酸析法和碱析法处理草浆造纸黑液的效果对比

对比了酸析法和碱析法对碱法草浆造纸黑液中木质素的去除效果,并分析了聚合氯化铝(PAC)絮凝剂对酸析和碱析后木质素的絮凝效果。实验结果表明:酸析法和碱析法都能有效析出造纸黑液中的木质素,酸析法对色度的去除效果要优于碱析法;当造纸黑液pH为3时,COD去除率达到72.0%,色度去除率为97.7%;当造纸黑液pH为13时,COD去除率达到55.0%,色度去除率为22.3%;PAC对于酸析后木质素有较好的絮凝效果,当废水温度为55℃、PAC加入量为45mL/L时,COD去除率可以达到79.5%,色度去除率为98.5%;PAC絮凝剂对于碱析后的造纸黑液色度的去除效果较差。     

利用钢铁盐酸酸洗废液在填料塔中制备FeCl3

以钢铁盐酸酸洗废液为原料,亚硝酸钠为催化剂,氧气为氧化剂,在填料塔中催化氧化制备三氯化铁。考察了反应温度、催化剂加入量和添加方式、循环流量等对制备三氯化铁的影响。实验结果表明,在优化的工艺条件为料液预热温度为60 ℃、催化剂加入量为钢铁盐酸酸洗废液总质量的0.30%、料液循环流量6.0 m³/h的条件下,反应80~120 min,酸洗废液中的Fe²⁺完全氧化为Fe³⁺。     

Fenton试剂氧化法处理染料结晶废母液

采用Fenton试剂氧化法处理分散橙、分散紫和分散蓝3种染料结晶废母液。研究了H₂O₂加入量、n（H₂O₂）#x02236;n（Fe²⁺）和废母液pH对COD去除率或TOC去除率的影响。对TOC去除反应分段进行了动力学方程拟合,并探讨了反应机理。实验得到的分散橙、分散紫和分散蓝的废母液处理工艺条件：H₂O₂加入量分别为264.4,352.9,441.2mmol/L;n（H₂O₂）#x02236;n（Fe²⁺）分别为20,10,20;废母液pH=3。3种废母液在0~20min和20~120min两个阶段的反应与二级动力学拟合方程的相关性最好。3种废母液经Fenton试剂氧化处理后,部分有机物降解为小分子有机酸,部分有机物完全矿化。     

公路交通事故黑点成因的对应分析法

为了便捷获取公路事故黑点的形成原因,应用对应分析构建立事故黑点成因分析模型。该模型设立事故样本和事故影响因素之间的列联表,将列联表中影响变量的状态呈现于二维对应分析散点图中,以直观简洁的形式描述事故样本与影响因素之间的对应关系。进而设定相关系数判定对应分析模型的收敛性,应用点子排除法剔除特殊影响变量,增强了分析结果的鲁棒性。通过G205事故黑点路段(K954+50-K954+900)的实例分析表明,运用对应分析法所建立的模型与算法可以获得公路事故黑点形成的主要和次要因素,准确确定直接原因与根本原因的对应关系。     

亚铵法制浆黑液作肥料对水环境影响的研究

通过亚铵法制浆蒸煮黑液直接作农肥施于水稻田的研究,给出了不同施肥方式连续数天田间水和渗滤水中黑液污染物变化情况,定量描述了黑液作肥料直接施于水稻田对水环境的影响。     

稻草制浆黑液生物＋混凝处理试验

通过对稻草制浆黑液厌氧、好氧、混凝处理组合工艺的试验研究,探索该工艺的可行性,考察了不同温度、不同有机负荷下,该类废水的生物处理效果以及后续混凝效果。结果表明：中温35℃是厌氧阶段最佳处理温度,好氧阶段不同负荷条件下,CODCr去除率基本相同;经厌氧－好氧处理,黑液CODCr和木质素去除率分别为80％和30％,色度去除不明显;混凝阶段CODCr和木质素去除率分别为70％和90％,色度去除率达90％以上,出水达到国家标准。     

杨树刺槐混交林沙地土壤的水分—物理性质

研究了刺槐与杨树混交林后沙地土壤水分－物理性质变化的状况,结果表明,刺槐与杨树混交后,土壤水分－物理性质得到了改善,表现在土壤最大持水量增加,毛管持水量、田间持水量得以提高,土壤有效持水量也有了较大幅度的提高,刺槐与杨树混交后土壤总孔隙度、非毛管孔隙度、毛管孔隙度得到提高,并由此而改善了混交林土壤的渗透性能,表4参7     

