溶剂萃取法从活性炭滤泥中回收增塑剂

本工作用溶剂萃取法从炭泥中回收增塑剂,通过小试筛选最佳的溶剂,确定工艺条件;在年产百万吨级的工业装置上进行生产性试验,结果为抽出率达炭泥量的50％以上,溶剂回收率达90％以上,回收的增塑剂产品达到部标二级品标准.     

利用赤泥和造纸黑液研制散煤固硫助燃剂

根据钙系固硫剂固硫原理 ,将高CaO含量赤泥加入散煤中燃烧 ,发现其能够起到固硫的效果。但是赤泥的加入影响原煤的发热量 ,因此利用高有机质含量的造纸黑液来弥补其发热量的损失 ,从而研制成功了固硫助燃剂。试验结果表明 :固硫助燃剂能够起到对燃煤固硫助燃的效果 ,具有良好的应用前景     

基于APCS-MLR和PMF模型的赤泥堆场周边耕地土壤重金属污染源解析

为探究重庆某赤泥堆场周边耕地土壤重金属污染特征和来源,分析土壤中8种重金属元素（Cd、Cr、Hg、Ni、Pb、As、Cu和Zn）含量和空间分布特征,利用单因子污染指数法和内梅罗综合污染指数法对土壤重金属污染特征进行评价,并在相关性分析的基础上采用APCS-MLR和PMF模型定量解析重金属来源.结果表明,除土壤Cr外,其他7种重金属元素含量均值均高于重庆市土壤背景值.土壤重金属整体处于中度污染水平,其中Cd、Hg和As为中度污染,Pb、Cu、Ni和Zn为轻度污染.土壤Cr、Ni、Pb、Cu和Zn空间分布格局相似,相互间呈极显著正相关（P < 0.01）;Cd、Hg和As空间分布特征有较大差异,且相互间相关性不显著（P > 0.05）.源解析表明,研究区土壤重金属来源较为复杂,APCS-MLR和PMF模型均能解析出4种相同的污染源,分别为赤泥堆场渗滤排放和自然来源、火力发电排放源、农业活动与自然来源和有色金属冶炼排放源.两种模型源解析结果差异较小,APCS-MLR模型中4种污染源贡献率分别为51.8%、18.0%、15.9%和14.3%,而在PMF模型中分别为45.9%、12.8%、21.5%和19.8%.     

赤泥基纳米零价铁对多金属污染土壤修复效果

为实现重金属复合污染（Pb、Zn、Cu和Cd）土壤同步修复,构建土壤-小白菜体系,探究赤泥（RM）、纳米赤泥（RMn）以及纳米赤泥负载纳米零价铁（RMn-nZVI）这3种不同赤泥基钝化剂对Pb、Zn、Cu和Cd复合污染土壤的修复效果与机制,并考察土壤中Pb、Zn、Cu和Cd形态分布对小白菜积累Pb、Zn、Cu和Cd的控制作用.结果显示,3种钝化剂施用可显著提高土壤pH,降低土壤酸可提取态（F1）Pb、Zn、Cu和Cd含量,增加残渣态（F4）含量,最终钝化效果表现为：RMn-nZVI>RMn>RM.此外,3种钝化剂显著降低了小白菜可食用部分Pb、Zn、Cu和Cd的积累,其中RMn-nZVI处理下降低程度最高,Pb、Zn、Cu和Cd含量分别下降35.11%、45.05%、69.52%和59.63%.结果表明,纳米赤泥负载纳米零价铁新型钝化材料在重金属复合污染土壤修复领域具有一定的应用潜力.     

