微波法处理含铬废渣的可行性分析

微波辐照解毒铬渣是一项新技术，为考察该技术应用的可行性，本文对铬渣解毒前后性状的变化进行了讨论。结果表明，该技术能较完全地使高价铬转化为低价铬，解毒渣中铬主要以三价形态存在，铬渣毒性得到消除；解毒渣浸出液中Cr^6＋浓度远低于国家危险废物鉴别标准，解毒渣已不属于危险固体废弃物，其在环境条件下可安全存放。说明该技术具有应用前景。     

镍渣制备建筑用微晶玻璃的初步研究

对从镍渣中提取铁同时制备建筑用微晶玻璃的进行了研究.结果表明,熔渣中铁的质量分数可以降到0.5%左右,满足制备微晶玻璃的要求.对微晶玻璃样品进行了显微镜、X射线衍射、扫描电镜分析.其主晶相是透辉石(CaO·MgO·2SiO2),晶体的形貌为短柱状,分布均匀.本文所介绍的制备工艺是可行的.     

Arsenic contamination in the Kanker district of central-east India: geology and health effects

This paper identifies newer areas of arsenic contamination in the District Kanker, which adjoins the District Rajnandgaon where high contamination has been reported earlier. A correlation with the mobile phase episodes of arsenic contamination has been identified, which further hinges on the complex geology of the area. Arsenic concentrations in both surface and groundwater, aquatic organisms (snail and water weeds) soil and vegetation of Kanker district and its adjoining area have been reported here. The region has been found to contain an elevated level of arsenic. All segments of the ecoysystem are contaminated with arsenic at varying degrees. The levels of arsenic vary constantly depending on the season and location. An analysis of groundwater from 89 locations in the Kanker district has shown high values of arsenic, iron and manganese (mean: 144, 914 and 371 μg L⁻¹, respectively). The surface water of the region shows elevated levels of arsenic, which is influenced by the geological mineralised zonation. The most prevalent species in the groundwater is As(III), whereas the surface water of the rivers shows a significant contamination with the As(V) species. The analysis shows a bio-concentration of the toxic metals arsenic, nickel, copper and chromium. Higher arsenic concentrations (groundwater concentrations greater than 50 μg L⁻¹) are associated with sedimentary deposits derived from volcanic rocks, hence mineral leaching appears to be the source of arsenic contamination. Higher levels of arsenic and manganese in the Kanker district have been found to cause impacts on the flora and fauna. A case study of episodic arsenical diarrhoea is presented.     

高炉渣制备光催化剂及其催化活性的研究

以废弃的冶金高炉渣为原料,采用混酸酸溶-水热合成法制备了光催化剂,并对其进行了SEM、UV-Vis、XRD、比表面积等物性测试分析;通过处理甲基橙模拟废水,探讨了制备过程中渣酸比、混酸配比、渣用量、溶渣时间等条件对高炉渣制光催化剂活性的影响。将所制光催化剂与P25光催化剂进行对比分析,结果表明,高炉渣制光催化剂不仅具有较高的光催化活性,而且制备成本低廉,仅为P25光催化剂的1/10,这对于冶金高炉渣的循环再利用及光催化氧化技术的工业化应用具有重要的实际意义。     

理化因素对锰细菌Arthrobacter chlorophenolicus MN1409氧化Mn2+的影响

Arthrobacter chlorophenolicus MN1409是1株分离自锰矿样品的高效锰氧化细菌。为了建立该菌株氧化Mn2+的适宜条件,研究了接种量、装液量、摇床转速、温度、pH值、Fe2+初始质量浓度和Mn2+初始质量浓度等理化因素对其锰氧化效率的影响。结果表明,接种量、装液量、转速和Mn2+初始质量浓度在一定范围内变化对锰氧化率影响不大;而温度、pH值和Fe2+初始质量浓度变化对锰氧化率有较大影响。当接种量为4%,装液量为60 mL,温度为25℃,摇床转速为100r/min,pH值为7,且有一定的Fe2+存在时,Arthrobacter chlorophenolicusMN1409对锰的氧化效率最高。     

Laboratory investigation of Waelz slag stabilization

Electric Arc Furnace dusts are considered hazardous waste due to their high heavy metals content (zinc, lead, etc.). The Waelz process is one of the most efficient technologies, in terms of capacity and quality, able to recover nearly the 90% of zinc contained in such EAF dusts. Unfortunately, the resulting slag still has eco-compatibility problems, although its mechanical and chemical properties are suitable for civil engineering applications. Stabilization tests, by quartz addition, were performed on EAF dusts in a laboratory furnace. Temperature, treatment time and cooling rate were varied in order to define the best conditions for regulating the formation of a stable microstructure able to hinder the release of substances. Microstructural characterization was carried-out using SEM and XRD analysis. Leaching tests were performed according to EN 12457-2 standards and water analyses were performed using ICP-OES. The best chemical stability was achieved when dust powders were mixed with 20% of silica and water-cooled.     

淋滤条件对矿物废渣中铊释放的影响

研究了淋滤时间、淋滤液pH值、粒径及滤速对沉灰渣中铊释放的影响，结果表明：上述因素均能影响废渣表面铁氧化物的水解，这种水解支配着铊释放的过程；滤速及碱性颗粒的参予能显著影响废渣表面的水解作用。     

电解锰废水中锰（Mn^2＋）和氨—氮（NH3—N）的处理

本文讨论了沉淀法和空气提气法去除电解锰废水中含有的锰(Mn~(2+))和氨-氮(NH_3-N),并研究了该方法的最佳条件,为废水日排放量在300—400T之间的工厂设计了废水处理路线。结果表明,上述方法处理后的废水中Mn~(2+)和NH_3-N含量达到或低于国家污水排放标准。     

腐殖质对二氧化锰引起的五氯酚转化反应的影响

研究了在二氧化锰催化引起的五氯酚的转化反应中,腐殖质前身化合物的加入对五氯酚去除率的影响,并以p-coumaricacid为代表研究了体系pH值、反应时间、二氧化锰的质量浓度以及腐殖质前生物的浓度和分子结构对去除率的影响。结果表明,反应的最佳pH值范围是4～4.70,去除率在80%左右。五氯酚在24h内去除速率较快,去除率达到75%左右;反应到168h,去除速率趋于0,去除率达到80%左右。相同条件下,无p-coumaricacid的对照体系中,对应的反应时间内去除率仅分别为20%和25%左右。五氯酚的去除率还随二氧化锰质量浓度和p-coumaricacid浓度的增加而增大。当二氧化锰的质量浓度由0增加到100g·L-1时,去除率由0增大为95%;而当p-coumaricacid的浓度由0增加到1mmol·L-1时,去除率由25%增大到100%左右。此外,不同腐殖质前身物的分子结构和浓度对去除率分别起到了提高、不明显改变和降低的作用。     

碱矿渣胶凝材料固化重金属污泥的研究

主要原材料为高炉矿渣的碱矿渣胶凝材料(HAS)、掺3%沸石的HAS、掺5%沸石的HAS、水泥等4种固化材料被用来固化人工合成含铅、镉、铬等重金属的污泥。污泥固化体中污泥与固化材的掺和比例为4:1。实验结果表明,HAS固化剂对重金属污泥的固化效果要好于水泥,其污泥固化体的无侧限抗压强度高于水泥固化体,同时其固化体的重金属浸出量明显低于水泥。沸石的掺入使HAS固化体的重金属浸出量减小,且随着沸石掺加量的增大,HAS固化体的重金属浸出量相应的减少。