Effects of feed-supplementation and hide-spray application of two sources of tannins on enteric and hide bacteria of feedlot cattle

Pathogenic bacteria attached to the hide or shed in the feces of cattle at slaughter can contaminate carcasses intended to be processed for human consumption. Therefore, new pre-harvest interventions are needed to prevent the carriage and excretion of foodborne pathogens in cattle presented to the processing plant. The objectives of this study were to examine the antimicrobial effects of hydrolysable tannin-rich chestnut and condensed tannin-rich mimosa extracts on bacterial indicators of foodborne pathogens when applied as a hide-intervention and as a feed additive to feedlot cattle. Water (control) or solutions (3 % wt/vol) of chestnut- and mimosa-extract treatments were sprayed (25 mL) at the left costal side of each animal to a 1000 cm² area, divided in four equal quadrants. Hide-swabs samples obtained at pre-, 2-min, 8-h, and 24-h post-spray application were cultured to enumerate Escherichia coli/total coliforms and total aerobic plate counts. In a second experiment, diets supplemented without (controls) or with (1.5 % of diet dry matter) chestnut- or mimosa-extracts were fed during a 42–day experimental feeding period. Weekly fecal samples starting on day 0, and rumen fluid obtained on days 0, 7, 21 or 42 were cultured to enumerate E.coli/total coliforms and Campylobacter. Tannin spray application showed no effect of treatment or post-application-time (P> 0.05) on measured bacterial populations, averaging 1.7/1.8, 1.5/1.6 and 1.5/1.7 (log₁₀ CFU/cm²) for E. coli/total coliforms, and 4.0, 3.4 and 4.2 (log₁₀CFU/cm²) in total aerobes for control, chestnut and mimosa treatments, respectively. Mean (± SEM) ruminal E. coli and total coliform concentrations (log₁₀ CFU/mL) were reduced (P< 0.01) in steers fed chestnut-tannins (3.6 and 3.8 ± 0.1) in comparison with the controls (4.1 and 4.2 ± 0.1). Fecal E. coli concentrations were affected by treatment (P< 0.01), showing the highest values (log₁₀ CFU/g) in fecal contents from mimosa-fed steers compared to controls (5.9 versus 5.6 ± 0.1 SEM, respectively). Total coliforms (log CFU/g) showed the highest values (P< 0.01) in feces from chestnut- and mimosa-fed steers (6.0 and 6.1 ± 0.1 respectively) in comparison with controls (5.7 ± 0.1). Fecal Campylobacter concentrations (log₁₀CFU/g) were affected by treatment (P< 0.05), day (P< 0.001) and their interaction (P< 0.01) with the controls having lower concentrations than chestnut- and mimosa-fed steers (0.4, 1.0, and 0.8 ± 0.3, respectively). It was concluded that under our research conditions, tannins were not effective in decreasing measured bacterial populations on beef cattle hides. Additionally, chestnut tannin reduced E. coli and total coliforms within the rumen but the antimicrobial effect was not maintained in the lower gastrointestinal tract. Further research is necessary to elucidate the possible antimicrobial effects of tannins at site-specific locations of the gastrointestinal tract in beef cattle fed high-grain and high-forage diets.     

炭黑工业烟气余热的回收及利用

对油炉法炭黑生产过程烟气的来源，组成，发生量，特性作了介绍，着重研究了炭黑烟气余热的加收及利用。结果表明，采用余热锅炉串联多级空气预热器，是目前我国炭黑烟气余热回收及利用的最佳方法，采用这种方法，不仅可将高温炭黑烟气的余热量最大限度地回收及利用，同时可满足炭黑收集及烟气净化系统设备对炭黑烟气温度的要求，采用该法，炭黑烟气余热利用率可提高２０％以上，经济效益十分可观。     

利用造纸黑液制备水煤浆添加剂

利用造纸黑液中有效成分，经过适当处理制备水煤浆添加剂，并且对添加剂的性能进行了测试。结果表明，依照该工艺生产的添加剂，性能优良，能够满足工业生产需要。