用新型絮凝剂处理制浆漂白废水

采用一种新型的有机无机复合型高分子絮凝剂(F-1)处理制浆漂白废水，进行了絮凝条件的优选试验和对比试验，结果表明：F-1絮凝剂的絮凝沉降效果与絮凝剂的用量、废水的pH有很大的关系。当废水的pH为6．0、絮凝剂用量为100mg／L时，漂白废水的色度、SS和COD的去除率分别为98．2％、93．6％和78．6％。而且，其絮凝性能明显优于阳离子聚丙烯酰胺(PAMC)、聚合氯化铝(PAC)以及聚合硫酸铁(PFS)等絮凝剂。     

氯化钡废液联产氢氧化钙和氯化钡

讨论了氯化钡废液联产氢氧化钙及高纯氯化钡的方法和主要影响因素。通过复盐共沉淀、热滤、结晶、精制纯化等工序,用氯化钡的蒸发残液制得了工业级的氢氧化钙和高纯度氯化钡,其纯度分别达95％和99．92％以上。采用有机溶剂析出法精制氯化钡,无需重结晶工序,是对传统工艺的一种改进。     

SBR生物技术处理竹浆造纸黑液的研究

通过循环序间歇式活性污泥法（ＳＢＲ）处理可使经酸析木质素后所得黑液中的ＢＯＤ５和ＣＯＤ显著减少,当进水中ＣＯＤ浓度为１０９０－１１７０ｍｇ／Ｌ时,ＢＯＤ５去除率为７０％－８３％,ＣＯＤ去除率为５４．５％－６３％,出水中ＢＯＤ５和ＣＯＤ的浓度分别为７６－１０１ｍｇ／Ｌ和４１９－５００ｍｇ／Ｌ,内电解与ＳＢＲ联合对黑液的处理更为有效,当进水ＣＯＤ浓度为１０４６－１１００ｍｇ／Ｌ,ＢＯＤ５和ＣＯＤ去除率     

草浆黑液直接碱回收技术的燃烧试验研究

探讨了草浆黑液与赤铁矿流化床燃烧反应机理和工艺参数.通过差热分析得到关联式x/x_0=1-exp(-0.012t),可用于预测草浆黑液在流化床中燃烧时碱回收的转化率.实验表明,草浆黑液碱回收转化率可高达95％以上. ’     

污泥厌氧消化液中碳酸盐对回收磷的影响

为探讨污泥厌氧消化液中碳酸盐对以磷酸钙盐形式回收磷的影响,以粉煤灰浸出液为钙源,考察了消化液中的碳酸盐对磷回收过程和磷回收产物性质的影响。实验结果表明,在反应pH为10、反应钙磷摩尔比为1.67、反应时间为10 m in的条件下,消化液碳酸盐浓度为2 400 mg/L(以CaCO3计)时,磷的回收率为78.53%,回收产物中磷含量(以P2O5计)为28.93%;对消化液进行盐酸预酸化使pH达到4及以下时,磷回收率接近100%,回收产物中磷含量(以P2O5计)达到43.08%。消化液中碳酸盐的存在易形成碳酸钙沉淀,从而降低了磷回收率、回收产物中磷含量以及回收产品的纯度;预酸化能够有效地去除消化液中的碳酸盐并降低了其对磷回收的不利影响。     

Resourceful Utilization of Tannery Wastewater

Leather industry is an important light industry in China.Leather making requires a series of chemical treatment.Degreasing,unhairing and chrome tanning wastewaters are the main portions of tannery wastewater.Reclaiming and reusing these wastewaters can eliminate 80% of COD,75% of BOD,95% of chromium and 93% of sulfuret,furthermore reduce environment impact,decrease treatment costs,save chemicals and water.Some application methods of wastewater reclamation and reuse for different operations were reported.The suitable reclamation and reuse technologies can enable leather making processes more rational,and realize the recovery and recycle of several chemicals in the tannery.Resourceful utilization of tannery wastewater should mate with renovating production technology,updating equipment,and must be guaranteed sufficiently by environmental protection measures.     

乙醇溶析结晶法从白炭黑废母液中回收硫酸钠

以乙醇为溶析剂,通过过滤—中和—蒸馏浓缩—溶析结晶等工序,从白炭黑废母液中回收硫酸钠。考察了硫酸钠回收效果的影响因素,并进行了热能消耗和处理成本的分析。实验结果表明：乙醇的加入量对硫酸钠溶解度和蒸馏浓缩过程有着显著影响;在蒸馏醇水比（乙醇与中性废母液的体积比）为0.27,浓缩废母液中硫酸钠质量浓度为69.27 g/L,溶析醇水比（乙醇与浓缩废母液的体积比）为1的最佳工艺条件下,白炭黑废母液中硫酸钠的一次回收率可达69.94%,硫酸钠产品的纯度达到97.3%。     

Black Disease (Terpios hoshinota): A Probable Cause for the Rapid Coral Mortality at the Northern Reef of Yongxing Island in the South China Sea

The northern reef of Yongxing Island, the largest reef island of the Xisha Islands in the South China Sea, was in good condition with significant cover of scleractinian corals until 2002. Surveys in 2008 and 2010, however, found that coral coverage had declined rapidly and severely, implying that catastrophic coral mortality occurred during the past 8 years. A blackish mat was observed covering live and dead corals in both 2008 and 2010 that was identified as an encrusting sponge, Terpios hoshinota, by special surface morphology and spicule structure. In addition, spicule residues were found on the surface of long-dead corals, indicating a previous invasion of T. hosinota. T. hoshinota is referred to as the "black disease" because it rapidly overgrows and kills corals. Our evidence indicates that outbreaks of black disease are at least partially responsible for the massive coral mortality at the northern reef of Yongxing Island over the past 8 years, although human activities and heat-related coral bleaching cannot be discounted as minor causes for this coral decline.     

草甘膦母液膜分离的电渗析预处理

研究了用电渗析法去除草甘膦母液中影响膜通量的亚磷酸根,主要考察了pH值、工作电压、反应时间和温度等因素对亚磷酸根去除率的影响,并对电渗析预处理后母液纳滤膜分离的膜通量进行实验验证。实验表明：淡化液、浓缩液流量为30 L/h,pH值约为8.1,工作电压为20 V,反应时间为2 h左右,温度〈30℃时,电渗析对母液中亚磷酸...     

许昌市发制品行业的清洁生产调查

发制品行业是以人发、人造纤维等为原材料进行假发加工的行业。许昌市发制品的生产过程大致可分为两个阶段:漂染和前后处理。漂染过程用水量大,产生的废水难以处理。其中过酸、氧化、染色配置的溶液使用一次后直接排放,不符合清洁生产要求,且所排放的溶液可考虑中和多次利用。漂染过程水资源消耗量大,废水产生量大,没有考虑废水综合利用。按清洁生产的要求在以上环节可通过技术革新和设备改造得以改进。