玉米浸泡液制备苏云金杆菌生物杀虫剂的影响因素研究

以玉米淀粉生产过程中的浸泡液为培养基,摇瓶发酵培养苏云金杆菌生物杀虫剂,通过一系列单因子试验,考察了不同培养条件(种子液的种龄、接种量、浸泡液的含固率、初始pH值、摇床转速、发酵温度及发酵时间)对苏云金杆菌在玉米浸泡液中的生长(菌数增长与芽孢形成)以及发酵液的生物毒效的影响.研究表明,在最佳摇瓶培养条件(种子液种龄10 h,接种量2%,浸泡液含固量3%,初始pH值7.0～7.5,摇床转速200 r/min,发酵温度30℃)下发酵48 h,活菌数和活芽孢数分别可达到7.9×108 CFU/mL和5.5×108 CFU/mL,毒力效价为698.0 IU/μL.本试验可为生物农药的工业化生产提供实用参数.     

抛光铝粉爆炸及ABC粉体抑爆特性的实验研究

为研究抛光铝粉的爆炸危险和ABC粉体的抑爆特性,在对实验粉体粒径分布进行分析的基础上,采用20 L粉尘爆炸特性实验装置,分别对不同铝粉尘浓度、不同抑爆剂浓度条件下的爆炸特性参数进行测试。研究结果表明:在实验条件下,铝粉的爆炸下限为45 g/m3＜C＜60 g/m3;随铝粉浓度增加,爆炸烈度呈现出先增强后减弱的变化趋势,在浓度为400 g/m3时爆炸烈度最大。ABC抑爆剂能够有效抑制铝粉爆炸超压和爆炸反应进程,随着惰性粉体浓度的增加,抑制效果愈加明显,爆炸逐渐减弱。当ABC惰性粉体的质量占比增加到50%时,相较单一铝粉爆炸,反应过程时间由72 ms增加至785 ms,爆炸最大压力、最大压力上升速率分别下降了61.7%,89.5%;当ABC粉体质量占比为53%时,铝粉被完全惰化,未发生爆炸。     

Study on explosion risk of aluminum powder under different dispersions

This paper mainly studied the influence of particle size distribution on the explosion risk of aluminum powder under the span of large particle size distribution. The measurement was carried out with the 20 L explosion ball and the Hartmann tube. The statistical analysis was used to analyze the relevance between the parameters of explosion risk and the particle size parameters. Test results showed that with the increase of particle size, the sensitivity parameter increases and the intensity parameter deceleration decreases. The effect of particle size change on MEC and MIE of small particle size aluminum powder is relatively small but greater impact on Pm and (dP/dt)m. The small particle size components greatly increasing the sensitivity of the explosion and accelerating the rate of the explosion reaction; while the large particle size component contributes to the maximum explosion pressure. D_3,2 particle size dust determines the risk of aluminum powder explosion.     

The inhibitory combustion reaction performance and tail gas analysis of composite ultra-fine dry powder extinguishing agent containing different additives

For lack of an extinguishing agent with high-efficiency, non-toxic and environmentally friendly, a new type of extinguishing agent was fabricated to solve such an urgent problem. In this study, the zinc borate (ZB) and ferrocene (Fe(Cp)₂) were utilized as two additives for extinguishants to suppress combustion reaction and the toxicity of the tail gas was detected. The mass fraction of ZB corresponding to the optimal inhibitory effect was determined to be 0.5–1.5%, by contrast, the optimum interval of Fe(Cp)₂ was detected as 0.5–1.0%. Similarly, with the increasing proportion of the two additives, the homologous inhibitory action was gradually weakened. From the perspective of thermogravimetric analysis (TGA), it was indicated that the ZB accelerated the pyrolysis process of the extinguishant, making its thermal decomposition process more thoroughly. Meanwhile, the differential scanning calorimetry (DSC) demonstrated that the decomposition efficiency was markedly improved when the amount of ZB was maintained at 0.5–1.5%. Besides, the tail gas tests were implemented to assess the extent of toxic and harmful properties. In terms of the carbon monoxide (CO) and carbon dioxide (CO₂) generated, once the mass fraction of ZB and Fe(Cp)₂ was less than 1.5% and 1.0% respectively, the concentration of CO and CO₂ was distinctly lower than that without additives. Moreover, the inhibitory ability on nitrogen oxides (NOx) was enhanced when the mass fraction of the two additives was kept below 1.0%. The results confirmed that a more practical extinguishant was proposed and it can provide guidance for the application and development of extinguishants.     

