RPC200人行道板抗弯承载力试验研究

笔者对铁路桥梁用空心无配筋活性粉末混凝土人行道板进行了抗弯试验研究 ,探讨了其受力变形性能。分析表明 :活性粉末混凝土人行道板的安全系数均大于 2 ,满足承载能力要求 ;位移延性系数均大于 3.5 ,具有良好的延性性能 ,破坏形式属于延性破坏。该类人行道板的成果已通过铁道部专家的鉴定 ,拟用于青藏铁路桥梁实际工程中。     

废玻璃钢粉填充丁腈橡胶的性能研究

研究了废玻璃钢粉填充丁腈橡胶的性能。从取向和非取向两个方面探讨了废玻璃铜粉含量对丁腈橡胶性能的影响,比较了废玻璃铜粉和碳酸钙对丁腈橡胶性能的影响。结果表明,玻璃钢粉对于丁腈橡胶具有一定的补强作用,随着玻璃钢粉加入量的增加,电阻率略有下降;由于玻璃短纤维的存在使得胶片取向与非取向方向的性能有所差异。综合性能考虑,使用20份废玻璃钢粉的复合材料具有较高的性能价格比。     

生物质粉体燃烧炉实验研究

利用生物质微米燃料进行了粉体燃烧炉实验研究。在实验工况下,该燃烧炉能够稳定燃烧;当燃料/风量为250g/m3时,主燃室温度稳定在1150℃左右,最高可达1249℃,燃料燃烧充分,燃烧效果最佳;在最佳工况下,炉膛的温度场适宜,能够满足其工业化应用需要。     

Effect of Al2O3 particle size reduction on aluminium dust explosion

To investigate the effect of Al₂O₃ particle size on an aluminum explosion, the overpressure and flame velocity in a vertical duct were evaluated. The results show that the inhibitory effect of submicron Al₂O₃ is best, while the inhibitory effect increases with increasing inerting ratio. However, the inhibitory effect of micron Al₂O₃ does not increase significantly after the inerting ratio exceeds 40%. For high-concentration aluminum powder, 0.8 μm Al₂O₃ with an inerting ratio less than 20% promotes aluminum explosion. As the inerting ratio increases beyond 20%, however, the overpressure decreases. Furthermore, Al₂O₃ inhibits the formation of the intermediate product AlO and decreases the flame brightness. As the inerting ratio of 0.8 μm Al₂O₃ reaches 50%, the white patches in the flame image disappear. The results of scanning electron microscopy showed that the explosion products agglomerate and some dot-like protrusions appear on the surface of the unburned aluminum particles. The inhibition mechanism was qualitatively investigated. Physical heat absorption is proven to play a limited role. Thermal radiation and chemical inhibition play a key role. The chemical effect mainly influences the surface reaction energy source.     

玉米秸秆发酵浸出液模拟废水发酵产氢的放大实验研究

在20L的半连续流发酵罐中,以牛粪堆肥为产氢菌源,按照玉米秸秆发酵浸出液的主要成份配制模拟废水,考察和分析了几个关键环境因素对发酵产氢的影响。结果表明,HRT、C/N、Fe2+浓度和模拟废水浓度对发酵产氢均有不同程度的影响。在本实验条件下,秸秆模拟废水的氢产量、氢浓度和产氢速率分别为11.80mol/kg、56%和8.81L/(L?d),底物转化率大于90%,废水中COD去除率为39.40%。在整个发酵产氢过程,液相主要发酵副产物为丁酸、乙酸和丙酸以及少量的乙醇和丁醇。     

Effects of various pretreatment methods on mixed microflora to enhance biohydrogen production from corn stover hydrolysate

Effects on mixed microflora to enhance biohydrogen production from corn stover hydrolysate was studied.     

秸秆生物质环境材料的制备及对水中多环芳烃的处理性能

300～700℃下热解炭化黄豆、芝麻、玉米秸秆8h,制备了秸秆生物质环境材料,测定了秸秆生物质环境材料的BET比表面积及其对亚甲基蓝和碘的吸附能力.以多环芳烃(PAHs)为目标污染物,探讨了生物质环境材料对水中单一和复合PAHs的吸附性能.结果表明,随热解温度升高,秸秆生物质环境材料比表面积增大,其对亚甲基蓝、碘的吸附...     

PAC强化“水解酸化+CAST”工艺处理混合化工废水的研究

采用粉末活性炭(PAC)强化"水解酸化+CAST"工艺对混合化工废水进行研究。试验结果表明:PAC强化"水解酸化+CAST"工艺对进水中COD、难降解COD、BOD5、NH3-N和TP等参数的去除率分别达到了82.8%、52.8%、95.8%、88.8%和94.2%,实际出水水质有了很明显提高。PAC与活性污泥法耦合处理废水,PAC在产生吸附作用的同时,具有与生物协同的降解作用。通过改变PAC的投加方式和投加量试验,出于经济方面考虑,在保证出水水质指标达标的前提下,确定2~3天为一个比较合理的PAC投加周期。     

巯基改性玉米秸秆吸附Hg(Ⅱ)的热力学特征研究

采用化学反应的合成方法向玉米秸秆中引入巯基官能团,并进行电镜扫描、红外光谱和X射线电子能谱分析.在此基础上,以巯基改性玉米秸秆为吸附剂,通过批处理试验讨论了吸附时间、体系pH和温度等因素对水体中Hg(Ⅱ)吸附的影响.结果表明,采用该合成方法可以成功地向玉米秸秆中引入0.98%的巯基官能团,巯基改性玉米秸秆对水体Hg(Ⅱ)的吸附最佳pH为6,吸附能在120min内达到平衡,在285K时对Hg(Ⅱ)的最大吸附量可达80.04mg·g-1.吸附过程是自发的放热过程,可用Langmuir模型描述,其吸附机理可能为络合反应控制的化学吸附.研究表明,巯基改性玉米秸秆是一种对水体Hg(Ⅱ)具有良好吸附能力的生物吸附剂.     

Nitrification characteristics of nitrobacteria immobilized in waterborne polyurethane in wastewater of corn-based ethanol fuel production

A technology to achieve stable and high ammonia nitrogen removal rates for corn distillery wastewater (ethanol fuel production) treatment has been designed. The characteristics of nitrifying bacteria entrapped in a waterborne polyurethane (WPU) gel carrier were evaluated after acclimation. In the acclimation period, nitrification rates of WPU-immobilized nitrobacteria were monitored and polymerase chain reaction (PCR) was also carried out to investigate the change in ammonium-oxidizing bacteria. The results showed that the pellet nitrification rates increased from 21 to 228 mg-N/(L-pellet. hr) and the quantity of the ammonia oxidation bacteria increased substantially during the acclimation. A continuous ammonia removal experiment with the anaerobic pond effluent of a distillery wastewater system was conducted with immobilized nitrifying bacteria for 30 days using an 80 L airlift reactor with pellets at a fill ratio of 15% (V/V). Under the conditions of 75 mg/L influent ammonia, hydraulic retention time (HRT) of 3.7--5.6 hr, and dissolved oxygen (DO) of 4 mg/L, the effluent ammonia concentration was lower than 10 mg/L and the ammonia removal efficiency was 90%. While the highest ammonia removal rate, 162 mg-N/(L-pellet.hr), was observed when the HRT was 1.3 hr.