Utilization of cement kiln dust (CKD) in cement mortar and concrete—an overview

Solid waste management is one of the major environmental concerns around the world. Cement kiln dust (KKD), also known as by-pass dust, is a by-product of cement manufacturing. The environmental concerns related to Portland cement production, emission and disposal of CKD is becoming progressively significant. CKD is fine-grained, particulate material chiefly composed of oxidized, anhydrous, micron-sized particles collected from electrostatic precipitators during the high temperature production of clinker. Cement kiln dust so generated is partly reused in cement plant and landfilled. The beneficial uses of CKD are in highway uses, soil stabilization, use in cement mortar/concrete, CLSM, etc.Studies have shown that CKD could be used in making paste/mortar/concrete. This paper presents an overview of some of the research published on the use of CKD in cement paste/mortar/concrete. Effect of CKD on the cement paste/mortar/concrete properties like compressive strength, tensile strength properties (splitting tensile strength, flexural strength and toughness), durability (Freeze–thaw), hydration, setting time, sorptivity, electrical conductivity are presented. Use of CKD in making controlled low-strength materials (CLSM), asphalt concrete, as soil stabilizer, and leachate analysis are also discussed in this paper.     

Satellite and Ground Based Monitoring of Aerosol Plumes

Plumes of atmospheric aerosol have been studied using a rangeof satellite and ground-based techniques. The Sea-viewing WideField-of-view Sensor (SeaWiFS) has been used to observe plumesof sulphate aerosol and Saharan dust around the coast of theUnited Kingdom. Aerosol Optical Thickness (AOT) was retrievedfrom SeaWiFS for two events; a plume of Saharan dusttransported over the United Kingdom from Western Africa and aperiod of elevated sulphate experienced over the Easternregion of the UK. Patterns of AOT are discussed and related tothe synoptic and mesoscale weather conditions. Furtherobservation of the sulphate aerosol event was undertaken usingthe Advanced Very High Resolution Radiometer instrument(AVHRR). Atmospheric back trajectories and weather conditionswere studied in order to identify the meteorologicalconditions which led to this event. Co-located ground-basedmeasurements of PM₁₀ and PM_2.5 were obtained for 4sites within the UK and PM_2.5/10 ratios were calculatedin order to identify any unusually high or low ratios(indicating the dominant size fraction within the plume)during either of these events. Calculated percentiles ofPM_2.5/10 ratios during the 2 events examined show thatthese events were notable within the record, but were in noway unique or unusual in the context of a 3 yr monitoringrecord. Visibility measurements for both episodes have beenexamined and show that visibility degradation occurred duringboth the sulphate aerosol and Saharan dust episodes.     

Use of Natural 35S to Trace Sulphate Cycling in Small Lakes,Flattops Wilderness Area,Colorado, U.S.A.

Measurements of the cosmogenically-produced ³⁵S, a radioisotope of sulphur (t_1/2 = 87 days), are reported for the Ned Wilson Lake watershed in Colorado. The watershed contains two small lakes and a flowing spring presumed to be representative of local ground water. The watershed is located in the Flattops Wilderness Area and the waters in the system have low alkalinity, making them sensitive to increases in acid and sulphate deposition. Time series of ³⁵S measurements were made during the summers of 1995 and 1996 (July–September) at all three sites. The system is dominated by melting snow and an initial concentration of 16–20 mBq L^-1 was estimated for snowmelt based on a series of snow samples collected in the Rocky Mountains. The two lakes had large initial ³⁵S concentrations in July, indicating that a large fraction of the lake water and sulphate was introduced by meltwater from that year's snowpack. In 1995 and 1996, ³⁵S concentrations decreased more rapidly than could be accounted for by decay, indicating that other processes were affecting ³⁵S concentrations. The most likely explanation is that exchange with sediments or the biota was removing ³⁵S from the lake and replacing it with older sulphate devoid of ³⁵S. In September of 1995 and 1996, ³⁵S concentrations increased, suggesting that atmospheric deposition is important in the sulphate flux of these lakes in late summer. Sulphur-35 concentrations in the spring water were highly variable but never higher than 3.6 mBq L^-1 and averaged 2 mBq L^-1. Using a simple mixing model, it was estimated that 75% of the spring water was derived from precipitation of previous years.     

