利用农药含钾废渣制备氯化钾

利用热解及钙盐沉淀法对农药含钾废渣进行处理,制得高纯度的KCl.通过管式炉反应器对农药含钾废渣中有机物的去除进行了研究,探讨了升温速率、热解终温、终温保持时间及空气流量对热解过程的影响,并对钙盐沉淀法除氟过程的溶液pH及m(Ca2+)∶m(F-)进行了确定.实验结果表明:当升温速率为20℃/min、热解终温为600℃、终温保持时间为90 min、空气流量为3.0m3/min时,废渣中的有机物完全分解;钙盐沉淀法除氟的最佳条件为溶液pH 8,m(Ca2+)∶m(F-)=3.0,氟离子的去除率达到98％;最终得到KCl的产率为70.6％,产品纯度为98.2％,符合国家Ⅰ级优等品标准.     

氯磺酸的清洁生产工艺

在对氯磺酸原有工艺——低气浓法、高气浓法进行技术分析的基础上,设计建成了氯磺酸生产产量为150t／d的循环吸收合成法生产装置。该工艺的实施,可使排放尾气中污染物的浓度低于国家排放标准,二氧化硫的转化率达到98％,三氧化硫和氯化氢利用率分别比原来提高6％和1．5％,且经济效益与环境效益显著。     

Composition of Aqueous Extracts of Broiler Litter Treated with Aluminum Sulfate,Ferrous Sulfate,Ferric Chloride and Gypsum

More knowledge on the composition of aqueous extracts of broiler litter amended for Water Soluble P (WSP) reduction would help to understand how amendments work. We measured pH, concentrations of Ca, Mg, Fe, Al, Cu, Mn, Zn, Molybdate Reactive P (MRP), and Dissolved Unreactive P (DUP) in water extracts of broiler litter treated with aluminum sulfate (ALS), ferrous sulfate (FES), ferric chloride (FEC), and gypsum (GYP) at 0, 5, 15, and 25% w/w. In order to study the effects of acidification, the same properties were measured in aqueous extracts of broiler litter suspensions that were titrated to end-points 3, 4, or 6 with 0.5N HCl. Concentrations of MRP, DUP, Ca and Mg, were 61%, 53%, 3.8 times, and 2.6 times greater in extracts from suspensions acidified to pH 6 than at the original pH of 8.9. ALS, FES, and FEC reduced pH, and showed similar effects on WSP concentrations, which were greater than with GYP. The magnitude of the reductions in WSP by ALS, FES, and FEC is uncertain because the actual amount of WSP immobilized cannot be determined. This is because of two opposite effects: 1) Through adsorption, soluble aluminum and iron remove phosphates from solution, and 2) Through acidification, iron and aluminum compounds release phosphates to solution.     

Mechanochemical dechlorination of polyvinyl chloride with calcium sulfates

Polyvinyl chloride (PVC) was milled with hydrated or unhydrated calcium sulfates (CaSO₄·2H₂O or CaSO₄) in air by using a planetary mill to investigate mechanochemical dechlorination behavior. The milling process resulted in size reduction and in the breaking of bonds leading to mechanically induced solid state reaction, forming CaCl₂ and dechlorinated hydrocarbon with C=C double bonds in the product. Washing the milled mixtures with water at room temperature allowed removal of the chloride formed during milling, and more than 95% of the chlorine in PVC was removed from a mixture milled for 4 h. This process could offer a potential route for the handling and disposal of both PVC and gypsum wastes. H₂S gas was generated during milling; more H₂S was released from the unhydrated sample than from the hydrated sample.     

