利用废弃菜籽油制备炭黑-基于气溶胶气相化学沉积法

利用气溶胶化学气相沉积的方式转化废弃菜籽油制备炭黑。以氮气为载气,将液体废油预先转化成气溶胶颗粒输送至高温管式炉,在 800 ℃ 的条件下进行热分解,形成基于废油的炭黑。产物的形貌、组分和结构采用光学显微镜,拉曼光谱, SEM 和 XPS 等方式进行表征。结果显示,炭黑表面呈阶梯片状叠加结构,而拉曼谱上出现强烈的 D 峰、G 峰及 G' 峰（其中 ID/IG=1.09 ）。根据能谱 C1S 峰显示,炭黑表面化学键主要由 sp2 CC,sp3 C—C,C—OH 和 OC—O— 组成,其中 sp2 占据 88.5%。对比分析原始单晶硅基和负载炭黑表面的润湿性,显示负载炭黑后的硅表面疏水性大幅度提高,与水的接触角从 66.4°增长到 141°,呈现超级疏水性;而油在硅基和炭黑表面的接触角分别为 21.2°和<4°。     

生物炭和脱硫石膏对盐碱土壤基本理化性质及玉米生长的影响

采用玉米室内盆栽实验的方法,研究了内蒙古包头市西部盐碱土壤在施用以玉米秸秆和污泥为原料制备的生物炭、脱硫石膏及其混合物等不同土壤改良剂对土壤基本理化性质及玉米生长的影响。研究结果表明：单独施用生物炭能够显著提高土壤中养分含量,虽然随着玉米的生长,对土壤养分大量吸收,土壤养分略有降低,但土壤养分仍远远高于未经任何处理的盐碱土壤养分含量;单独施加脱硫石膏对降低土壤碱度、盐度有显著效果,施用脱硫石膏后土壤pH呈下降趋势（0~80 d）,pH最多降低了0.74个单位,且脱硫石膏具有较好的脱盐作用,种植玉米后土壤中溶解性盐含量分别降低了22.55%、25.60%、33.74%、44.07%、45.41%。生物炭和脱硫石膏混合物对土壤的影响,既在一定程度上降低了土壤盐、碱度,又提高了土壤中养分含量,且对玉米生长具有促进作用,能提高玉米生物量。     

Biodegradability of Quaternized, Crosslinked Sugarcane Bagasse

Quaternized, crosslinked sugarcane bagasse can adsorb anionic dyes from textile wastewater. Disposal of dye-saturated adsorbent by composting or land application would require that modifications made to the bagasse do not interfere with its decomposition. The impact of quaternization and crosslinking on bagasse biodegradability was examined. Bagasse in varying states of modification was mixed with soil and monitored for carbon dioxide evolution for four weeks at 27°C. After subtracting the amount of carbon evolved from control soil samples, the net carbon evolved from the bagasse samples was determined and used as a measure of their extent of biodegradation. Biodegradability decreased in the order: bagasse (approx. 60% degraded after four weeks) > quaternized bagasse > quaternized, epichlorohydrin-crosslinked bagasse > quaternized, methylene-bis-acrylamide-crosslinked bagasse > epichlorohydrin-crosslinked bagasse (less than 5% degraded). Crosslinking severely impacted biodegration, probably by preventing the penetration of (hemi)cellulytic and lignolytic enzymes into the interior of the modified bagasse particles. It is concluded that the biodegradability of quaternized, crosslinked bagasse is too low for composting or land application.     

重庆城区PM2.5化学组分特征及季节变化

2014年7月-2015年5月典型季节期间在重庆城区选择典型站点开展PM2.5样品采集,并测量质量浓度,分析样品中水溶性离子、无机元素、OC和EC等组分,在此基础上对组分化学组成进行了质量重构。结果表明：观测期间PM2.5年均值为76.4 μg·m-3,浓度季节变化为冬季 > 秋季 > 春季 > 夏季;组分方面,以二次转化为主的SO42-、NH4+、NO3-和OC是PM2.5组分中最主要成分,OC/EC比值4个季度均大于2,表明城区二次有机碳生成显著;硫氧化率（SOR）分析,气态污染物SO2的二次转化效率较高,大气存在明显的二次转化过程。PM2.5质量重构后主要组成为有机气溶胶（OM）、二次无机离子（SNA）和矿物尘,重庆城区应协同控制一次排放的颗粒物和气态污染物SO2和NOx,从而控制二次组分浓度。     

