城市生活垃圾机械生物处理效果

采用机械生物处理工艺研究了淋洗水解、脱水与好氧生物干燥对城市生活垃圾的处理效果。结果表明:在淋洗水解及压榨脱水机械生物处理阶段,控制淋洗液与生活垃圾重量比2:1,停留时间1.2~1.4 d条件下,生活垃圾可以减量49.7%。而过程中产生的淋滤液COD为 32 939 mg/L、pH为5.1、COD:N:P=261:5:3.6,可以进行厌氧消化处理或作为碳源进行资源化利用。在好氧生物干燥阶段,通风量采用0.08 m3/min,2~3 d堆体温度可升至73℃,7 d左右即可产出LCV高达15 000 kJ/kg左右的高品位垃圾衍生燃料(RDF),其产率为38.2%,氯元素含量低于0.5%,重金属含量较低,满足燃料要求。     

巢湖低温高效聚磷菌的筛选及其特性

采用低温富集培养及混合平板分离技术,从巢湖底泥中分离筛选得到2株在低温下仍具有较高效能的菌株D3、D6,经过厌氧/好氧交替培养,2种菌株在低温下(8℃)的除磷率均达到80%以上。在低温下,研究了pH、微量元素对2株菌株生长及除磷率的影响,实验结果表明,2株菌都具有广泛的温度适应性,适宜其生长和除磷的pH为中性偏碱,微量元素的缺乏对2株菌株的生长和除磷效果有不同程度的不良影响。染色观察显示,厌氧培养时菌体内聚羟基丁酸(PHB)颗粒明显增多,转为好氧培养后异染颗粒增多,为典型的聚磷菌特征。经鉴定,2株菌均属假单胞菌属。     

300 MW燃煤锅炉机组超细颗粒聚并器的实验研究

为了解决燃煤锅炉烟气中超细颗粒难以脱除的问题,基于流体动力学原理设计了一种超细颗粒聚并器,并在300 MW燃煤锅炉机组电除尘器的前置烟道中进行了实验研究。结果表明,聚并器内部存在超细颗粒之间以及超细颗粒与大颗粒之间的相互聚集行为,从而使超细颗粒数量显著减少。例如,对于粒径在2.65和10.48 μm以下的颗粒,其体积比例在聚并器出口分别减少了56.7%和62.3%,在电除尘器出口的粉尘浓度减少了26.34 mg/Nm3,这表明,基于流体动力学原理的聚并器对超细颗粒的聚并作用明显,具有良好的应用前景。     

人工生物蓄水过滤系统对雨水的滞留与过滤功效

通过人工构建3个不同沙土配比的生物蓄水过滤系统,对人工系统滞留雨水时间和净化雨水的功效进行了研究。首先,根据自然降雨特点将雨水地表径流按照不同水量与进水时间引入系统,然后测定系统出水水量、时间、水质以及土壤湿度,比较植物层和整个系统滞留雨水径流的效果以及系统过滤雨水的功效。结果表明,(1)人工生物蓄水过滤系统有显著的滞留雨水的作用。其中植物层滞留雨水时间4.72~11.50 h,整个系统滞留雨水时间为5.17~13.80 h,人工系统比植物层滞留雨水时间显著延长,且进水量越大,差异越显著。(2)系统出水流速平缓,蒸发与植物蒸腾耗水量比例低于6%;壤土含量越高,滞留雨水时间越长。(3)经系统过滤,系统出水酸碱度平均增加0.81,氨氮含量平均降低0.42 mg/L。     

