为揭示惰性气体抑爆机理有一定作用。     

页岩气加砂压裂高压管汇失效爆裂风险 控制措施研究与实践

随着页岩气平台井工厂化压裂施工启动,在大排量、高压力、长时间施工条件下,高压管汇失效爆裂大幅增加。为减少高压管汇在压裂过程中失效爆裂风险,运用故障假设、因果分析法从人的因素、物的因素、技术工艺、生产管理、工作环境5个方面分析事故的原因,提出了提升采购产品质量、修订完善高压管汇使用技术规范和管理制度、实施专业化管理、应用大数据管理高压管汇、优化现场地面高压管汇流程分配布局设计与联接工艺等高压管汇失效爆裂风险预防控制措施和失效后应急安全防护措施,建立了生命周期全过程、专业化的高压管汇失效爆裂防控与应急防护体系,实现风险可防受控。为页岩气压裂作业的安全提供了参考。     

火电厂烟气排放对广州大气环境的影响

广州市是酸雨、可吸入颗粒物污染严重的地区之一,这与其能源结构以煤为主有关.广州发电厂以燃煤为主,其周围大气采样数据分析显示燃煤电厂可对周围大气环境造成较大影响,是酸雨前体物、可吸入颗粒物的主要排放源.酸雨破坏了生态环境,也阻碍了经济的发展;燃煤排放的烟尘细颗粒物属于可吸入颗粒物,其上附着的As、Cr等微量元素多为致癌物质和致基因毒性诱变物质,对周围居民的健康危害极大.最后, 对当前的环境保护工作及存在的问题进行了阐述.     

Ⅱ824-2综放工作面瓦斯综合治理试验研究

通过对淮北芦岭矿Ⅱ824-2综放工作面瓦斯综合治理的试验研究,摸索出了高瓦斯综放工作面瓦斯治理的有效方法,取得了较好的瓦斯抽放和通风排放效果.     

Trends of air pollution in the Fichtelgebirge Mountains, Bavaria

We analyzed 13 years of hourly measurements of SO₂, NO_x, and O₃, at forest ecosystem research sites in SE Germany. A quasi-continuous data record was obtained by combining data sets from two locations. Before interpreting trends in the combined data set, we analyzed if the change of location introduced a systematic bias. We employed autocorrelation functions, Hurst statistics, complexity analysis, and recurrence quantification and found that the partial data sets exhibited no indication of the presence of any bias. For SO₂, we also compared the data from the forest sites with data obtained in nearby cities and also found no indications for any systematic effects. Applying nonparametric trend statistics we found a significant decrease of the SO₂. Most of the observed decrease is due to the reductions of SO₂ emissions in eastern Germany, but reductions in western Germany and the Czech Republic also played important roles. For O₃, we observed a significant increase, the causes of which are unclear from our data alone. No trend was identified for NO_x.     

液体旋流分离器分离效率的研究

液体旋流分离器是水环境污染治理的主要设备之一.分离效率是衡量液体旋流分离器分离过程进行完善程度的最重要的技术指标,它能从质与量两方面反映出设备性能的优劣.当前液体旋流分离器设计过程还缺少具体量化的理论依据,为了给液体旋流分离器的设计提供理论依据,通过液体旋流分离器从水中分离固体粒子的性能实验,得出了液体旋流分离器各部结构尺寸、形状、相对比例对分离效率的不同影响程度,提出了结构参数的最佳取值范围.按照本研究提出的设计原则和方法,可以制造出性能优良的液体旋流分离器.