制导弹药火工元件加速寿命试验技术研究

准确判定组件的剩余寿命是制导弹药维修工作的重要组成部分。针对制导弹药火工元件的特点,分析了加速寿命试验的类型、加速应力、寿命分布和加速系数;研究了试验中的应力水平、样本选取和失效判定等问题;探讨了基于线性无偏估计的数据处理方法。该试验方法也适用于制导弹药其他组件的寿命预测。     

Evaluation of mercury speciation and removal through air pollution control devices of a 190 MW boiler

Air pollution control devices (APCDs) are installed at coal-fired power plants for air pollutant regulation. Selective catalytic reduction (SCR) and wet flue gas desulfurization (FGD) systems have the co-benefits of air pollutant and mercury removal. Configuration and operational conditions of APCDs and mercury speciation a ect mercury removal e ciently at coal-fired utilities. The Ontario Hydro Method (OHM) recommended by the U.S. Environmental Protection Agency (EPA) was used to determine mercury speciation simultaneously at five sampling locations through SCR-ESP-FGD at a 190 MW unit. Chlorine in coal had been suggested as a factor a ecting the mercury speciation in flue gas; and low-chlorine coal was purported to produce less oxidized mercury (Hg2+) and more elemental mercury (Hg0) at the SCR inlet compared to higher chlorine coal. SCR could oxidize elemental mercury into oxidized mercury when SCR was in service, and oxidation e ciency reached 71.0%. Therefore, oxidized mercury removal e ciency was enhanced through a wet FGD system. In the non-ozone season, about 89.5%–96.8% of oxidized mercury was controlled, but only 54.9%–68.8% of the total mercury was captured through wet FGD. Oxidized mercury removal e ciency was 95.9%–98.0%, and there was a big di erence in the total mercury removal e ciencies from 78.0% to 90.2% in the ozone season. Mercury mass balance was evaluated to validate reliability of OHM testing data, and the ratio of mercury input in the coal to mercury output at the stack was from 0.84 to 1.08.     

石化企业综合防雷技术探讨

分析了石化企业当前防雷工程中存在的问题,结合先进的防雷技术与产品,对防雷接地系统与接地、工程电子信号系统的防护提出一些改进意见。     

加氢站用45 MPa高压储氢瓶式容器火烧试验模拟*

为研究加氢站用高压储氢容器在火灾下的安全性能,采用计算流体力学（CFD）方法对45 MPa高压储氢瓶式容器火烧试验过程进行模拟研究,结合气瓶火烧试验,分析高压储氢容器火灾下的热响应过程,研究不同因素对储氢容器压力泄放装置动作时间的影响。结果表明:613 s以内试验压力与模拟数据的最大相对误差为3.9%,模型误差在可接受范围;不同充装介质对安全泄放装置动作时间影响不大;不同充装压力对容器内介质压升速率影响较大,充装水平较高时压力泄放装置更快动作,较低的充装压力下容器内介质温升较快;不同环境温度对介质温升影响较小。     

新型矿用圆弧形薄壁防冲吸能装置屈曲特性数值分析*

为解决支架面对冲击地压产生的强冲作用容易失效、失稳的难题,针对现有矿用防冲吸能装置存在的不足,提出1种新型矿用圆弧形薄壁防冲吸能装置。采用ABAQUS有限元数值模拟方法对新型防冲吸能装置与原有方形预折纹薄壁装置进行对比分析,同时研究新型防冲吸能装置在不同壁厚和不同轴向模块堆积个数情况下的屈曲特性。结果表明:圆弧形薄壁装置相比于方形折纹薄壁装置在相同厚度情况下其总吸能提升近20%,比吸能提高63%,装置防冲优势明显;在装置高度不变的情况下增加模块轴向堆积个数可有效降低压溃峰值荷载、荷载波动系数,增加平均压溃荷载;随着装置薄壁厚度降低,压溃峰值荷载、压溃平均荷载、总吸能与比吸能均降低,荷载波动系数增加,曲线波动性变大。     

生物接触氧化+植物一体化装置处理小城镇污水试验研究

利用“生物接触氧化+植物”一体化装置处理城镇污水,试验最终选用悬浮多面球作填料,采用射流曝气,控制进水流量为0.45 m3/h,进水浓度为COD 63～467 mg/L、NH3-N 11.21～52.7 mg/L、TN 28.6 ～63.5mg/L和TP １.1～6.42 mg/L时,COD、NH3-N、TN和TP的去除率分别达到88％、86％、70％、60％以上,出水COD≤30 mg/L,NH3-N≤5 mg/L、TN≤13 mg/L、TP≤0.5 mg/L.水质优于《城镇污水处理厂污染物排放标准》(GB 18918-2002)一级A标准,具有较好的工程应用前景.     

GC/MS法测定黄浦江水中挥发性有机化合物

采用吹扫捕集装置与GC／MS联用仪的全自动恒流控制,对黄浦江7个断面水样中47种挥发性有机化合物进行了分析。结果表明,被查的47种挥发性有机化合物基本都有检出,其中甲苯、异丙苯的绝对检出量最高。四氯化碳的检出值也较高,吴淞口四氯化碳的平均浓度已经远远超过GB3838—2002《地表水环境质量标准》,并且四氯化碳浓度在黄浦江流域各个断面的分布具有一定规律性。     

智能型防碰天车装置的安全可靠性分析

针对目前油田钻井现场使用的智能型防碰天车装置存在一些安全问题，分析了问题的实质是设计测量精度和安全可靠性不高。提出了具体改进设计的方案与意见。     

工程塑料环境因素与载荷应力耦合作用试验装置研究

目的 设计一种能够模拟工程塑料实际服役工作环境的试验装置,在多型自然环境中,构建兼具环境因素侵蚀与载荷应力耦合作用的试验条件。方法 研制工程塑料环境因素与载荷应力协同作用试验装置,采用包括拉伸加载、弯曲加载、控制系统等组件的模块化设计,实现0.01~16 Hz加载频率的拉伸及弯曲载荷,最大1 550 kg的拉伸载荷,最大375 kg的弯曲载荷。结果 将研制完成的试验装置置于多型自然环境下对试验施加恒定和交变载荷,以真实模拟工程塑料实际服役中的环境因素与载荷应力协同作用。结论 试验装置制造加工难度小,结构稳定可靠,可用于评价和研究工程塑料等系列类型材料的环境损伤性能演变。     

Inexpensive substrate sampler for macroinvertebrates

Assessment of aquatic macroinvertebrates is a critical component of many watershed monitoring programs and passive samplers are often used to collect long-term site data, especially in environments where active sampling is not possible. However, standard passive samplers can be expensive and lost in extreme conditions. We developed a sampler using plastic soda bottles (PSB) filled with river rock and compared its effectiveness with standard Hester-Dendy samplers in both lotic and lentic environments. Abundance, taxa richness, and macroinvertebrate composition showed no significant differences between sampler types in either habitat type. PSB samplers, which can be constructed for less than one dollar each, collected the same number of organisms and represented the same diversity as Hester-Dendy devices that cost around $38 each. In studies where funds are limited, PSB samplers appear to be suitable for passive monitoring.