声凝并联合雾化预处理及其在过滤除尘中的应用

根据声凝并理论和雾化湿式除尘理论,建立了燃煤飞灰在声场联合雾化加湿作为预处理的过滤式除尘实验装置。分别在声场、雾化加湿、声场与雾化加湿相结合3种预处理条件下进行实验,确定合适的加湿量范围,得出不同条件下燃煤飞灰的去除效果。在声场联合雾化加湿条件下,分别研究了声压级和雾化加湿量对飞灰的去除率的影响。结果表明,声场和雾化加湿联合作用能有效提高燃煤PM2.5去除率。以声场联合雾化加湿作为预处理进行过滤除尘实验,结果表明,虽然对高效滤料的除尘效率提高作用有限,但是该预处理可减轻滤袋负荷,有效延缓压差增长,降低清灰频率。由于采用表面覆膜滤材,加湿量控制得当可避免产生"糊袋"现象。     

水华束丝藻与铜绿微囊藻净化水体氮磷及其脂质积累过程比较

选取水华束丝藻与铜绿微囊藻作为典型水华蓝藻,探索水华蓝藻净化水体及合成生物柴油的潜力.采用氮磷浓度为NH4+-N 7.5 mg/L,PO43--P 1.0 mg/L的模拟污水,重点考察了在光照强度与温度不同的条件下2种微藻对氮磷的去除率,并利用尼罗红荧光染色法测定了微藻中的中性脂含量.结果表明,2种藻对PO43--P的去除率均较高,最高达到98%,对NH4+-N的去除率稍低,最高为52%.水华束丝藻及铜绿微囊藻均具有较强积累中性脂的能力,适宜的温度与光照条件有利于微藻对氮磷的去除及细胞中脂类的积累.2种藻均在光照强度为12 000 lx时中性脂含量更高.水华束丝藻在温度为18~22℃条件下,生长更优,氮磷净化效果较好,中性脂积累能力更强.而铜绿微囊藻在温度为22~26℃时表现更好.     

某城市污水处理厂废水化学除磷沉淀特性及影响因素

通过对西安市某污水处理厂进水、厌氧池上清液、二沉池出水、污泥浓缩水、污泥脱水进行FeCI3·6H2O、PAC除磷实验,并以FeCI3·6H2O为沉淀剂对厌氧池上清液从pH、Fe/P摩尔比、腐殖酸、挥发性脂肪酸(VFA)等因素进行批次实验分析磷去除状况.实验显示,三氯化铁、PAC对进水除磷效果不佳,厌氧池上清液用FeCI3·6H2O为沉淀剂时磷去除率较低,二沉池出水、污泥浓缩水以及污泥脱水用FeCI3·6H2O、PAC时其正磷去除率均可达到80%左右.通过对比不同pH值、Fe/P摩尔比、腐殖酸和VFA浓度对厌氧池上清液除磷效果的影响,结果表明,在pH=4~5,Fe/P=1.3时磷的去除效果达到78%以上,腐殖酸浓度对磷去除率影响不大,VFA在低于10 mg/L和高于60 mg/L时对磷去除率影响较大.     

低温碱溶脱除液晶显示器(LCD)玻璃基板粉末中的硅和铝

为了提高氯化法回收LCD中铟的效果,降低SiO2和Al2O3对氯化过程的干扰,采用NaOH对液晶显示器玻璃基板粉末中的硅和铝进行了预先溶出规律研究.首先分析了LCD粉末中SiO2和Al2O3的含量、形貌以及铟的浸出变化,然后计算了SiO2和Al2O3的脱除效率.在条件实验基础上通过正交实验设计得出优化实验条件.研究表明,在液固比为90:2、温度95℃、溶出时间2 h、碱度0.56 g/L的最佳工艺条件下, SiO2的脱除率为80.88%、Al2O3的脱除率为 83.30%、二者总的脱除率为81.30%,洗涤液中没有发现铟的溶出,碱溶后的物料表面产生大量均匀的孔状结构.这将对液晶显示器玻璃基板粉末的资源化与铟的富集有重要意义.     

