铜矿酸性废水氧化钙中和处理装置的改造

介绍了用氧化钙二次中和沉淀法处理铜矿酸性废水的工艺流程、主要设备和处理效果。针对矿山不断开采带来的废水水质变化和处理装置存在的新问题 ,对工艺路线、斜板沉淀池、石灰消和机等进行了改造。改造后的运行结果表明 ,出水水质达到GB8978— 1996二级排放标准 ,节约运行费用 15万元 /a ,沉淀池大修期从 4a延长到 6a ,减少石灰用量 8% ,增加废水处理量 1.5× 10 5m3 /a。     

AQUATIC TRANSPORT OF HEAVY METALS IN THE URBAN ENVIRONMENT1

ABSTRACT: A study has been conducted for the past two years on a 4.6 mile stretch of the Saddle River near Lodi, New Jersey. The primary objectives of this study were two fold; initially, the amounts of various heavy metals being contributed to the Saddle River by stormwater runoff, rainfall, and individual tributaries, etc., were investigated to better delineate the distribution of various sources of heavy metals to the aquatic environment. Secondly, a series of benthal deposits from the Saddle River were analyzed to determine the fate of these metals once introduced into the receiving stream. A mass balance analysis of heavy metals in the Saddle River was performed to determine the amount of these materials contributed from unrecorded sources. The results of this study seemed to demonstrate the importance of considering the potential scouring of river sediments as a secondary source of metals in determinations of this type. The distribution of metals in precipitation samples collected in this study was found to be similar to that in runoff, with lead and zinc predominating. Relative concentrations of metals in precipitation as compared to those of stormwater were relatively insignificant. Metal concentrations of bottom sediments were found to vary considerably from sample to sample.     

去除矿井水处理构筑物中藻类的应用研究

针对部分矿井水处理构筑物中藻类大量滋生繁殖的现状,研究了除藻剂硫酸铜对构筑物中的藻类去除情况,重点考察了硫酸铜的适宜投加量和持续作用时间.工业性试验表明,硫酸铜的投加量1.0 mg/L左右,持续投加时间为一周左右,可有效地去除矿井水处理构筑物中的藻类.     

电路板蚀刻废液及其回收铜盐产品中PCBs污染特征

POPs(持久性有机污染物)是近年来广受关注的一类环境污染物. 为研究工业过程中POPs的运转迁移,针对电路板蚀刻废液及其回收后生产的铜盐产品中7种指示性PCBs(多氯联苯)及CB-209进行分析. 结果表明,PCBs在碱性废液和微蚀废液中未检出,而在酸性废液中有不同程度检出,ρ(∑₈PCBs)在0.41~60.80 ng/L之间,其中ρ(∑₇指示性PCBs)在0.24~58.00 ng/L之间. 3种铜盐产品〔CuCl₂、Cu₂(OH)₃Cl和CuSO₄〕中,CuSO₄中w(∑₈PCBs)相对较高,在2.75~284.00 ng/kg之间;而CuCl₂中w(∑₈PCBs)在6.95~31.50 ng/kg之间;Cu₂(OH)₃Cl中w(∑₈PCBs)在7.31~9.42 ng/kg之间. 污染物指纹特征表明,酸性蚀刻废液及其铜盐产品中的PCBs具有十分相似的分布特征,CB-28是最主要的检出单体,并且w(CB-209)相对较高,表明铜盐产品中的PCBs主要来源于生产原料(酸性蚀刻废液)的携带,而酸性蚀刻废液中污染物来源须待进一步分析研究.      

熟污泥改性黄土对铜的吸附解吸特征

为探明熟污泥改性黄土对重金属的容纳能力,以熟污泥改性黄土为供试土样,采用序批实验法研究了供试土样对铜(Cu)的吸附解吸特征,并分析了供试土样对铜的固定能力及影响因素.供试土样对铜的吸附量在铜添加浓度小于100mg/L时急剧增加,在铜添加浓度大于100mg/L时增加缓慢,而解吸量的变化趋势则恰恰相反.Langmuir型吸附等温式是描述供试土样对铜的吸附过程的最佳模型,而吸附量与解吸量的关系可以很好的用指数函数来描述.供试土样对铜的固定吸附量随熟污泥含量的增加而增加,有机质含量是决定性因素.     

Identification and assessment of environmental burdens of Chinese copper production from a life cycle perspective

The environmental burdens of Chinese copper production have been identified and quantified in the context of typical technologies, materials supplies and environmental emissions by a life cycle approach. Primary and secondary copper production using copper ores and scraps, respectively, were analyzed in detail. The flash and bath smelting approaches and the recycling of copper scraps were selected as representative copper production processes. A quantitative analysis was also conducted to assess the influence of material transport distance in copper production. Life cycle assessment （LCA） results showed that resources depletion and human health contribute significantly to environmental burdens in Chinese copper production. In addition, the secondary copper production has dramatically lower environmental burdens than the primary production. There is no obvious distinction in overall environmental burdens in primary copper production by flash or bath smelting approach. However, resources depletion is lower and the damage to human health is higher for flash smelting approach. Ecosystem quality damage is slight for both approaches. Environ- mental burdens from the mining stage contribute most in all life cycle stages in primary copper production. In secondary copper production, the electrolytic refining stage dominates. Based on the life cycle assessment results, some suggestions for improving environmental performance were proposed to meet the sustainable development of Chinese copper industry.     

