炼厂含油污泥与石油焦共成浆性及其影响因素

我国所加工的原油重质化和劣质化现象日益严重,导致以高硫石油焦、含油污泥为代表的副产物产量大幅增加,对生态环境构成了潜在威胁. 为利用成熟的水煤浆气化工艺对废物无害化处理,进行了炼厂含油污泥与石油焦制备高性能混合浆液的研究. 采用干磨湿配制浆工艺,考察了含油污泥与石油焦的共成浆性,分析了石油焦粒度分布、含油污泥添加量、温度、pH等对成浆性的影响. 结果表明:石油焦颗粒疏水性较强、比表面积小,其单独成浆时最佳粗细颗粒质量比为5.5∶4.5;含油污泥与石油焦共成浆时,其最佳添加量为3.0%;在30℃,pH为7~9条件下,可制得表观黏度低于1000mPa·s,稳定时间超过48h,流动性较好的混合浆液,可满足水煤浆气化无害化工艺的进料要求.      

An extension of Multiple Greek Letter method for common cause failures modelling

Common cause failure describes a condition where several components share the same source of failure that causes them to fail or become unavailable simultaneously. The objective of this paper is to present an improved approach to common cause failure modelling within reliability analyses. The currently used methods allow one component to share common characteristics with only one group of components, which may be affected by the same source of failure. Therefore, an improved method was developed, where components can be assigned to several groups of components that are susceptible to faulty operation with respect to their similar characteristics. A mathematical derivation of the method is presented and the theory is applied to smaller theoretical samples and to a simplified real example. The results show that the new method enables a more detailed reliability analysis. The results prove that consideration of common cause failures using the improved method may decrease the system reliability compared to traditional common cause failure consideration. The system reliability decreases more, if the redundant components have more similarities and are therefore assigned to several common cause failure groups.     

Duct-venting of dust explosions in a 20 L sphere at elevated static activation overpressures

Ducts are often recommended in the design of dust explosion venting in order to discharge materials to safe locations. However, the maximum reduced overpressure increases in a duct-vented vessel rather than in a simply vented vessel. This needs to be studied further for understanding the duct-venting mechanism. Numerous duct-vented dust explosion experiments were conducted, using a 20 L spherical chamber at elevated static activation overpressures, ranging from 1.8 bar to 6 bar. Duct diameters of 15 mm and 28 mm, and duct lengths of 0 m (simply venting), 1 m and 2 m, were selected. Explosion pressures both in the vessel and in the duct were recorded by pressure sensors, with a frequency of 5 kHz. Flame signals in the duct were also obtained by phototransistors. Results indicate that the secondary explosion occurring in the duct increases the maximum reduced overpressure in the vessel. The secondary explosion is greatly affected by the duct diameter and static activation overpressure, and hence influences the amplification of the maximum reduced overpressure. Larger static activation overpressure decreases the severity of the secondary explosion, and hence decreases the increment in the maximum reduced overpressure. The secondary pressure peak is more obvious as the pressure accumulation is easier in a duct with a smaller diameter. However, the increment of the maximum reduced overpressure is smaller because blockage effect, flame front distortion, and turbulent mixing due to secondary explosion are weaker in a narrow duct. The influence of duct length on the maximum reduced overpressure is small at elevated static activation overpressures, ranging from 1.8 bar to 6 bar at 15 mm and 28 mm duct diameters.     

Genotoxic effects of two different classes of insecticide in developing chick embryos

Pesticides provide considerable protection against pest population; however, rampant accumulation of these chemicals into varied habitats across the globe necessitates the need for a careful screening of each chemical due to toxic manifestations. In the current study, the genotoxic potential of two different classes of commercial insecticides – chlorpyrifos and cypermethrin combination and Spinosad, a naturalyte were compared. Rhode Island Red chick embryos were exposed to different doses of either of these insecticides individually, by in ovo treatment. Genotoxicity was then evaluated through micronucleus (MN) test and Comet assay. The combination insecticide exposure at low doses of 0.05 and 0.1 μg/egg induced DNA damage as evidenced by an increased tail moment in the Comet assay. Further, the presence of micronucleated erythrocytes and also various abnormal cells including dacryocytes, microcytes, erythroplastids, squashed/notched nuclei, and spindle-shaped erythrocytes in the blood smear consolidates indicate the presence of insecticide-induced genotoxicity. Spinosad, however, was found only mildly genotoxic but at a high dose of 1.5 mg/egg. The results indicate that usage of naturalyte insecticide may be a better option to minimize the harmful effects of chemical insecticides.     