Effects of Soil Amendments at a Heavy Loading Rate Associated with Cover Crops as Green Manures on the Leaching of Nutrients and Heavy Metals from a Calcareous Soil

The potential risk of groundwater contamination by the excessive leaching of N, P and heavy metals from soils amended at heavy loading rates of biosolids, coal ash, N‐viro soil (1:1 mixture of coal ash and biosolids), yard waste compost and co‐compost (3:7 mixture of biosolids to yard wastes), and by soil incorporation of green manures of sunn hemp (Crotalaria juncea) and sorghum sudangrass (Sorghum bicolor × S. bicolor var. sudanense) was studied by collecting and analyzing leachates from pots of Krome very gravelly loam soil subjected to these treatments. The control consisted of Krome soil without any amendment. The loading rate was 205 g pot^? 1 for each amendment (equivalent to 50 t ha^? 1 of the dry weight), and the amounts of the cover crops incorporated into the soil in the pot were those that had been grown in it. A subtropical vegetable crop, okra (Abelmoschus esculentus L.), was grown after the soil amendments or cover crops had been incorporated into the soil. The results showed that the concentration of NO₃‐N in leachate from biosolids was significantly higher than in leachate from other treatments. The levels of heavy metals found in the leachates from all amended soils were so low, as to suggest these amendments may be used without risk of leaching dangerous amounts of these toxic elements. Nevertheless the level of heavy metals in leachate from coal ash amended soil was substantially greater than in leachates from the other treatments. The leguminous cover crop, sunn hemp, returned into the soil, increased the leachate NO₃‐N and inorganic P concentration significantly compared with the non‐legume, sorghum sudangrass. The results suggest that at heavy loading rates of soil amendments, leaching of NO₃ ^? could be a significant concern by application of biosolids. Leaching of inorganic P can be increased significantly by both co‐compost and biosolids, but decreased by coal ash and N‐viro soil by virtue of improved adsorption. The leguminous cover crop, sunn hemp, when incorporated into the soil, can cause the concentration of NO₃‐N to increase by about 7 fold, and that of inorganic P by about 23% over the non‐legume. Regarding the metals, biosolids, N‐viro soil and coal ash significantly increased Ca and Mg concentrations in leachates. Copper concentration in leachate was increased by application of biosolids, while Fe concentration in leachates was increased by biosolids, coal ash and co‐compost. The concentrations of Zn, Mo and Co in leachate were increased by application of coal ash. The concentrations of heavy metals in leachates were very low and unlikely to be harmful, although they were increased significantly by coal ash application.     

芦苇碳源-表面流人工湿地对农田退水脱氮的长期效能研究

针对农田退水NO₃^--N占比高、C/N低,氮污染难以去除的问题,将经济易得的芦苇(Phragmites australis)茎叶碎段装填在表面流人工湿地(packed surface flow construct wetland,PSFW)的表层作为外加碳源,以研究其长期运行情况下的脱氮效能。结果表明：第29~149天,外加芦苇茎叶碎段的PSFW的脱氮效能明显高于无芦苇茎叶碎段的空白PSFW₀;进水NO₃^--N和TN浓度分别为(16.4±1.0)和(17.7±2.0)mg/L,HRT按3、4和2 d运行时,HRT为4 d时脱氮效能最优,PSFW对NO₃^--N和TN去除率分别为(87.4±6.0)%和(74.1±6.0)%,PSFW₀去除率仅为(14.4±4.0)%和(14.4±3.0)%;第150~269天,PSFW的脱氮效能稍高于PSFW₀,在进水NO₃^--N和TN浓度分别为(10.4±1.0)和(10.8±1.0)mg/L,HRT按3、2和1 d运行时,HRT为3 d时脱氮效能最优,PSFW对NO₃^--N和TN的去除率分别为(91.9±7.0)%和(90.2±7.0)%,PSFW₀去除率分别为(91.3±5.0)%和(86.4±6.0)%。第270~334天,PSFW的脱氮效能稍低于PSFW₀;进水NO₃^--N和TN浓度分别为(5.7±0.4)和(7.2±0.8)mg/L,HRT为3 d时,PSFW对NO₃^--N和TN的去除率分别为(88.6±10.0)%和(82.5±7.0)%,PSFW₀去除率分别为(94.0±6.0)%和(87.8±3.0)%。