Development of Stream Water Chemistry during Spring Melt in a Northern Hardwood Forest

The role of snowmelt and subsurface hydrology in determiningthe chemistry of a small headwater stream in the TurkeyLakes Watershed (TLW) was evaluated for the spring meltperiods 1992 to 1996. Spring runoff is the dominanthydrological event at the TLW each year. Processesoccurring within the snowpack during snowmelt wereprincipally responsible for the above-ground changes inchemical fluxes relative to bulk deposition (the effect ofwinter throughfall was minimal). Large changes in chemicalfluxes occurred below ground. Organic matter decomposition,weathering, nitrification, and element cycling are some ofthe more important below-ground processes that operateduring the snow accumulation and ablation season and controlthe composition of the water ultimately appearing in thestream. Maximum stream discharge was accompanied byelevated concentrations of H⁺, NO₃ ^-, K⁺,NH₄ ⁺, DOC, Al and Mn, but reduced levels ofCa²⁺, Mg²⁺, SO₄ ^2- and SiO₂. Theconcentration-discharge relationships were consistent withwater movement through and above the forest floor duringpeak discharge, a flowpath facilitated by rapid infiltrationof meltwater and the existence of a relatively impermeablelayer in the mineral soil creating a perched water table. Averaged over the five periods of snow accumulation andablation, it was estimated that pre-melt stream flow, andwater routed through the forest floor and through the uppermineral soil contributed 9, 28 and 63%, respectively, ofthe discharge measured at the outlet of the catchment. Theforest floor contribution would be greater at peak dischargeand at higher elevations. An end-member mixing modelestimated concentrations of SO₄ ^2-, NO₃ ^-,Cl^-, Ca²⁺, Mg²⁺, Na⁺ and Al that werecomparable to average values measured in the stream. Othervariables (NH₄ ⁺, H⁺, K⁺ and DOC) wereover-estimated implying retention mechanisms operatingoutside the model assumptions.     

Deposition and Storage of Spheroidal Carbonaceous Fly-Ash Particles in European Mountain Lake Sediments and Catchment Soils

Spheroidal carbonaceous particles(SCPs) are produced only from high temperaturecombustion of fossil-fuels. In mountain lakesystems, they provide an unambiguous indicator ofatmospheric deposition. In order to comparedepositional fluxes of SCPs between mountainareas experiencing various pollutant regimes,intensive bulk deposition sampling was undertakenat five sites across Europe. Catchment soil coresand lake sediment cores were also taken at eachsite to compare SCP storage over the post-industrial period. Atmospheric, sediment and soilSCP data showed similar patterns. Highestcontamination was found in Scotland, Slovakia andSpain with the Austrian site intermediate and themid-Norwegian site least contaminated. A highproportion of accumulated SCPs were found to bestored in catchment soils at each site.Therefore, a significant increase in soilerosion, possibly as a result of future climatechange, could lead to the input of largequantities of catchment stored SCPs and, byimplication, other atmospherically depositedcontaminants to the lake ecosystem.     

The Characterisation of Settled Dust by Scanning Electron Microscopy and Energy Dispersive X-ray Analysis

Settled dust has been collected inside the main foyers ofthree University buildings in Wolverhampton City Centre,U.K. Two of the three buildings are located in a streetcanyon used almost exclusively by heavy duty dieselvehicles. The dust was collected on adhesive carbonspectro-tabs to be in a form suitable for analysis byscanning electron microscope and energy dispersive X-rayanalysis. Using these analytical techniques, individualparticle analysis was undertaken for morphology andchemistry. Seasonal variations and variations due tolocation were observed in both the morphologicalmeasurements and chemical analysis. Many of the differencesappear attributable to the influence of road traffic, inparticular, the heavy duty diesel vehicles, travellingalong the street canyon.     

Trends in the Water Chemistry of High Altitude Lakes in Europe

Here we present the chemical trends of seven high altitude lakes, analysed within the AL:PE and MOLAR Projects of the EU (1999) and selected on the basis of the availability of complete and reliable data for the period 1984–1999. The lakes are representative of the Scandinavian Alps, the Cairngorm Mountains in Scotland, the Alps and the Pyrenees. Significant trends were identified for some indicators of acidification, for instance pH and alkalinity, but not all lakes reacted similarly to decreasing depositions of sulphate and base cations. Differences in lake response are discussed in relation to recent variations of atmospheric deposition chemistry and associated changes in climatic conditions. Beside individual variations of the studied lakes, depending, among other things, on altitude and morphology, catchment characteristics and climate trends play a major role for the reaction of high altitude lakes on changes in atmospheric depositions.     

韶钢新石灰窑烟气除尘技术的应用

韶钢新石灰窑烟气除尘系统要用旋风除尘器、金属管式换热器、高效陶瓷多管除尘器的组合方式。介绍了该系统的设计参数、工艺流程、主要设备及其功能。     

静电除尘在烧结机头烟尘治理中的应用

通过对安钢烧结机一、二期工程中烧结机头电除尘器结构性能和运行效果对比，结合安钢实际运行情况，分析了一期工程中电除尘器的运行存在的问题，重点对电除尘器的结构特点进行阐述，以提供一种适用于烧结机头烟尘治理的电除尘技术。     

清洁安全的井下作业环境

根据煤矿井下粉尘的特性及其危害和对井下空气污染的状况，提出针对井下各产尘源的治理措施和治理方法，通过对粉尘污染的治理，改善煤矿工人的作业环境，实现清洁生产，降低矿工职业病发病率和事故率，提高煤矿生产效益和经济效益。