Assessment of hydrocarbon emissions from diesel invert mud residues treated in a bioreactor

Hydrocarbon emissions from a diesel invert mud residue (DIMR) were monitored while the hydrocarbons were being biodegraded in a solid‐phase bioreactor. Five to twenty percent of the reduction in diesel hydrocarbons was attributed to evaporation depending on the treatment, i.e. homogenization, cultivation, and aeration. Most of these volatile hydrocarbons were linear C₈ — C₁₂ alkanes and one‐ring aromatics. Of the treatments aeration had the largest effect on emissions; forced air through the bottom of the bioreactor cells increased emissions by three times over that of the non‐aerated cells. Cultivation increased hydrocarbon emission concentration as much as twofold over the pre‐cultivation value, however, emissions returned to the original levels within 12 hours. Homogenization had the least effect of all treatments. Diurnally, the emission rate was 40% higher in late afternoon than at midnight; the cause of which was probably atmospheric fluctuations such as temperature and solar radiation. The effects of daily atmospheric fluctuations were empirically modeled and taken into account for determining the total volume of emissions.     

高效絮凝剂制备的前期浸取研究

我国油田多采用絮凝剂处理含油污水。为得到高效、廉价的絮凝剂,使用赤泥最优化制备聚合氯化铝铁。通过化学分析法和X射线衍射分析,得出赤泥中铝﹑铁元素含量。正交实验结果表明:影响Fe溶出的因素由强到弱依次为盐酸用量系数﹑反应温度﹑目数和反应时间,最佳浸出条件为目数80～120、液固比5.5、反应温度95℃、反应时间3.5h。     

高浓度钻井废泥浆处理工艺的试验研究

为实现钻井泥浆无害化处理,提出了"酸化破胶-固液分离-催化氧化-微生物降解"的处理方法,并采用钻井现场废泥浆进行了系列试验研究。结果表明:泥浆密度调节为1.15 kg/dm3,酸化pH≤3,固液分离效果最佳;过滤分离后固相浸毒液达到国家排放标准;液相经Fenton氧化、微生物降解后,COD将降低到110 mg/L以下。该方法运行成本低,处理彻底无隐患,为进一步工业化试验奠定了基础。     

Low levels of toxic elements in Dead Sea black mud and mud-derived cosmetic products

Natural muds used as or in cosmetics may expose consumers to toxic metals and elements via absorption through the skin, inhalation of the dried product, or ingestion (by children). Despite the extensive therapeutic and cosmetic use of the Dead Sea muds, there apparently has been no assessment of the levels of such toxic elements as Pb, As, or Cd in the mud and mud-based products. Inductively coupled plasma mass spectrometry analysis of eight toxic elements in samples collected from three black mud deposits (Lisan Marl, Pleistocene age) on the eastern shore of the Dead Sea in Jordan revealed no special enrichment of toxic elements in the mud. A similar analysis of 16 different commercial Dead Sea mud cosmetics, including packaged mud, likewise revealed no toxic elements at elevated levels of concern. From a toxic element standpoint, the Dead Sea black muds and derivative products appear to be safe for the consumer. Whatever the therapeutic benefits of the mud, our comparison of the elemental fingerprints of the consumer products with those of the field samples revealed one disturbing aspect: Dead Sea black mud should not be a significant component of such items as hand creams, body lotions, shampoo, and moisturizer.     

白泥在2×420t/h燃煤锅炉烟气脱硫系统的应用研究

对白泥在某热电公司2×420t/h燃煤锅炉烟气脱硫系统的应用进行试验研究,结果发现,白泥脱硫能力优于石灰石,且其能够提高系统的灵活性和经济性。化学分析结果表明,白泥中CaCO3含量低于石灰石,但碱性、MgO含量、Cl-含量均和活性高于石灰石;白泥供浆石膏的含水率和Cl-含量高于石灰石供浆石膏,二者在颜色和微观结构上也有一定差异,其他化学成分相差不大,但通过优化运行条件能够实现降低石膏含水率和Cl-含量的目的。虽然选用白泥作为脱硫剂会对脱硫系统产生一定影响,但从脱硫能力和经济效益上看,其明显优于石灰石。     

铬的浸出毒性试验方法研究

以铬为分析指标,探讨了钻井废充泥浆在不同的提取剂、没的提取时间、不同的固液比以及不同的提取方式下铬的浸出毒性大小,提出了适合评价钻井废充泥浆中铬的浸出毒性的试验方法。