软锰矿浆烟气同步脱硫脱硝资源化利用新工艺

燃煤烟气中的SO2和NOx是大气中重要的污染物,开发高效、经济的同步脱硫脱硝技术是环保领域的研究热点。针对现有同步脱硫脱硝技术存在的氧化剂成本较高和产物不能资源化利用等突出问题,提出了软锰矿浆烟气同步脱硫脱硝,并副产硫酸锰和硝酸锰的资源化新工艺。研究结果表明:软锰矿浆可以有效的脱除烟气中的SO2和NOx,反应产物分别为硫酸锰和硝酸锰。在烟道中注入臭氧,将难溶于水的NO快速氧化为NO2,可大大提高脱硝效率,在O3/NO=1.2的条件下可以达到72%的脱硝率、90%的脱硫率和85%的锰浸出率;吸收液经过空气氧化除铁和加入铜试剂除重金属后,结晶分离溶液得到的硫酸锰和硝酸锰可分别达到HG/T 2962—1999标准的硫酸锰产品和HG/T 3817—2006标准的工业硝酸锰产品要求。该工艺实现了SO2和NOx污染治理与低品位软锰矿资源化利用的双重目的,为SO2和NOx的资源化污染治理技术的开发和应用提供了新的思路。     

A comprehensive model to estimate the simultaneous release of acidic and basic gaseous pollutants from swine slurry under different scenarios

Swine slurry is a source of atmospheric pollutants. Emissions of basic and acidic compounds from slurry are largely dependent on the surface pH. In a storage system, the pH at the surface layers changes over time due to the volatilisation of ammonia (NH₃), carbon dioxide (CO₂) and acetic acid (HAc). In this article, a comprehensive gas emission–pH (GE–pH) coupled model is proposed to describe the simultaneous release of acidic and basic gaseous pollutants from swine slurry. The model was applied to describe the release of NH₃, CO₂, HAc and hydrogen sulphide (H₂S) from standard slurries stored in animal houses, outside storage tanks and lagoons. The modelled results agreed well with values reported in the literature and could be reasonably interpreted. The key parameters affecting the release of gases were: initial pH, initial concentration of total ammonium nitrogen and inorganic carbon, slurry temperature and air velocity. This study suggests that future modelling studies on gas emissions from animal slurry should consider the concentration of inorganic carbon and the frequency in which the slurry surface is mixed or altered, because they affect the surface pH and the release of gaseous pollutants from slurry.     

常温常压KBH4还原法快速脱除水煤浆中的硫

使用KBH4还原法脱除水煤浆中的硫.在常温常压,KBH4浓度为2.0 mmol.L-1、煤炭粒径109μm、处理时间10 min、搅拌速度为200 r.min-1的条件下,低硫水煤浆中煤炭的总脱硫率可以达到43.0%.而且硫酸盐硫的脱除率约47.8%,黄铁矿硫的脱除率约55.4%;同时有机硫的脱除率约23.9%.硼氢化钾还原法相比其它传统化学脱硫方法,对有机硫和无机硫脱除均有作用,试剂用量少,反应条件温和,脱硫速度快,热值的损耗小,处理后水煤浆中煤炭的热值有所提高,起燃温度降低.     

发酵液回流对餐厨垃圾厌氧消化的影响

针对厌氧发酵液回流可提高厌氧系统性能,而不适的回流比例又会造成系统酸化的现象,采用单相连续反应器研究了发酵液回流及不同回流比对餐厨垃圾厌氧消化过程的影响。结果表明:在1 gVS/L的有机负荷下进行三种比例(10%、30%、50%)的发酵液回流使系统日平均产气量比不回流阶段分别提高0.7%、13.0%、4.9%,且对气体甲烷含量无显著影响。回流使VFA降解更充分,也使系统缓冲能力得到调节,但在较高的回流比(50%)下会造成Na+积累从而抑制系统产气性能。     

基于GA-ELM浆体管道输送临界流速预测模型研究

针对浆体管道输送临界流速预测难度大、精确度低等技术难题,提出了基于极限学习机(ELM)的临界流速预测模型,用训练集对模型进行训练,以验证集预测值的均方误差作为适应度函数,利用遗传算法(GA)对ELM模型参数进行优化,应用优化得到的ELM模型对预测集进行预测。以某矿山为例,模型参数优化结果如下:隐含层节点数L为400,输入权值ai、偏置向量bi最优组合下预测结果适应度为0.0201。采用优化的ELM模型对预测集进行预测,预测结果的最大相对误差x=3.96%,平均相对误差y=1.58%,对比BP神经网络(x=12.95%)和SVM模型(x=3.19%),表明ELM模型更加精确、高效。     

不同喷油策略对柴油-四氢呋喃混合燃料燃烧和排放的影响

为了解决环境污染和能源短缺等问题,本研究针对四氢呋喃作为一种含氧替代燃料展开研究.在一台六缸增压柴油机上开展了不同喷油策略下四氢呋喃和柴油混合燃料对柴油机燃烧和排放的影响研究,所用3种燃料分别为：纯柴油、5%四氢呋喃和95%柴油、15%四氢呋喃和85%柴油混合燃料（混合比例均为体积比）,以原机国六脉谱图为基准调节主喷时刻和喷油压力.结果表明,添加5%四氢呋喃使燃油消耗率增加,有效热效率降低,当加入15%四氢呋喃后燃油消耗率进一步升高,有效热效率相比于添加5%四氢呋喃有一定程度改善,但仍低于纯柴油燃料;当喷油压力高于100 MPa时,混合燃料的燃油消耗率和有效热效率随喷油压力的提高基本保持不变.四氢呋喃加入使小负荷下NO_x、CO和HC排放增加;大负荷下使NO_x排放增加,CO和HC排放逐渐降低,各工况下的碳烟排放均降低.由此可见,柴油-四氢呋喃混合燃料的有效热效率相比于纯柴油降低了1%~2%,加入四氢呋喃可有效降低碳烟排放和改善部分工况下的气体污染物排放.