络合吸收结合生物转化去除氮氧化物技术

介绍了络合吸收结合生物转化处理NOx 技术的基本原理和目前的研究进展情况 ,并分析了该技术处理氮氧化物存在的问题和未来发展方向     

同步化学除磷对A2/O工艺除污染效能与活性污泥性能的影响

考察了A2/O同步化学除磷工艺中Al2（SO4）3投加量对TP、COD、NH4+-N和TN的去除率与活性污泥性能的影响。结果表明,常温（18~32℃）条件下同步化学除磷最适宜的Al2（SO4）3投加量为铝、磷摩尔比0.5：1,此条件下出水TP、COD、NH4+-N和TN浓度均能达到《城镇污水处理厂污染物排放标准》（GB 18918-2002）一级A标准。研究同时发现,Al2（SO4）3投加后,活性污泥的沉降性能和污泥活性均有所增强,其中SVI值由93.8 mL·g-1降至81.3 mL·g-1,Zeta电位由-5.5 mV降至-11.8 mV,胞外聚合物EPS含量增加了59.9%,蛋白质与多糖的比例由5.2降至2.1,比耗氧速率由4.2 mg·（g·min）-1升高到6.7 mg·（g·min）-1（以MLSS计）。微生物菌群结构分析结果表明,投药后污泥中微生物种类由投药前的8种减少为6种,硝化菌和反硝化菌比例有所降低,聚磷菌比例升高为6%。在低温（0~10℃）条件下,Al2（SO4）3投加量需有所增加,当铝、磷摩尔比为1：1时,反应器出水TP、COD、TN和NH4+-N浓度方可达到一级A标准。     

Method of Testing the Penetration of Acid Solutions Through Safety Gloves

Because they cause burns that are difficult to heal, acids are dangerous, and steps should be taken to ensure that the human skin does not come into contact with them. For this purpose safety gloves are generally used by workers who have to handle acids. Such gloves need to be tested to ensure that they are acid resistant. Standard EN 374 (European Committee for Standardization [CEN], 1993c) specifies a method of testing the permeation of liquid chemicals, on a molecular level, through glove material, but it may be difficult to ensure the fitness of the joints of a two-compartment cell, when gloves are lined with jersey. To deal with this a simple pH-meter method to test the permeation of acid and alkali solutions through safety gloves has been developed. The permeation of H₂S0₄, HCI, HN0₃, and CH₃COOH through gloves made from neoprene, nitrile, and PVC was tested. This method seems to be simple and economical.     

Attributes of Occupational Injury Among Workers in the Chemical Industry and Safety Issues

Case-study research was carried out with a view to find the attributes of occupational injury among workers in the chemical industry and to enhance safety issues. Injury data were collected and processed in terms of different variables, such as age, gender, skills, type of hazard, etc. Pareto analysis was then applied to find a pattern of occupational injury among the workers. The study revealed that 79.52% of the injured workers were in the 40–59 age group; 57.14% of accidents occurred during the 1st shift; 73.26% of accidents caused injury to hands, feet, chest to thigh, arms and eyes; and 70.93% of injuries were caused by pumps, carrying and lifting, vehicles, pipelines, valves, and grinding. Surprisingly, no one was injured in the group of temporary workers. The paper also provides specific suggestions followed by some action plans.     

基于HFACS-BN模型的危险化学品事故人因路径分析*

为提高危险化学品安全管理水平,收集我国134起以人为主因的危险化学品事故,构建危险化学品事故的HFACS-BN模型,并基于贝叶斯网络对危险化学品事故中的人因路径及各因素灵敏度进行分析。研究结果表明:行为违规是导致事故的最主要不安全行为;在复杂路径中,环境因素和操作者状态具有较高的灵敏度,与其相关的风险认知与处理不当是阻碍事故预防的关键因素;在非复杂路径中,操作者状态与运行计划不当具有较高的灵敏度,其所涉及的监督违规、组织过程和组织氛围,是导致危险化学品事故的根本起点,并可依此分析事故直接原因和间接原因;操作者状态在2种路径中均表现出高灵敏度,因此化工企业在人员管理上要加强关注职工状态,减少不安全行为的出现。     

危化品事故情景推演网络构建及关键节点分析*

为有效应对危化品事故发生与演变时存在的动态性及不确定性问题,基于事故演变过程中的关键情景状态及对应孕灾环境、应急活动和处置目标等要素,引入动态贝叶斯网络方法,构建危化品事故情景推演网络,并结合复杂网络知识,对孕灾环境和应急活动2类事故影响因素节点进行敏感性和重要度分析。结果表明:情景推演网络计算的情景节点概率符合事故发生的实际情况,能够对危化品事故在不同孕灾环境和应急救援下的演变路径进行推演,并且分析得到燃烧物、消防力量、火场环境和建筑密度等关键影响因素节点,研究结果可为事故处理提供应急辅助决策支持。