铬盐废水蒸发系统腐蚀突变与缓蚀工况研究

针对铬盐废水蒸发系统运行过程中的腐蚀问题,采用失重法、pH值检测、扫描电镜(SEM、EDS)和XRD等手段,模拟研究了温度、Cr3+质量浓度对20#碳钢腐蚀速率、腐蚀产物的影响,并从废水pH值和形貌分析角度探索腐蚀速率发生突变的原因.研究表明:废水Cr3+质量浓度在150～180 mg/L范围,碳钢腐蚀速率发生突增,废...     

采空区热环境对深部倾斜厚煤层自燃区域影响研究

为探究热场对深部倾斜采空区煤自燃区域划分的影响,通过对采场空隙结构和耗氧速率进行分析,利用Fluent软件模拟不同通风方式下热环境对采空区流场及自燃带影响.结果表明:受倾角工作面、采空区空隙率及地温梯度综合影响,下行冷风与受采空区浮升力作用的热风在工作面中下部汇合并涌向工作面,使工作面局部温度升高;上行通风方式采空区蓄...     

我国特种劳动防护用品产业分布特点分析

为了解我国特种劳动防护用品产业分布特点和产业市场集中程度,基于生产企业统计数据,估算我国特种劳动防护用品产业市场集中度;对比2017年和2010年数据,统计分析我国特种劳动防护用品产业的区域、产品种类、企业注册资金规模和企业从业人员数量的分布和变化,分析总结了产业发展呈现的特点,提出了加快我国特种劳动防护用品产业发展的相应建议。结果表明:当前我国特种劳动防护用品产业市场结构尚属于低集中竞争型;各区域生产企业数量按照东部、中部、西部和东北的顺序依次递减,东部生产企业占据全国企业总数的65%以上;一半以上企业的注册资金均大于1 000万元;以从业人员数量看,80%以上企业属于小型企业规模;与2010年相比,2017年我国特种劳动防护用品生产企业从业人员数量增加了6.67%,企业从业人员规模分布变化不明显,企业注册资金规模已由约7成企业在500万元以下转变为近7成超过500万元,产品种类增加了40%。研究结果可为我国劳动防护用品产业和安全产业的发展提供科学参考。     

基于响应曲面法的遗煤自燃分析与研究*

为研究高瓦斯易自燃煤层不同供风量、高抽巷抽采流量、低抽巷抽采流量3因素对采空区自燃“三带”分布影响规律,选取阳煤五矿8406工作面为研究对象,在数值模拟研究基础上,采用Design Expert软件进行Box Behnken试验设计,构建采空区氧化升温带宽度在3因素、3水平条件下的二次回归响应曲面模型,并对不同条件下采空区氧化升温带宽度进行预测与分析。结果表明:二次回归方程P值为0.001 6,预测模型显著,模型的失拟项为0.606 3,不显著,回归方程具有统计学意义;当供风量为1 500~2 000 m3/min,低抽流量为450~650 m3/min,高抽流量为100~200 m3/min时,对氧化升温带宽度一次项重要度排序为C（高抽巷抽采流量）>A（供风量）>B（低抽巷抽采流量）,二次项重要度排序为AC（供风量和高抽巷抽采流量）>AB（供风量和低抽巷抽采流量）>BC（低抽巷抽采流量和高抽巷抽采流量）,且AB,AC,BC之间均无交互作用。     

An experimental study on the burning rate of a continuously released n-heptane spill fire on an open water surface

Spill fires are common during oil product storage and transportation after a loss of containment. Since the burning fuel is moving and the fuel depth is quite shallow, the burning rate in a spill fire is different from that of a pool fire with a static burning zone. Unlike pool fires, which have been studied for decades and have well-established correlations for burning rate, research on spill fires is inadequate. In this paper, continuously released n-heptane spill fire experiments were conducted on open water surfaces with varying fuel discharge rates. The pool diameters were measured, and the spill fire burning rates were estimated based on a dynamic balance between fuel supply and combustion. The burning rates in n-heptane pool fires from the literature were reviewed and compared with the estimated burning rates in spill fires of the same dimension. The spill fire burning rate was found to be close to that in a pool fire during the initial burning phase but lower than that in a bulk burning pool fire and that in a “fuel-level-controlled” pool fire. The distinction between the burning rates of spill fires and pool fires is explained by the heat balance analysis of the fuel layer. A model for the spill fire burning rate was proposed accordingly. The results calculated with the presented model are closer to the measured data than those calculated with pool fire models.     