铜对水生生物的毒性:类群特异性敏感度分析

铜的毒性因受多种环境因素(如温度、pH等)的影响,其水质基准和标准经历过多次修改。由于不同区系生物受生活环境等因素的影响,不同物种对铜的耐受性和敏感度上存在很大的差异。本文通过构建类群特异性敏感度分布,以及对10%安全浓度值(10%hazardous concentration,HC_(10))及其95%置信区间(95%confidence interval,95%CI)的比较,分析了铜对淡水和海水各类群的敏感度差异,以期为我国在制定相关水质基准的物种选择上提供参考。结果显示,淡水系统中藻类为对铜毒性最敏感类群,其次为甲壳类,软体动物类,鱼类,寡毛类,而昆虫类为对铜的最耐受类群。海水各类群对铜的敏感度顺序与淡水类似,只是在寡毛类和鱼类顺序上有所不同。相对于海洋物种,淡水水体生物总体上比海水中各相应类群生物对铜更为敏感。     

电气火灾一次短路熔痕金相组织特征参数定量分析

电气火灾一次短路熔痕鉴别和判定对分析火灾原因和事故认定至关重要,而目前金相分析方法目前处于经验和半经验水平,缺乏定量分析手段.本文开展不同电流条件下(100A至300A,间隔为20A)铜导线一次短路模拟实验,制作相应短路熔痕金相图谱.同时引入描述金相组织特征参数,基于Image - ProPlus应用数字图像处理技术提取图谱的金相组织特征参数量化指标,讨论金相组织晶粒和孔洞尺寸变化的特点,实现金相微观组织特征参数和电流之间的关系数据对比分析,探讨一次短路熔痕金相组织的量化判据和变化规律.     

Cu2+和Cu-EDTA对鲫鱼脑组织应激蛋白HSP70诱导的影响

以鲫鱼(Carassius auratus)作为实验对象,经过40d不同浓度铜(Cu²⁺)及其配合物(Cu-EDTA)的暴露后,运用SDS-PAGE和Western Blotting方法检测鱼脑组织内应激蛋白HSP70的诱导表达情况.结果表明:在实验浓度下,与对照组相比,Cu²⁺和Cu-EDTA对鱼脑内HSP70有显著的诱导(p<0.05),而将Cu²⁺和Cu-EDTA实验组相对比,络合剂EDTA一定程度上改变了Cu的生物可利用性,从而降低了其毒性.实验还发现,Cu²⁺浓度在国家渔业水质标准0.01mg/L下时,鱼脑组织内HSP70已经有明显的表达,说明运用分子生物学指标要比传统的环境监测指标更敏感,具有对污染物早期预警的作用.     

硒蛋白R抑制铜离子介导的Aβ_(42)聚集和细胞毒性

阿尔茨海默病(Alzheimer's disease,AD)是一种神经退行性疾病,其主要病理特征包括脑内出现老年斑和神经纤维缠结以及神经元缺失。过渡金属离子如Fe~(2+)、Zn~(2+)、Cu~(2+)等会在AD病人脑中大量蓄集,从而促进,-淀粉样多肽(Aβ)聚集并产生大量活性氧自由基,引起细胞功能改变。硒蛋白R(Sel R)是一种蛋氨酸亚砜还原酶,可将蛋白中的蛋氨酸亚砜还原为蛋氨酸。然而Sel R与金属离子的关系尚无报道。文章对Sel R的突变体Sel R'(Sel R中硒代半胱氨酸Sec95突变为半胱氨酸Cys95)结合Cu~+的性质进行了表征,同时也对Sel R'调节Cu~+/Cu~(2+)诱导的Aβ42聚集和细胞毒性的能力进行了研究。结果表明,Sel R'可与Cu~+特异性螯合剂BCA竞争结合Cu~+,说明Sel R'具有较强的Cu~+结合能力。采用硫磺素荧光法(Th T),发现Cu~+/Cu~(2+)显著性抑制Aβ42的纤维化、诱导其形成非纤维化聚集体,而Sel R'则能够显著抑制Cu~+/Cu~(2+)诱导的Aβ42聚集形态的改变。细胞实验表明:Sel R'能显著降低Cu~+/Cu~(2+)诱导的Aβ42的细胞毒性。上述结果提示:Sel R在脑内除了还原蛋氨酸亚砜,还可通过与铜离子的结合抑制其细胞毒性作用,从而干预AD的发展。