非平衡式双极性离子风消电技术与应用

为实现风送管道物料静电监测与控制,预防料仓静电燃爆事故,提高聚烯烃装置料仓安全水平,基于非平衡式双极性离子风消电技术,开发了双极性离子风消电器;基于离子风消电器和静电监测器,探讨了石化粉体料仓用离子风消电控制系统组成、电路、气路布局;对非平衡式双极性离子风消电系统进行现场应用测试。结果表明:基于此管道粉体消静电技术,合理调节正、负侧控制电压,可有效控制管道物料荷质比稳定在±0.3 μC/kg以内,保障聚烯烃装置料仓安全、稳定运行。     

蓝藻资源化技术研究及应用进展

针对蓝藻资源化问题,概述国内外利用蓝藻制备有机肥、提取高纯度藻蓝蛋白、制备活性炭和藻粉这4种利用方式的特点、现状及应用进展。提出,应从高温好氧堆肥技术、藻蓝蛋白提取技术和藻水分离技术这3个方面,解决其关键技术问题并进行进一步研究开发。     

高比表面微孔活性炭的制备及其对对硝基苯胺的吸附

以互花米草与棉秆为原料,以KOH为活化剂,制备了高比表面微孔活性炭,利用氮气吸附、红外光谱FT-IR、扫描电子显微镜SEM等技术对活性炭表面物化性质进行了表征与分析,并通过静态实验测定了其对对硝基苯胺的吸附性能。结果表明,在KOH与植物茎秆碳化料的质量比为3∶1、温度为800℃、活化时间为1.5 h条件下,制备的棉秆活性炭CS-AC和互花米草活性炭SA-AC的BET比表面积分别为2 135和2 825 m2/g,H-K微孔容积分别为1.09和1.19 cm3/g,有80%以上的孔分布在2 nm以内。静态吸附实验表明,2种植物基活性炭对对硝基苯胺有较强的吸附能力,Langmu ir最大吸附量超过700 mg/g。吸附受溶液pH影响较大,Frend lich方程能较好地描述静态吸附平衡数据。     

3种生物质炭对活性艳蓝KN-R的吸附简

选择由玉米秸秆、稻壳和稻草秸秆在825℃制成的生物质炭作为吸附剂,通过模拟实验,研究其对溶液中活性艳蓝KN-R的吸附特性,考察了pH值、时间、溶液初始浓度和生物质炭用量对吸附效果的影响。结果表明,当pH为2.0时,玉米秸秆炭和稻壳炭对活性艳蓝的吸附量均达到最大,而pH对稻草秸秆炭的影响不大;三者达到吸附平衡的时间分别为180、300和360 min,最大吸附量分别为114.05、54.60和68.19 mg/g。等温吸附过程可以用Langmuir方程来描述;动力学实验表明,吸附过程更符合拟二级动力学模型;热力学数据分析发现,吸附过程是自发进行的吸热过程。     

The presence of Bacillus thuringiensis (Bt) protein in earthworms Eisenia fetida has no deleterious effects on their growth and reproduction

Earthworms Eisenia fetida, bred in substances with stover of two genetically-engineered Bacillus thuringiensis (Bt) corns (5422Bt1 (Event Bt11) and 5422CBCL (MON810)) expressing Cry1Ab and their near-isogenic non-Bt corn (5422), were used to investigate the non-target effects of Bt corn on soil-dwelling organisms. Cry1Ab concentrations in substances, casts and guts of E. fetida were also investigated by Enzyme-linked immunosorbent assay (ELISA). More than 90% individuals of E. fetida survived over a period of 30 d, irrespective of whether they received Bt corn or non-Bt corn. Compared to 5422 treatments, significantly higher relative growth rate and more number of new offspring and cocoons of E. fetida were found in 5422Bt1 and 5422CBCL treatments. These results were unlikely to be directly caused by Cry1Ab released from Bt corns but rather by differences in other factors of plants such as plant components (soluble sugar, total organic carbon, total protein and available phosphorus of Bt corns were more than 5422). ELISA results indicated immunoreactive Cry1Ab was detectable in substances, and the casts, guts of E. fetida from Bt corns treatments, of which the highest levels were detected in substances under the corresponding experimental conditions. With the increase of treated time, a strong decline was observed in Cry1Ab from substances and casts of E. fetida, whereas Cry1Ab in guts of E. fetida from 5422Bt1 treatments gradually increased and that from 5422CBCL treatments increased between 14 and 30 d. Therefore, the presence of Cry1Ab in E. fetida had no deleterious effects on their growth and reproduction.     

超声波-铁粉协同降解五氯酚

通过超声波-铁粉联合体系协同降解废水中的五氯酚(PCP).实验结果表明:降解120 min后,PCP去除率可达90.4％;在该体系中铁粉被逐渐腐蚀成Fe2+,随降解时间的延长,Fe2+浓度逐渐增加;体系中的Fe2+可以促进·OH的产生,并且可以与超声空化作用下产生的H2O2发生Fenton试剂氧化反应降解PCP;超声波...