上海市人口分布变动的空间特征分析

空间自相关分析是一种空间统计的方法。可以揭示区域变量的空间结构形态。通过对2000-2003年期间上海市乡镇人口密度变化率的空间相关性分析，发现上海市近几年人口分布空间变动格局表现为以中心城区为中心的环状分布模式，中心城区和远郊区人口密度变化小。人口增长缓慢，而近郊区人口密度变化大，人口增长迅速。全市人口密度变化率存在着显著的空间集聚现象。四种类型的空间关联在空间分布上具有明显的规律性。研究结果表明，目前上海市人口郊区化趋势明显。高人口密度区域在不断向外扩张，人口分布与经济、交通等社会发展因素的关系日益密切。这些研究结果说明利用空间自相关统计方法能够扩展和加强对人口分布空间模式的研究．从而为经济总体布局和城市化建设提供辅助参考作用。     

Effect of bioethanol and thermal barrier coating on the performance of dual fuel engine operating on Honge oil methyl ester (HOME) and producer gas induction

Alternative fuels have numerous advantages compared to fossil fuels as they are renewable, biodegradable; provide energy security and foreign exchange saving besides addressing environmental concerns and socio-economic issues as well. Renewable fuels can be used predominantly as fuel for both transportation and power generation applications. Improved engine performance with reduced engine exhaust emissions is a major research objective in engine development. Today, the use of biomass derived producer gas is more relevant for addressing rural power generation and is a promising technique for controlling both nitric oxide (NO_x) and soot emission levels. In view of this, exhaustive experiments on the use of Honge oil methyl ester (HOME)–Producer gas in a dual fuel engine have been carried out with an intension of improving its fuel efficiency. This paper mainly presents results on a single cylinder four stroke direct injection diesel engine operated in dual fuel mode using HOME–Producer gas combination with and without bio-ethanol addition and thermal barrier coating (TBC). Further, the results were compared with diesel–producer gas mode of operation. Experimental investigation on dual fuel operation using HOME+5% bioethanol (BE5)–Producer gas operation with TBC showed 12.35% increased brake thermal efficiency with decreased hydrocarbon and carbon monoxide emissions and increased NO_x emission levels compared to HOME–Producer gas mode of operation.     

碱片—离子色谱法测定大气中硫酸盐化速率方法探讨

实验证实碱片－离子色谱测定大气中硫酸盐化速率方法操作简便快速，准确可靠，最低检出浓度可达０．１ｍｇ／Ｌ，可替代碱片－重量法测定。     

混合菌对石油的降解

从含油污水中分离得到4株能高效降解石油的微生物菌株(X2、X3、X4、X5),经鉴定,4株菌分别属于黄单胞菌属(Xanthomonas sp.)、动胶菌属(Zoogloea sp.)、芽孢杆菌属(Bacillus sp.)和邻单胞菌属(Plesiomonas sp.).通过观察4株菌在原油培养基中的生长变化过程,确定了其中的优势菌;并对4株菌进行复配实验以确定各株菌混合后的石油降解效果;用正交实验法确定达到最佳石油降解效果各菌的投加量;通过对残油的Gc-MS测定分析,确定各菌在降解石油时所起的作用.结果表明,混合菌株中菌X4为优势菌,且有高的降解效果(达68,60％),其它3株降解率不高的菌混合投加也能达到较高的降解效果(达63.17％),菌X4是混合菌株维持高降解率的关键;达到最佳降解效果的各菌投加量分别为0.1％、0.1％、0.5％、2.0％;菌X2和菌X3降解C12-C16直链烃和少量支链烃,菌X4和菌X5对C12-C22直链烃有好的降解效果.图2表4参10     

Potassium carbonate-based ternary transition temperature mixture (deep eutectic analogues) for CO2 absorption: Characterizations and DFT analysis

•Addition of hindered amine increased thermal stability and viscosity of TTTM. •Addition of hindered amine improved the CO₂ absorption performance of TTTM. •Good the CO₂ absorption of recycled solvents after two regenerations. •Important role of amine group in CO₂ absorption of TTTM confirmed by DFT analysis. Is it possible to improve CO₂ solubility in potassium carbonate (K₂CO₃)-based transition temperature mixtures (TTMs)? To assess this possibility, a ternary transition-temperature mixture (TTTM) was prepared by using a hindered amine, 2-amino-2-methyl-1,3-propanediol (AMPD). Fourier transform infrared spectroscopy (FT-IR) was employed to detect the functional groups including hydroxyl, amine, carbonate ion, and aliphatic functional groups in the prepared solvents. From thermogravimetric analysis (TGA), it was found that the addition of AMPD to the binary mixture can increase the thermal stability of TTTM. The viscosity findings showed that TTTM has a higher viscosity than TTM while their difference was decreased by increasing temperature. In addition, Eyring’s absolute rate theory was used to compute the activation parameters (ΔG*, ΔH*, and ΔS*). The CO₂ solubility in liquids was measured at a temperature of 303.15 K and pressures up to 1.8 MPa. The results disclosed that the CO₂ solubility of TTTM was improved by the addition of AMPD. At the pressure of about 1.8 MPa, the CO₂ mole fractions of TTM and TTTM were 0.1697 and 0.2022, respectively. To confirm the experimental data, density functional theory (DFT) was employed. From the DFT analysis, it was found that the TTTM+ CO₂ system has higher interaction energy (|ΔE |) than the TTM+ CO₂ system indicating the higher CO₂ affinity of the former system. This study might help scientists to better understand and to improve CO₂ solubility in these types of solvents by choosing a suitable amine as HBD and finding the best combination of HBA and HBD.