高锰酸钾预氧化强化微污染水源水中锰的去除

目前,我国很多地区地表水都存在锰超标问题,这给供水安全带来了极大隐患.本文考察了高锰酸盐预氧化强化水中锰的去除效果.实验结果表明,原水经过高锰酸盐处理后,水中的锰含量明显降低,当高锰酸盐投加量达到0.5mg/L之后,水中的锰离子浓度已经达到了原子吸收检出限以下,但色度有所增加.当高锰酸钾∶硫酸亚铁=1∶4时,水中的锰去除效果较好,色度降低,随着亚铁离子投加比例的增加,水中锰的去除率反而下降.     

散煤运输用膜型抑尘剂的制备及性能研究

采用水溶液聚合法,以氧化淀粉、丙烯酸(AA)、二甲基二烯丙基氯化铵(DMDAAC)为原料,通过接枝共聚制备了一种软膜型抑尘剂(抑尘剂液体干燥后形成具有一定韧性的软膜)。与聚乙烯醇类壳型抑尘剂(干燥后形成很脆的壳层)相比,软膜型抑尘剂提高了煤粉固化层的抗破裂能力。由抗震荡性试验可知,使用膜型抑尘剂后,经过18 h的震荡,煤粉的损失率仅为1.91%,而使用壳型抑尘剂后煤粉的损失率为4.85%。还测定了2种抑尘剂的保湿性和耐破度。利用红外光谱对产物的结构进行了表征,采用SEM观察了该产物在煤粉表面形成的膜层形貌。试验结果表明,散煤运输中膜型抑尘剂在减少煤粉损失和控制扬尘污染方面性能优于壳型抑尘剂。     

Gasification and smelting system using oxygen blowing for plastic waste including polyvinyl chloride

A new type of waste gasification and smelting system using oxygen blowing based on high-temperature metallurgy, was developed by Sumitomo Metals, Japan. This system can steadily gasify and melt not only municipal waste, but also plastic waste and polyvinyl chloride (PVC) waste by using a top-blow oxygen lance together with sideways-blow oxygen lances. As a result of gasification in the high-temperature reducing atmosphere and rapid gas cooling, dioxin-free, high-calorie purified gas was produced. Ash components in the wastes were smelted in a high-temperature reducing atmosphere, and high-quality slag free of heavy metals was produced. Most of the chlorine in the wastes was converted into hydrogen chloride in the off gas. The hydrogen chloride can be recovered as hydrochloric acid or chlorine, which are recyclable to PVC manufacturing.     

氯乙烯储罐的事故后果分析

氯乙烯具有毒性和易燃易爆性,如果泄漏至空气中,可能产生中毒或爆炸事故。笔者以某化工厂氯乙烯储罐为例,分析氯乙烯储罐可能发生的事故;对其主要事故危害,即中毒、蒸气云爆炸、扩展气体沸腾蒸气爆炸3种事故进行后果模型分析;计算出发生3种事故对人员伤亡和设备损坏造成的危害区域,并提出建议和对策。该研究结果可为同类企业进行安全管理提供科学依据和参考,有助于企业制定防范措施以及事故应急救援预案,从而减少人员伤亡及财产损失。     

Effects of Cd~(2+) on the nucleolus in root tip cells of Allium cepa

ＥｆｆｅｃｔｓｏｆＣｄ￣（２＋）ｏｎｔｈｅｎｕｃｌｅｏｌｕｓｉｎｒｏｏｔｔｉｐｃｅｌｌｓｏｆＡｌｌｉｕｍｃｅｐａＪｉａｎｇＷｕｓｈｅｎｇ；ＬｉｕＤｏｎｇｈｕａ（ＤｅｐａｒｔｍｅｎｔｏｆＢｉｏｌｏｇｙ，ＴｉａｎｊｉｎＮｏｒｍａｌＵｎｉｖｅｒｓｉｔｙ，Ｔ...     

从金属切削废料中回收镍和钴生产硫酸镍和氧化钴

以镍钴合金切削废料为原料，通过酸溶、除铁、除铬、镍钴分离等一系列步骤，回收镍和钴，生产硫酸镍和氯化钴，通过试验确定了最佳工艺条件，并对经济效益进行了分析。